NHTSA recalls, safety ratings, and consumer complaints for the 2020 Honda Insight.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 1.5L 4 cyl Automatic (variable gear ratios) | 55 | 49 | 52 | $1,150 |
| Overall Rating | |
| Frontal Crash |
Component: ELECTRICAL SYSTEM:PROPULSION SYSTEM:DC/DC CONVERTER
Honda (American Honda Motor Co.) is recalling certain 2020 CR-V Hybrid, Accord Hybrid, and 2020-2021 Insight vehicles. The DC-DC converter may shut down and prevent the 12-volt battery from recharging, possibly resulting in a loss of drive power.
Consequence: A loss of drive power can increase the risk of a crash.
Remedy: Honda will notify owners, and dealers will update the power converter unit (PCU) software, free of charge. The recall began February 12, 2021. Owners can contact Honda customer service at 1-888-234-2138. Honda's number for this recall is K9E.
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Honda (American Honda Motor Co.) is recalling certain 2018-2019 Acura NSX, 2019 Acura RDX, RLX and RLX Sport Hybrid, 2018-2019 Honda Accord, Civic Hatchback, Civic Type R and HR-V, 2019-2020 Insight and 2019 Fit vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.
Remedy: Honda will notify owners and dealers will replace the fuel pump assembly, free of charge. The recall began July 22, 2020. Owners may contact Honda customer service at 1-888-234-2138.
At approximately 148,000 miles the steering would have an intermittent notchy, or sticky, feeling while driving straight. While driving straight at cruising speed, I noticed that the resistance on the left side of the steering wheel was greater than the right side, then the resistance would decrease suddenly (release), and the steering wheel would rotate slightly to the right, but less than 1 degree, so it would be hardly noticeable on video. The issue seems to only present itself after the vehicle is driven 20-40 minutes and when the temperature is 47 degrees or higher. I have noticed it at low speed (15-20mph) and at highway speeds. If I recall correctly, the issue first presented itself when we had our first 60 degree day and I was driving on the highway with the wheel straight. Then as I accumulated miles throughout the weeks, I would notice that it didn't happen on colder days but then happened more often on warmer days. Now that the vehicle has ~148,800 miles on it, and the air temperature is 67 degrees, the issue presented itself this morning (4/1/2026) after 3 minutes of driving and during the first sweeping left turn on my commute and at approximately 40 mph. Then the issue continued to happen throughout the drive, eventually becoming nearly constant by the end of the 45-minute commute. I do have an appointment with the Honda dealer for diagnosis, but the service advisor and I suspect that the steering rack is failing.
Battery keeps draining. On my 3rd battery and believe there’s a defect in the DC/DC converter (earlier recall - K9E). This has caused issues being stranded in the cold.
The 2020 Honda Insight has 5 NHTSA recalls and 29 consumer complaints on file. It received an overall safety rating of 5 out of 5 stars in NHTSA crash testing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
| Side Crash |
| Rollover |
Component: ELECTRICAL SYSTEM:BODY CONTROL MODULE:SOFTWARE
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Accord Sedan, Accord Hybrid, and 2019-2020 Insight vehicles. A software error may cause intermittent or continuous disruptions in communication between the Body Control Module (BCM) and other components. This may result in malfunctions of various systems such as the windshield wipers and defroster, rearview camera, exterior lights, audible warning of a stopped vehicle, and power window operation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 103, "Windshield Defrosting and Defogging Systems" and number 111, "Rear Visibility" as well as FMVSS numbers 104, 108, 114, 118, and 305.
Consequence: Various system malfunctions such as inoperative windshield wipers, defroster, rearview camera, or exterior lighting can increase the risk of a crash.
Remedy: Honda will notify owners, and dealers will update the BCM software, free of charge. The recall is expected to begin February 22, 2021. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is X95.
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Honda (American Honda Motor Co.) is recalling certain 2019-2020 Acura MDX, MDX Sport Hybrid, RDX, TLX, Honda Accord, Civic Hatchback, Insight, 2019 Acura ILX, Honda Accord Hybrid, Civic Coupe, Civic Coupe Si, Civic Sedan, Civic Sedan Si, Civic Type R, Fit, HR-V, Odyssey, Passport, Pilot and Ridgeline, and 2018-2019 CR-V vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will replace the fuel pump assembly, free of charge. Owner letters were mailed May 18, 2021. Owners may contact Honda customer service at 1-888-234-2138. Note: This recall is an expansion of recall 20V-314.
