Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2004 GMC Canyon.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: CHILD SEAT
GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
Consequence: BOTH NHTSA AND GM DISCOURAGE PLACEMENT OF A CHILD IN A FRONT SEAT. NEVERTHELESS, THERE ARE INDIVIDUAL CIRCUMSTANCES THAT MAY REQUIRE PLACEMENT OF A CHILD IN A RESTRAINT IN THE FRONT CENTER SEATING POSITION OF THIS VEHICLE THAT DOES NOT OFFER A REAR SEAT. LACK OF ACCESS TO THE TOP TETHER ANCHOR AND A LACK OF INSTRUCTIONS AS TO HOW TO USE IT, MAY RESULT IN IMPROPER INSTALLATION OF A CHILD RESTRAINT. IMPROPER INSTALLATION OF A CHILD RESTRAINT CAN RESULT IN A REDUCTION IN THE RESTRAINT'S PERFORMANCE IN THE EVENT OF A CRASH AND AN INCREASED RISK OF INJURY OR DEATH TO THE CHILD SEATED IN THE RESTRAINT.
Remedy: DEALERS WILL CUT A HOLE INTO THE BACK PANEL TRIM COVER TO ALLOW ACCESS TO THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT POSITION AND WILL PROVIDE SUPPLEMENTAL INFORMATION AS TO USE IN THE OWNER'S MANUAL. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR VISIT GM'S WEBSITE AT WWW.GMOWNERCENTER.COM.
Component: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
CERTAIN PICKUP TRUCKS MAY EXPERIENCE THE PERMANENT LOSS OF BRAKE LAMP FUNCTION OR BRAKE LAMPS THAT ARE ILLUMINATED AT ALL TIMES. THE CENTER HIGH-MOUNTED STOP LAMP (CHMSL) IS AFFECTED IN BOTH INSTANCES. ALSO, IF EQUIPPED, THE CRUISE CONTROL WILL BECOME INOPERATIVE. ANY TRAILER BRAKE LAMPS WHICH ARE CONNECTED TO THE VEHICLE'S BRAKE LAMP WIRING WILL MIMIC THE VEHICLE'S BRAKE LAMPS WHEN EITHER CONDITION OCCURS.
Consequence: A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
The frame has rust through and broke on rear front leafspring mount of frame on both side . A very know problem with almost every one of these trucks
Frame front passenger cracked while driving. Was able to avoid near accident with another vehicle.
The contact owns a 2004 GMC Canyon. The contact stated that after work was completed on the tires, the independent mechanic informed him that due to severe undercarriage corrosion, the vehicle was unsafe to drive. The contact also took the vehicle to a dealer who provided the same information as the independent mechanic. The manufacturer was then notified of the failure and informed him that there were no open recalls on the vehicle. No additional assistance was offered. The vehicle was not repaired. The failure mileage was approximately 89,000.
THE CHASSIS HAS BECOME SEVERELY RUSTED ON LEFT SIDE WHERE FRONT OF LEAF SPRING IS BOLTED TO IT. IT IS ABOUT TO BREAK OFF AND IT HAS BEEN DENOTED AS "UNSAFE TO DRIVE" BY THE LOCAL GMC DEALERSHIP. TRUCK HAS BEEN WELL-MAINTAINED AND IS IN GOOD CONDITION OTHERWISE. IT HAS BEEN GARAGE-KEPT FOR THE LAST 10 YEARS. I BOUGHT IT NEW 9/2004. THE DEALERSHIP JUST DISCOVERED PROBLEM TODAY WHEN I WAS HAVING OTHER ROUTINE WORK DONE.
WE HAD SOME REPAIR WORK DONE AND WERE TOLD THAT THE FRAME WAS RUSTED OUT SO BADLY IT WAS READY TO BREAK IN HALF, LEAVING US WITH A CAR THAT IS UNDRIVEABLE. THIS APPEARS TO BE A COMMON ISSUE WITH OTHER MODELS OF GMC TRUCKS AND THE ISSUE IS NOT BEING ADDRESSED. MAJOR SAFETY ISSUE!
The 2004 GMC Canyon has 3 NHTSA recalls and 80 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Remedy: DEALERS WILL REPLACE THE BRAKE LAMP SWITCH ASSEMBLY. THE RECALL BEGAN ON DECEMBER 5, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463 OR ISUZU AT 1-800-255-6727.
Component: EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.
Consequence: THIS CONDITION COULD CAUSE THE SIMULTANEOUS LOSS OF ALL BRAKE LAMPS OR CAUSE ALL OF THE BRAKE LAMPS TO STAY ON CONTINUOUSLY. BOTH OF THESE CONDITIONS COULD FAIL TO WARN OTHERS OF THE DRIVER'S INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS AS SPECIFIED IN THE RECALL BULLETIN FREE OF CHARGE. GM ANTICIPATES THAT PARTS WILL BE AVAILABLE BY JUNE 2010. A SPECIAL COVERAGE FOR VEHICLES REGISTERED IN ALL OTHER STATES WILL BE IMPLEMENTED IN THE SAME TIME FRAME. IN THE INTERIM, OWNERS WHO EXPERIENCE THE FAILURE CAN OBTAIN A FREE REPAIR, HOWEVER THEY WILL BE REQUIRED TO RETURN WHEN THE NEW DESIGN PART BECOMES AVAILABLE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.
