Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2002 Hyundai Elantra.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
HYUNDAI IS RECALLING CERTAIN MY 2001-2002 ELANTRA VEHICLES. MOVEMENT OF THE SIDE IMPACT AIR BAG WIRING HARNESS MOUNTED UNDER EACH FRONT SEAT, POSSIBLY CAUSED BY CONTACT FROM MATERIALS PLACED UNDER THE SEAT, MAY RESULT IN AN ELECTRICAL RESISTANCE THAT WOULD CAUSE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) WARNING LIGHT ILLUMINATION.
Consequence: THIS CONDITION ONLY RELATES TO THE DRIVER AND PASSENGER SEAT MOUNTED SIDE IMPACT AIR BAGS AND MAY PREVENT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT DURING A CRASH WHERE SUCH DEPLOYMENT SHOULD OCCUR. NON-DEPLOYMENT OF THE SRS AIR BAGS MAY INCREASE THE RISK OF INJURY TO THE DRIVER AND FRONT PASSENGER UNDER CERTAIN CRASH CONDITIONS.
Remedy: DEALERS WILL INSTALL NEW SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR CLIPS AND REVISED SIDE IMPACT AIR BAG WIRING HARNESS ATTACHMENTS UNDER THE DRIVER'S AND FRONT PASSENGER'S SEATS. THE RECALL IS EXPECTED TO BEGIN DURING THE FOURTH QUARTER OF 2008, AND WILL BE SENT OUT IN SIX MAILINGS. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Component: SUSPENSION:FRONT:CONTROL ARM
HYUNDAI IS RECALLING 160,904 MY 2001-2003 ELANTRA AND MY 2003 TIBURON VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT USED DURING THE WINTER MONTHS IN THESE JURISDICTIONS MAY RESULT IN INTERNAL CORROSION AND THINNING OF THE STEEL IN THE FRONT LOWER CONTROL ARMS. THE CORROSION MAY PROGRESS TO THE POINT WHERE THE LOWER CONTROL ARM'S UPPER AND LOWER PANELS BECOME PERFORATED. A PERFORATED FRONT LOWER CONTROL ARM MAY FRACTURE BETWEEN ITS BALL JOINT ATTACHMENT AND THE FORWARD AND REARWARD PIVOT ATTACHMENTS TO THE CHASSIS.
Consequence: THE FRACTURING OF THE CONTROL ARM COULD AN OWNER'S CONTROL OVER THEIR VEHICLE THAT MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE FRONT LOWER CONTROL ARMS FOR CORROSION DAMAGE. IF SPECIFIED LEVELS OF INTERNAL CORROSION DAMAGE ARE FOUND, THE FRONT LOWER CONTROL ARMS WILL BE REPLACED WITH NEW FRONT LOWER CONTROL ARMS INCORPORATING ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT LOWER CONTROL ARMS DO NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE FRONT LOWER CONTROL ARMS AND WILL TREAT THE FRONT LOWER CONTROL ARMS WITH RUST-PROOFING MATERIALS TO ARREST THE INTERNAL CORROSION PROCESS. THESE PROCEDURES WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 17, 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
I WAS DRIVING THE CAR AND THE MOMENT I TRIED TO STOP AT THE TRAFFIC STOP SIGN THE LOWER ARM CONTROL FROM THE DRIVER SIDE BROKE AND THE WHEEL BROKE AND THE CAR SLID. THANKS GOD IT WAS AT NIGHT AND NO CARS WERE THERE. I REMEMBER THE NIGHT BEFORE I WAS DRIVING ON THE HIGHWAY AND NOTHING HAPPENED. I CALLED MY INSURANCE AND THEY SENT ME A TOWING TRUCK TO MOVE THE CAR. I DIDN'T REPAIR THE CAR BECAUSE IT WAS A BIG MESS. I TOOK SOME PICTURES OF IT AND THE TOWING COMPANY GUY ALSO. I REMEMBER I WENT TO HYUNDAI DEALER AND I WAS LOOKING FOR A PART THEIR AND THEY TOOK MY VIN NUMBER TO CHECK FOR THE PART BUT NEVER TOLD ME ABOUT THE RECALL. CAN HYUNDAI COMPANY GIVE ME SOME MONEY BACK THAT I SPENT FOR TOWING AND LOOSING MY CAR BECAUSE OF THIS INCIDENT. I EVEN PAID FOR THE CAR REGISTRATION WEEKS BEFORE. *TR
