Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1991 Ford Thunderbird.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 3.8L 6 cyl Automatic 4-spd | 17 | 24 | 20 | $3,000 |
| 3.8L 6 cyl Automatic 4-spd | 15 | 21 | 18 | $3,850 |
| 5.0L 8 cyl Automatic 4-spd | 16 | 22 | 18 | $3,300 |
| 3.8L 6 cyl Manual 5-spd | 15 | 22 | 18 | $3,850 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Component: POWER TRAIN:AUTOMATIC TRANSMISSION
THE PARK ROD ASSEMBLY CONTAINS A PARK CAM WITH INADEQUATE SURFACE HARDNESS, WHICH COULD LEAD TO PARK DISENGAGEMENT OR NO PARK ENGAGEMENT WHEN THE LEVER IS PLACED IN PARK.
Consequence: IF PARK IS NOT ENGAGED AND THE PARKING BRAKE IS OFF, AVEHICLE ROLL-AWAY COULD RESULT.
Remedy: REPLACE PARK ROD ASSEMBLY ON AUTOMATIC TRANSMISSIONS.
Component: VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
THE NUTS WHICH HOLD WINDSHIELD WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED AND MAY LOOSEN OR COME OFF. THIS CAUSES CHANGED WIPER PATTERNS, OR THE WIPERS MAY JAM IF TWO OF THE THREE NUTS COME OFF.
LOSS OF HYDRAULIC BRAKE ASSIST ON SUPER COUPE. PEDAL BECAME HARD TO PRESS. BOTH BRAKE AND ABS ANNUNCIATORS ILLUMINATING. TROUBLESHOOTING INDICATES BRAKE PRESSURE SWITCH FAILING TO SIGNAL PUMP TO CHARGE SYSTEM OR ACCUMULATOR HAS FAILED. MASTER CYLINDER AND ABS SYSTEM ARE ORIGINAL EQUIPMENT AND THUS 24 YEARS OLD.
WHILE THE CONSUMER WAS DRIVING ON THE HIGHWAY THE ACCELERATOR BECAME STRUCK. AS A RESULT THE VEHICLE CONTINUED TO ACCELERATE UNTIL THE BRAKE PEDAL AND EMERGENCY BRAKE WERE APPLIED. *AK *NM
DEFECTIVE HEADLAMP CIRCUIT BREAKER CAUSES HEADLIGHTS TO FLASH OFF AND ON REPEATEDLY. FIRST FAILURE OCCURRED WHEN CAR WAS 2 YEARS OLD, SECOND FAILURE IN THE LAST YEAR. CAR HAS LESS THAN 57,000 MILES. 1991 SUPERCOUPE MODEL HAS FOGLAMPS AS DO THE 1992 AND LATER THUNDERBIRD MODELS FOR WHICH A RECALL EXISTS.*AK
The 1991 Ford Thunderbird has 4 NHTSA recalls and 128 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Consequence: CHANGES IN THE WIPER PATTERN OR JAMMING OF THE WIPERSWOULD RESULT IN REDUCED DRIVER VISIBILTY IN INCLEMENT WEATHER CONDITIONS.
Remedy: APPLY TORQUE RETENTION MATERIAL TO WIPER MOTOR STUDS AND NUTS AND RETORQUE.
Component: ELECTRICAL SYSTEM:IGNITION
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
PLASTIC BUSHINGS IN BOTH ENDS OF WINDSHIELD WIPER TIE-ROD COMPONENT HAVE WORN. CAUSES WIPERS TO MOVE LESS, SKIP, AND LOSE ABILITY TO CLEAR ENTIRE WINDSHIELD. TIE-ROD MAY BECOME DISCONNECTED FROM MOTOR END OR FROM WIPER END. CAR HAS LESS THAN 57000 MILES.*AK
3.8L V6 ENGINE OVER-HEATED DUE TO HEAD GASKET FAILURE IN #4 CYLINDER. BOTH HEADS WERE REWORKED AND GASKETS REPLACED. AFTER REPAIR ENGINE STARTED STALLING. IDLE AIR CONTROL VALVE WAS THEN REPLACED. NOW THERE IS A FLUCTUATION IN OIL PRESSURE. PRIOR TO HEAD GASKET FAILURE, POWER STEERING PUMP HAS TO BE REPLACED.*AK
OVERHEATING AT FIRST THEN AFTER THE HEADGASKETS WERE REPLACED THE ROD BEARINGS FAILED WHICH ADDED ANOTHER 1200.00 TO THE 1645.00 OF THE FIRST REPAIR AND THE POWER STEERING PUMP WAS REPLACED AT THE TIME OF THE FIRST REPAIR.
HEAD GASKET FAILURE AT 73,000 ON MY 1991 TBIRD WITH THE 3.8 V6. LOOKS LIKE FORD IS TRYING TO COVER THIS UP! *NLM
WINDSHIELD WIPERS FREEZE UP WHEN WIPERS ARE TURNED ON HIGH. THIS IS A SIMILAR DEFECT TO THE "NHTSA CAMPAIGN ID NUMBER: 91V076000" PROBLEM I CAN NOT USE THE MY CAR WIPERS ON HIGH IN THE RAIN. *AK
ENGINE HAS BEEN REPLACED TWICE ALREADY AND NEEDS TO GO IN AGAIN BECAUSE OF HEAD GASKET BLOWING OUT. CONTACTED DEALER. *AK
WHILE DRIVING HEARS A LOUD BEEP COMING FROM FRONT OF VEHICLE. CAN'T ACTUALLY TELL WHERE BEEP IS COMING FROM. PLEASE ADD VIN. *AK
I AM IN A CLUB OF OVER 5,000 OWNERS OF IDENTICAL CARS AND FAILURES HAVE BEEN SEEN AS LOW AS 18,000 MILES TO MY KNOWLEDGE, AND NUMEROUS IN THE 60000 MILE RANGE ON WELL MAINTAINED CARS OF HEADGASKET FAILURE WHICH OFTEN CAUSES COMPLETE ENGINE FAILURE, IN MY CASE IT CAUSED TWO CONNECTING RODS TO FAIL, A CRANKSHAFT BEARING DUE TO OIL CONTAMINATION AND THE CRANKSHAFT AS A RESULT. THIS IS THE THIRD FAILURE ON MY VEHICLE, ONCE I WAS STRANDED ON A DANGEROUS DARK STRETCH OF I-95, ONCE IN THE RAIN AND AS A RESULT OF LOSS OF HEAT (HEADGASKET FAILURE SYMPTOM) I RAN A RED LIGHT AND PROCEDED THE WRONG WAY ON A ONE WAY STREET. *AK
CONSUMER IS HAVING PROBLEMS WITH A DEFECTIVE IGNITION SWITCH THAT IS POSSIBLY CAUSING VEHICLE TO STALL. *TT
Showing 15 of 128 complaints