TL* THE CONTACT OWNS A 2004 GMC CANYON. WHILE DRIVING 35 MPH, THE CONTACT HEARD AN ABNORMAL RATTLING NOISE COMING FROM THE REAR FRAME. THE CONTACT DROVE HOME AND THEN TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE FRAME WAS SEVERELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 119,730. THE VIN WAS UNKNOWN.
AFTER READING A POST FROM THE 116 AFFECTED GMC CANYON OWNERS I HAVE THE EXACT SAME PROBLEM. LAST MONTH JUNE 2019 WHILE DRIVING HOME FROM WORK MY AC JUST QUIT WORKING (HOT WEATHER IN SACRAMENTO), NO MATTER WHAT SPEED IT WAS ON 1 THROUGH 4. I ALSO SMELT A BURNING SMELL. TODAY WHILE DRIVING MY TRUCK TO THE REALER TO GET IT ANALYZED I HIT A BUMP AND THE BLOWER STARTED WORKING AGAIN ON SPEED 4. BOB FROM JOHN L SULLIVAN CHEVY JUST CALLED TO CONFIRM THE DIAGNOSIS...THE CONNECTOR THAT CONNECTS TO THE BLOWER WAS MELTED AND THE RESISTER WAS BURNT.
REAR FRAME HAS RUSTED COMPLETELY OUT. NOW SITTING AND CANNOT DRIVE. I LOVE DRIVING THIS TRUCK BUT NOW IT IS JUST SITTING. HOPE GM WILL SELL ME A FRAME AT COST SO I CAN FIX IT.
UNDERCARRIAGE RUST CAUSED SPARE TIRE/WHEEL TO FALL FROM UNDER THE VEHICLE.
THE GMC PASSLOCK LOCKOUT FEATURE IS A PAIN IN THE REAR OF NEARLY EVERY CAR/TRUCK OWNER HAVING THIS FEATURE. TODAY, FOR THE UMPTEENTH TIME, MY VEHICLE WOULD NOT START WHEN I TRIED TO START IT UP AFTER FUELING. MY TRUCK WAS STUCK AT THE GAS PUMPS, OBSTRUCTING OTHER PATRONS WAITING TO GAS UP. I SAT WAITING FOR ABOUT 5 MINUTES AND TRIED STARTING IT AGAIN, WHILE GETTING DIRTY LOOKS FROM OTHER PEOPLE WAITING TO GAS UP. OF, COURSE IT DIDN'T START BECAUSE I HADN'T WAITED THE REQUISITE 10 MINUTES. FINALLY, I GOT OUT AND PUSHED THE TRUCK AWAY FROM THE PUMPS BY MYSELF (I AM 72 YEARS OLD) AND THEN WAITED 10 MINUTES AND FINALLY RE-STARTED MY VEHICLE. I HAVE EXPERIENCED THIS AGGRAVATION OF MY VEHICLE NOT STARTING MANY, MANY TIMES DURING THE 14 YEARS THAT I HAVE OWNED THIS VEHICLE. I WILL NEVER BUY ANOTHER GMC PRODUCT! GMC SHOULD BE REQUIRED TO ISSUE A RECALL AND FIX THIS PROBLEM ONCE AND FOR ALL.
TL* THE CONTACT OWNS A 2004 GMC CANYON. WHILE THE VEHICLE WAS BEING SERVICED AT AN INDEPENDENT MECHANIC, THE TECHNICIAN NOTICED THAT THE ENTIRE FRAME WAS CORRODED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 86,000. *TT *JB
FRAME IS RUSTING AND COLLAPSING IN AREA BETWEEN CAB AND BED ON BOTH SIDES I HAD ATOYOTATACOMA WITH THIS CONDITION AND MANUFACTURER BOUGHT IT BACK . MY VEHICLE WAS NEVER IN A COLLISION. 95000 MILES
THE DASH WARNING FOR SEATBELT IS LIT UP
BRAKE LIGHTS STOPPING WORKING AND DOOR LOCKS AND CONTROLLABLE TO AND WINDOWS TO
THE FRAME HAS TOTALLY RUSTED AND IS BREAKING APART WHILE THE REST OF THE TRUCK IS IN VERY GOOD CONDITION. SEE PHOTOS. THIS WAS NOTICED ON 09-18-17. I BOUGHT THIS TRUCK NEW IN 2004 AND AS YOU CAN TELL BY THE MILEAGE IT HAS BEEN DRIVEN VERY LITTLE. PLEASE CONTACT ME WITH ANY QUESTIONS.
Showing 15 of 80 complaints