WHEN PUMPING GAS I CAN ONLY PUMP ABOUT $1.50 WORTH OF GAS AT A TIME BEFORE IT STARTS COMING BACK OUT AND SPILLING EVERYWHERE. I HAVE TRIED PUMPING GAS WITH THE CAR ON, NOT SAFE I KNOW, AND IT STILL ONLY TAKES ABOUT $1.50 BEFORE IT COMES BACK OUT. I HAVE SPOKEN TO MULTIPLE ELANTRA OWNERS AND THEY ALL HAVE THE SAME ISSUE. IT TAKES ABOUT 20 MINUTES TO FILL UP. THE MORE GAS YOU GET IN YOUR TANK, THE LESS YOU CAN PUMP. FROM THE RESEARCH I HAVE DONE ONLINE IT'S THAT THE EVAP CANISTOR HAS FAILED AND IT'S PUSHING CHARCOAL THRU THE FUEL LINES. WHAT IF THAT GETS INTO THE FUEL TANK AND THE PUMP SUCKS IT UP? DON'T THINK THAT WOULD BE A GOOD THING. BUT THE GAS THAT COMES OUT IS STARTING TO EAT AWAY THE PAINT BECAUSE IT DOES IT MULTIPLE TIMES EACH TIME I'M REFUELING. MY VEHICLE HAS HIGH MILES BUT ALOT OF PEOPLE THAT HAVE THIS ISSUE SAY THEY HAVE BELOW 100K MILES.
MY 2002 HUYNDAI ELANTRA GLS SUDDENTLY THE AIRBAG IS ON SOON ENGINE RUNNING, AND I HAVE BEEN TOLD BY TECHNICIAN THAT THE AIRBAG DEFECTIVE AND IT IS UNDER A RECALL.
The 2002 Hyundai Elantra has 6 NHTSA recalls and 349 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
ON CERTAIN PASSENGER VEHICLES, THE REAR BRAKE TUBES PASS BEHIND THE FRONT SUSPENSION CROSSMEMBER. TWO STEERING GEARBOX MOUNTING BRACKETS ARE WELDED TO THE CROSSMEMBER. ON VEHICLES EQUIPPED WITH AN ANTILOCK BRAKE SYSTEM (ABS), THE REAR BRAKE TUBES COULD CONTACT BOTH STEERING GEARBOX MOUNTING BRACKETS. ON VEHICLES THAT ARE NOT EQUIPPED WITH ABS, THE REAR BRAKE TUBES MAY CONTACT ONLY THE LEFT MOUNTING BRACKET. CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING BRACKETS COULD CAUSE WEAR AND CORROSION THAT COULD RESULT IN BRAKE FLUID LEAKAGE.
Consequence: FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPOSITION THE REAR BRAKE TUBES SO THEY DO NOT CONTACT THE MOUNTING BRACKETS, INSTALL BRAKE TUBE CLIPS TO CONTROL THE LOCATION OF THE REAR BRAKE TUBES, AND APPLY ANTI-CORROSION MATERIAL TO THE TUBES IN THE AREAS WHERE CONTACT WITH THE MOUNTING BRACKETS MAY HAVE OCCURRED. OWNER NOTIFICATION BEGAN ON OCTOBER 13, 2003. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Component: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
SOME PASSENGER VEHICLES CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN ON JUNE 30, 2004. OWNERS SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
Component: FUEL SYSTEM, GASOLINE:STORAGE
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY" A VALVE ON THE FUEL TANK ASSEMBLY MAY NOT CLOSE PROPERLY. IF A VEHICLE ROLLS OVER AND THE FUEL TANK ASSEMBLY VALVE IS NOT PROPERLY CLOSED, FUEL SPILLAGE MAY OCCUR.
Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS SHOULD CONTACT HYUNDAI DE PUERTO RICO AT 1-800-981-0188.