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
This 2020 Honda Insight performed “phantom braking” of the automated braking system when I was about to enter a clear intersection with no vehicles or obstacles in front of me. It activated the automated braking system and endangered my life and the lives of others over no real threat. This occurred 08/23/2025. The car is well maintained and does not have any service issues. This was completely random.
The contact owns a 2020 Honda Insight. The contact stated that after starting the vehicle, several unknown warning lights illuminated. During the failure, the brakes failed to function as intended, and the Lane Departure, Cruise Control, and Forward Collision Avoidance features failed to function as intended. The failure was intermittent. During the first failure, the vehicle was turned off and restarted after several minutes and the vehicle operated as intended. The vehicle was taken to the dealer and diagnosed with battery failure. The dealer also determined that the brake pedal simulator had failed. The vehicle was not repaired. The manufacturer was not notified of the failure. The vehicle remained with the dealer unrepaired. The failure mileage was approximately 18,000.
I was driving home from vacation when my engine splash plate came loose from my car on the interstate. The splash plate fell down and dragged on highway creating friction under my car. The metal had fallen down and was chipping away creating dangerous debris to my car and other cars on the highway. Roadside service was no help, per usual. I was traveling alone. The splash plate had to be removed entirely to prevent a fire and more damage to my car. I couldn’t remove the splash plate on the side of the interstate. I drove 30-40 mph to get help to prevent further damage or loss of property and my life.
I was driving down the highway, with no one in front of me, and my car alerted BRAKE and brought my car from 70 to an almost complete stop. This jerked myself and my passenger and caused a heat mark from the seat belt on my collar bone. It has done it multiple times since then. I'm terrified to be in traffic and for it to do this. This is most definitely putting my safety at risk, and the safety of others. I have not taken it to the dealership yet.
I was driving on a two lane road driving over a small paved bridge going about 40mph with a car next to me and a car behind me nothing in front of me when my car did a hard phantom brake. No pre warning, the display did show BRAKE and it did beep. But everything was sudden. Luckily the car behind was able to slam on brakes. The car behind me continued to follow but was at least 4 car lengths away. I assume bc they didn't know why I braked.
The contact owns a 2020 Honda Insight. The contact received notification of NHTSA Campaign Number: 23V858000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated the vehicle had stalled on several occasions. Additionally, the vehicle occasionally failed to start-up. The local dealer was contacted, but the vehicle was not diagnosed or repaired due to the cost. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 49,000. Parts distribution disconnect.
The whole hood vibrates while driving or when is windy, very noticeable at times. It was replaced once, almost a year ago but now it needs to be replaced again. same problem eventually the latches will be damaged creating a very hazardous situation. This vehicle has not been on an accident
I believe the tire, wheel or suspension system failed while driving on the highway, causing me to hit my head on the driver's window and lose cosciousness. I skidded into a concrete barrier on the right side of the highway and was found unconscious at the scene. The damage to the passenger side body of the vehicle is minor and does not match the catastrophic failure of the wheel, leading me to believe the wheel failed and caused the crash, not that the crash resulted in the damage to the wheel. The vehicle is currently at a tow lot and available for inspection. Luckily, no other vehicles were involved, but I was injured and could have easily been killed, or injured and killed others as it is a busy highway, especially during rush hour when this occurred. Inspection by the insurance company is pending. The police did not investigate as a safety incident because they immediately said on site that almost all single vehicle accidents are drug/alcohol related and treated it like a DUI stop. I passed field sobriety tests and a breathalyzer on scene and blood work at the hospital showed no drugs or alcohol in my system. I am missing time and memories starting about 5 minutes before the crash and for about 30 minutes after as a result of my concussion, I do not remember much besides a feeling that my car was falling, then I remember being woken up by the cop asking if I was under the influence.
