Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 1996 Ford Ranger.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: EXTERIOR LIGHTING:HEADLIGHTS
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Component: EXTERIOR LIGHTING:HEADLIGHTS
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Drivers side seat belt buckle does not work. The tongue on the long strap does not lock into the buckle at the seat. I think this may be a recall problem with other models and/or years, but not 1996 Ford Rangers.
heading back from picking up meal at pizza hut when "POP" sound from front of truck and then cabin filled with smoke. within 20-30 seconds of exiting the car it was in flames (See attached photos) recall notification was never sent to current owner and current owner didnt own in 2009 when it was first recalled. Ford customer service informed that auto insurnace would be required to handle loss of vehicle, but current owner doesnt have comprehensive coverage so insurance company is unable to payout for loss due to fire. This recall should have been communicated to titled owner after purchase.
Drivers side seat belt buckle does not release. Broken about ten years. Currently using middle seat belt buckle.
The 1996 Ford Ranger has 8 NHTSA recalls and 485 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: VEHICLE SPEED CONTROL
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Component: EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Component: EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Component: TIRES:TREAD/BELT
TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.
Consequence: IF THE TREAD SEPARATES FROM THE TIRE, THE DRIVER CAN LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH CAUSING INJURY OR DEATH.
Remedy: THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON AUGUST 29, 2001. HOWEVER, CUSTOMERS SHOULD CONTACT FIRESTONE CUSTOMER SERVICE AT 1-800-465-1904 FOR POSSIBLE ASSISTANCE.
Component: TIRES:TREAD/BELT
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
Consequence: SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
Remedy: THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.
Component: EQUIPMENT:OTHER:LABELS
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
MY 96 FORD RANGER HAS TREMENDOUS FRAME ROT ON THE DRIVE SIDE AT THE FRONT OF THE SPRING SHACKLES. SOMEONE HAD SPRAYED RHINO LINER LIKE MATERIAL ON THE ROT TO COVER IT UP OR TO TRY TO MAKE IT HOLD. THE REST OF THE FRAME IS IN OUTSTANDING CONDITION EXCEPT FOR IT BEING ALMOST BROKEN INTO AT THE GAS TANK STRAP AND FRONT SHACKLES. I HAVE REPLACED EVERY FRONT END PART ON THIS TRUCK THINKING IT WAS IN THE FRONT SUSPENSION. WHEN DRIVING IT RUNS OUT OF LINE FROM THE REAR AND THE FRAME IS STARTING TO BEND.
NANO AND MICRO PARTICULATES/CONTAMINANTS HAVE BEEN SPRAYED FROM AN AIRLINER AND CAUSED SEVERE DAMAGE TO MY BODY AND MY VEHICLE; IT INCLUDES FLAKES, TUBULES AND HIGHLY REFLECTIVE PARTICLES AND METALS. THE VEHICLE HAS STALLED AND LOST TWO GEARS AS A RESULT. IT HAS A GAS LEAKING ISSUE CAUSED BY THE TECHNOLOGY. I HAVE HAD TO GO TO THE EMERGENCY ROOM. MY VEHICLE HAS BEEN CONTAMINATED, DAMAGED AND SABATAGED AS WELL AS MY FAMILY MEMBERS VEHICLES, PERSONS AND PROPERTY. IT'S OCCURING ON AND OFF HIGHWAY. IT'S HAPPENING TO OTHER VEHICLES AS WELL. OIL AND BATTERY INTERIOR AND EXTERIORS AS WELL AS BODILY HARM, RISK AND INJURY. THE TECH AND PARTICULATES ARE HIGHLY DANGEROUS AND DESTRUCTIVE. [XXX] IS THE OFFENDING PARTY THAT CAUSED IT TO HAPPEN WITH THE FEDERAL AGENCIES. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TAKATA RECALL. I CRASHED MY 1996 FORD RANGER IN 2010. BOTH AIRBAGS DEPLOYED. MY COLLISION SHOP REPLACED THE AIRBAGS WITH UNKNOWN YEAR FORD RANGER AIRBAGS, BUYING SOME NEW PARTS FROM FORD TO COMPLETE THE INSTALL. THERE IS NO WAY TO KNOW IF THESE ARE RECALLED TAKATA AIRBAGS WITHOUT AN INSPECTION. MY LOCAL FORD DEALERSHIP, VARSITY FORD IN ANN ARBOR MI, IS REFUSING TO DO ANYTHING WITHOUT A RECALL NOTICE. ANY INSPECTION, EVEN IF THESE ARE RECALLED AIRBAGS, WILL BE AT MY COST BECAUSE THIS IS A 1996 TRUCK. I CALLED FORD'S RECALL LINE AND EXPLAINED THE SITUATION, AND THEY REFERRED ME TO MY LOCAL DEALERSHIP. THERE SEEMS TO BE NO PLAN TO TRACK DOWN DANGEROUS TAKATA AIRBAGS INSTALLED AFTER MANUFACTURE, EVEN IF THEY WERE ORIGINALLY INSTALLED IN ANOTHER VEHICLE THAT WOULD HAVE BEEN RECALLED.