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
ON CERTAIN PASSENGER VEHICLES, THE BRAKE TUBES FOR THE REAR BRAKES CAN CONTACT THE STEERING GEARBOX MOUNTING BRACKETS.
Consequence: CONTACT BETWEEN THE REAR BRAKE TUBES AND THE STEERING GEARBOX MOUNTING BRACKETS MAY RESULT IN REAR BRAKE TUBE WEAR AND CORROSION, INCREASING THE RISK OF BRAKE FLUID LEAKAGE. BRAKE FLUID LEAKAGE COULD RESULT IN REDUCED BRAKING CAPABILITY, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPOSITION THE REAR BRAKE TUBES, INSTALL BRAKE TUBE CLIPS, AND APPLY ANTI-CORROSION MATERIAL TO THE REAR BRAKE TUBES. OWNER NOTIFICATION BEGAN JANUARY 22, 2004. OWNERS SHOULD CONTACT HYUNDAI OF PUERTO RICO AT 1-800-633-5151.
I HAVE NOTED A RECALL #09V125000 RELATED TO THIS MAKE/MODEL/YEAR BUT FOR SOME REASON MY CAR WITH THE EXACT PROBLEM IS NOT PART OF THE RECALL. MY RIGHT FRONT CONTROL ARM COLAPSED. IT WAS COMPLETELY RUSTED THROUGH. WITH THAT SIDE FIXED I TRAVELED ABOUT 3 MILES AND MY LEFT SIDE CONTROL ARM BROKE. MY MECHANIC AND I WERE COMPLEXED, BUT AFTER RESEARCH I FOUND THIS PROBLEM EXIST AND RECALLS ISSUED. AFTER CONTACTING HYUNDA THEY SAID THIS VEHICLE VIN# WAS NOT COVERED. I DON'T UNDERSTAND HOW THIS LIFE THREATENING PROBLEM WAS NOT PART OF THE RECALL. SOMETHING IN THE RECORDS OF THIS CAR MUST BE IN ERROR.
REAR SUSPENSION CROSS MEMBER ROTTED OUT
IT IS HARD TO FILL THE GAS TANK UP. THE FUEL PUMP KEEPS SHUTTING OFF AND YOU HAVE TO SLOWLY FILL THE GAS TANK UP. YOU HAVE TO HOLD THE PUMP TO EVEN GET GAS TO FILL THE TANK.
THE WHOLE FRAME IS RUSTY.
ON OCTOBER 28TH, 2016 THE LOWER, DRIVER'S SIDE, FRONT CONTROL ARM DISINTEGRATED WHILE MY WIFE WAS DRIVING HER ELANTRA IN A PARKING LOT. SHE WAS MAKING A RIGHT TURN TO LEAVE THE LOT WHEN SHE LOST CONTROL OF THE CAR AS IT MADE A "TERRIBLE GRINDING NOISE." THE NEXT DAY I REMOVED THE WHEEL AND DISCOVERED THE CONTROL ARM WAS TORN IN TWO SECTIONS AND BADLY CORRODED. I WENT TO TWO HYUNDAI DEALERS TO TRACK DOWN A NEW PART. NEITHER DEALER MENTIONED THE FACT THAT THIS MODEL HYUNDAI HAD BEEN RECALLED FOR PRECISELY THIS PROBLEM. WHEN I LEARNED OF THIS PROBLEM I CONTACTED HYUNDAI MOTORS. THEY INFORMED ME THAT THE RECALL ONLY APPLIED TO VEHICLES PURCHASED OR REGISTERED IN THE SO-CALLED "SALT BELT" STATES. MY WIFE BOUGHT THIS CAR NEW IN COLORADO AND HAS NEVER DRIVEN IT IN THE "SALT BELT." YET IT SUFFERED THE SAME CORROSION AND FAILURE AS DESCRIBED IN THE RECALL BULLETIN. THIS IS A VERY DANGEROUS FAILURE BECAUSE THE CORROSION IS INSIDE THE CONTROL ARM AND CANNOT BE DETECTED BY A NORMAL VISUAL INSPECTION. I SUSPECT THAT THE FAILURE THAT SHOWED UP YEARS AGO IN THE "SALT BELT" CARS IS NOW APPEARING IN