On September 16, 2022, I was in an accident where a driver hit me on the rear passenger side. I went a through a green light of an intersection on the Mopac N feeder Road and Duvall. Either both our lights were green or the other driver was dishonest and his was red. Every airbag deployed. Based on the impact, it would be highly unlikely to sustain a cracked sternum. The impact was to the right and slightly behind me. I have requested information from Honda America on the airbags and they refuse. They further insulted me by telling to go to a dealership. After this, Honda is the last car I would purchase or lease. Having worked at dealerships for many years, I am certain Honda knows, as well as I do, that the dealer cannot or will not give me compete information on the airbags. My car was maintained and in amazing condition. The last time I was at First Texas Honda for service, the advisor brought it around because they were very busy. He said he was stunned it had 125,000 miles on it. It drove like it was brand new. Please see photos and reports. If you need any further information, please let me know.
Driving down highway at highway speed and car shot 52 failure codes. Car lost power and crawled to side of road. Nearly got rear ended multiple times trying to remove vehicle from roadway. Engine permanent codes U0111 U012D U0110 U12A5 U1206 U1205 Anti lock brakes permanent codes U040168 CAN Gateway Permanent codes U0029-00 Electric power train traction motor control module permanent code U1204 U12A5 U1205 U0100 U012D U1206 U0111 Electric power steering permanent codes U0416-68 Electric servo brake - permanent codes U0029-00 U0401-68 Integrated driver support system - permanent codes U0418-92 C0023-F0 U0100-F1 U0122-F1 U0100-00 C0031-62 C0034-62 C003A-62 U0416-68 Tire Pressure monitoring permanent codes U040168 OBDII Codes U1204 U12A5 U1205 U0100 U012D U1206 U0111 OBDII Permanent codes U1206 U12A5 U1205 U0111 U012D U0110 Over 41 codes documented and Honda says there is nothing wrong with the vehicle.
I WAS DRIVING AT 65-70 MPH ON A FREEWAY, AND ALL OF A SUDDEN THE CAR SPEED DROPPED EVEN MY FOOT IS ON THE GAS PEDAL, THE CAR SLOW DOWN TO 40MPH WHEN DECIDED TO PULL OVER TO THE SHOULDER, BARELY ENOUGH TIME TO GET OUT OF DANGER. THE CAR ENGINE SHOT DOWN BY ITS SELF, I COULD NOT MOVE THE VEHICLE TO THE FAR RIGHT ASS I WANTED TOO. THE WARNING LIGHT ON DASH BOARD INDICATED IN RED " POWER SYSTEM " BOTTOM OF IT IN WHITE LIGHT " POWER SYSTEM PROBLEM DO NOT DRIVE" THEN A MINUTE LATER, THE WARNING LIGHT CHANGED TO A RED LOGO OF A BATTERY 12 VOLT BATTERY CHARGING SYSTEM PROBLEM DO NOT DRIVE.
On July 22, 2022 I was driving my Honda Insight 2020. I was on the highway, current mileage on vehicle 50,796 miles, my speed was normal at 65 MPH when the car lost the ability to accelerate and it stalled. I was forced to make an emergency stop on the side of the interstate. Vehicle displayed on the dashboard "Critical Failure Detected. Stop Driving When Safe" The acceleration on the car kept decreasing and when stop it displayed "Power System Problem. Do Not Drive." Pulling to the side of the interstate was very scary because trucks were flying at about 80mph. I requested for tow company to pick me up but after hour wait, I gave up waiting on the tow truck. I restarted the vehicle and I was able to take off again. The fuel gas showed half of tank so I continue to drive. Forty miles later down the road, the same issue occurred again. I waited 30 minutes and since I was near a gas station I filled up the gas tank to full capacity. I drove another 100 miles (very skeptical) until I reached my final destination. During my drive I felt like the car had difficulties going into gear above 65MPH. The following day I took the vehicle to the Honda dealer, they said they couldn't pin point exactly what it is. Test show no issues on their diagnostic computer. However, the computer show a record of time and issue happening. They believe it is a fuel pump sensor relay. The vehicle senses I am out of fuel, which is not the case. Honda dealer will replace the sensor/relay and I will pay for it. The dealer states this vehicle is not part of a fuel pump recall. This issue needs to be addressed before it creates a scenario with fatalities, which can easily occur.
I have had 2 occasions when I experienced inadvertent spontaneous braking. Both times there was no vehicle in front of me. Both times the car stopped completely while driving in the city between 25 to 35mph. Fortunately there was no vehicle behind me either time and I did not sustain any injuries.
Showing 15 of 29 complaints