TL* THE CONTACT OWNED A 1996 FORD RANGER. WHILE DRIVING 30 MPH, FLAMES APPEARED UNDER THE HOOD. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS FILED. THE CAUSE OF THE FIRE WAS UNKNOWN. THERE WERE NO INJURIES. THE VEHICLE WAS NOT TOWED, BUT WAS DEEMED A TOTAL LOSS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OPENED A CASE. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 300,000. *TR *JS *BF CONSUMER STATED BOTH ODI 11173289 AND 11173291 HAD MANUFACTURER DEFECT THAT CAUSED THE FIRE.*JB
TL* THE CONTACT OWNS A 1996 FORD RANGER. WHILE DRIVING DOWN A HILL AT LESS THAN APPROXIMATELY 20 MPH, THE VEHICLE CRASHED INTO A TREE. NONE OF THE AIR BAGS DEPLOYED. THE DRIVER SUSTAINED MINOR BRUISING, WHICH DID NOT REQUIRE MEDICAL TREATMENT. A POLICE REPORT WAS NOT FILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE MONTHS LATER. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN.
TL* THE CONTACT OWNS A 1996 FORD RANGER. THE CONTACT STATED THAT THE VEHICLE FAILED INSPECTION DUE TO EXTENSIVE RUST ON THE FRAME OF THE VEHICLE. THE INDEPENDENT MECHANIC STATED THAT THE FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THERE WAS NO RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.
DRIVERS SIDE SEAT BELT WILL NOT STAY LATCHED INTO LATCHING MECHANISM
THE WHOLE UNDERBODY AND FRAME IS RUSTED AND ROTTED. THE LEAF SPRING SHACKLES HAVE RUSTED AND ROTTED AWAY.
TRUCK WAS PARKED ON THE GARAGE PAD FOR A WEEK. I OPENED THE HOOD AND CHECKED ALL FLUID LEVELS, AND FOUND THE BRAKE FLUID A LITTLE LOW. TOPPED OFF THE MASTER CYLINDER AND GOT BACK INTO THE TRUCK. STARTED ENGINE, AND PUSHED THE BRAKE PEDAL. IT WENT TO THE FLOOR, GOT OUT OF THE TRUCK AND HEARD FLUID DRIPPING. I LOOKED UNDER THE TRUCK AND SAW A PUDDLE OF BRAKE FLUID NEAR THE LEFT REAR WHEEL. I ASKED MY WIFE TO PUSH THE PEDAL DOWN AND I SAW BRAKE FLUID SPRAYING FROM THE MAIN STEEL BRAKE LINE. COULD HAVE BEEN A SERIOUS ACCIDENT AS THE TRUCK WAS USED ONE WEEK PRIOR TO THE ACCIDENT TO HAUL A FULL LOAD OF FIRE WOOD.
TL* THE CONTACT OWNED A 1996 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE BRAKE PEDAL WAS DEPRESSED AND THE VEHICLE ROLLED AWAY FOR A FEW SECONDS. THE FAILURE RECURRED INTERMITTENTLY AND BECAME PERMANENT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS HOWEVER, THE CONTACT WAS UNCERTAIN OF THE REQUIRED REPLACEMENT PART. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. THE VIN WAS UNAVAILALBE. THE CONTACT NO LONGER OWNED THE VEHICLE.
EXTENSIVE RUST DETERIORATION ON STRUCTURAL FRAME MEMBERS WHICH IS SPREADING RAPIDLY. VARIOUS LOCATIONS. I'M VERY CONCERNED ABOUT THE RIGHT SIDE REAR LEAF SPRING MOUNT BREAKING LOOSE WHILE IN MOTION. THE REMAINDER OF THE TRUCK IS IN GENERALLY GOOD CONDITION. WHEN I BOUGHT IT FROM THE ORIGINAL OWNER 7/11, SOME FRAME BRACKETS HAD BEEN REPLACED, BUT THE FRAME APPEARED SOUND. VEHICLE WAS STATIONARY.
THE FRAME HAS EXPERIENCED SEVERE CORROSION INCLUDING THE SPARE TIRE MOUNT, CROSS MEMBERS, REAR BUMPER, LEAF SPRING SHACKLES, AND PERFORATIONS/RUST THROUGH OF THE MAIN FRAME RAILS.
Showing 15 of 485 complaints