OLDER CARS IN OTHER PARTS OF THE COUNTRY. HYUNDAI APPARENTLY DOES NOT GIVE A [XXX]. I SUGGEST THE NHSTA IMPOSE A NATIONWIDE MANDATORY RECALL OF THESE VEHICLES. IF IT OCCURRED AT HIGHWAY SPEEDS THIS FAILURE WOULD RESULT IN IMMEDIATE LOSS OF CONTROL, RESULTING IN SEVERE INJURY OR DEATH FOR PASSENGERS IN THE CAR. THIS VEHICLE IS A ONE OWNER CAR THAT WAS GARAGED ALL ITS LIFE. IT WAS REGULARLY SERVICED BY A HYUNDAI DEALER. IT SHOWS NO SIGNS OF EXCESSIVE CORROSION IN ANY OTHER AREA OR PART. I AM OUTRAGED THAT HYUNDAI CHOSE TO LIMIT THE RECALL OF THESE VEHICLES TO SELECT STATES. THIS INCIDENT CLEARLY DEMONSTRATES THE PROBLEM IS NOT LIMITED TO VEHICLES EXPOSED TO CORROSIVE CHEMICALS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
AIRBAG LIGHT CAME ON AND REMAINS ON STEADY AS I WAS DRIVING IN RESIDENTIAL SECTION TODAY, AROUND 10PM. IT HAS BEEN 104 DEGREES WITH HUMIDITY FACTOR THE LAST COUPLE OF DAYS.
THERE IS RUST COMING THROUGH THE QUARTER PANELS IN THE FRONT
AIR BAG LIGHT COMES ON WHEN YOU MOVE THE SEAT FORWARD OR BACKWARD. SHOULD BE COVERED BY A RECALL, BUT WHEN I CALL THE DEALER I AM TOLD THAT THERE ARE NOT OPEN RECALLS ON MY VEHICLE. YET, THE RECALL LIST FOR FIXING THE AIR BAG SYSTEM LISTS 2002 HYUNDAI.
MY VEHICLE HAS CONTROL ARM RUST AND PERFORATIONS IN THE SUBFRAME, COVERED UNDER AN EXISTING RECALL. HYUNDAI HAS ADMITTED THAT THE PARTS ARE COVERED UNDER THE RECALL, BUT STATES THAT THEY ARE UNABLE TO REPLACE THE SUBFRAME AND CONTROL ARMS DUE TO RUST DAMAGE ON THE FRAME ITSELF. REPLACING THE DAMAGED PORTIONS OF THE FRAME WILL COST WELL OVER THE PRICE OF THE VEHICLE. IF THE SUBFRAME DID NOT HAVE TO BE REPLACED, THE FRAME WOULD LIKELY HOLD FOR SOME TIME AND NOT REQUIRE REPLACEMENT IN THE NEAR FUTURE. THE FRAME DAMAGE IS ONLY AN IMMEDIATE ISSUE BECAUSE THE RECALL REPAIR NEEDS TO BE DONE. HYUNDAI HAS OFFERED ME TO EITHER REPLACE THE FRAME DAMAGE AT MY OWN EXPENSE SO THEY CAN COMPLETE THE RECALL REPAIR, OR TAKE A BUYOUT EQUAL TO THE KELLY BLUE BOOK VALUE OF THE VEHICLE. OTHER COMPENSATION SUCH AS RENTAL FEES WAS REFUSED. IT HAS TAKEN THEM ~25 DAYS SINCE RECEIVING THE VEHICLE TO MAKE THIS OFFER.
TL* THE CONTACT OWNS A 2002 HYUNDAI ELANTRA. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V533000 (AIR BAGS). THE FAILURE MILEAGE WAS 121,190.
TL* THE CONTACT OWNS A 2002 HYUNDAI ELANTRA. THE CONTACT STATED THAT WHILE DRIVING AT UNKNOWN SPEEDS, THE VEHICLE WOULD LOSE BRAKE FLUID. IN ADDITION, THE CONTACT STATED THAT THE BRAKES WOULD FAIL TO RESPOND. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 165,000.
RANDOM ILLUMINATION OF AIR BAG LIGHT ON DASH WITHOUT EXPLANATION.
Showing 15 of 349 complaints