2011 GMC Sierra 2500

Component: AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.

Full recall detail →

Component: EQUIPMENT

General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.

Full recall detail →

Component: ELECTRICAL SYSTEM

General Motors LLC (GM) is recalling certain model year 2007-2011 Chevrolet Silverado HD 2500/3500 trucks manufactured January 18, 2007, to June 22, 2011, and GMC Sierra HD 2500/3500 trucks manufactured January 22, 2007, to June 21, 2011, and equipped with an auxiliary battery. Owners may unknowingly draw too much current through the vehicle's trailer harness resulting in the melting of fusible link for the auxiliary battery.

Consequence: If the fusible link melts it may come into contact with adjacent components, damage the electrical center cover, the nearby wiring harness conduit and other vehicle components, increasing the risk of a fire.

Remedy: GM will notify owners and dealers will replace the jumper harness with one that includes a 40 amp inline fuse, and provide the owner with supplemental Owner Manual information, free of charge. The recall began on August 29, 2014. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 14260.

Full recall detail →

The contact called on behalf of a Fire Department that owns a 2011 GMC Sierra 2500. The contact stated that while the Fire Department technician was performing a routine maintenance on the vehicle, the technician became aware that the sub frame was rusted with a hole in the sub frame. The vehicle was taken to the dealer, where it was determined that the sub frame needed to be replaced. The vehicle was not repaired. The contact related the failure to TSB Number: 19-NA-255. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 29,252.

On or about [XXX], the Transmission Control Module, FAILED, on my 2011GMC Denali 2500 6.6 diesel. It was a KNOWN faulty part .General Motors was aware of the issue years ago. This part should have been deemed a Safety Recall item. Imagine, pulling a trailer down a busy Freeway, with Semi's presence. Module goes out, truck goes idle, people hurt or worse. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When vehicle is warm and shut off, upon restart it will not go in to any gear, there was no warning lamps. An independent repair facility determined the Transmission Control Module was defective. General Motors has no parts available, and I know fro a fact it is a rather large issue.

TCM failed. Couldn’t find the parts required. Truck sat 700 miles away from me for four weeks. Had to have part repaired in hopes it worked. As of now I still have some issues but would not have the truck at all if I had to wait for a part

Transmission control module put my truck in limp mode while drinking down the highway.

Dash is cracked in multiple spots making it a safety concern when airbag is deployed.

On 4/12/22, we were towing our 32ft trailer with putt 2011 diesel GMC Sierra truck to Big Bear Lake which is in the San Bernardino Mountains in a two way winding highway. Upon making a somewhat sharp turn up a steep uphill, our accelerator went out. We had my mother in law, our two kids and dog in the vehicle at the time. We were able to get a speed of about 5-10mph to get a turn out and turn back around. We had no reception to call for help. The accelerator gave out shortly after but we were able to ride the decline to the bottom of the mountain and as soon as we were getting to the bottom, the engine turned off on us. Although it was still a two way highway, thankfully there was an emergency lane where we were able to park and where we were able to get very limited reception to call AAA (tow truck). There were vehicle speeding past us in high rates of speed. Because we needed a specialty tow truck given the towing of the truck/trailer, we knew it would take quite a while in the mountains for a driver to get to us. Temperatures at night in this area can get to 10-20 degrees. Five hours later at 11pm we were towed home. Upon towing the truck and trailer home, we were made aware of the reason the truck broke down through a diesel mechanic, which was CP4 fuel pump failure. Upon learning this and going online, we found out this is common for this truck with the CP4 fuel pump. We also found that other companies have made recalls, eg. Dodge but GMC/Chevy has not. This is obviously a safety issue that could have been catastrophic for myself, my kids and family and am wondering why there hasn’t already been a recall through GMC. Please let me know what our recourse is or if you have any questions.

My ABS and traction control and stabiltrak and service trailer break system keep going on and off its the most distracting thing i have a video of the chime not stopping. My water in fuel sensor won't go off I have un plugged it and changed it and the filter and when I unplug it it stays On

2011 GMC SIERRA. CONSUMER WRITES IN REGARDS TO PASSENGER SIDE FRONTAL AIRBAG SAFETY RECALL. THE CONSUMER STATED THE DEALER HAS NOT BEEN PROVIDED THE NECESSARY PARTS TO REPAIR THE VEHICLE. *JS

The contact owns a 2011 GMC Sierra 2500. The contact stated that while starting the vehicle, the vehicle remained in the PARK and failed to shift into DRIVE. The steering wheel was locked preventing the gear shifter from going into gear. The traction control warning light was flashing. The vehicle was taken to the local dealer but, was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 190,000. The VIN was not available.

While traveling at 65 mph the vehicle began to Vibrate and suddenly the tread separated and began banging against the side of the vehicle LT265/60R20E. I feel fortunate this was a rear tire and I was able to safely bring the vehicle to a stop. The tires were installed at 35333 miles so they only had about 26000 miles and are rated to 60000 miles.