1999 Ford Mustang

Component: EXTERIOR LIGHTING:HEADLIGHTS

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.

Component: FUEL SYSTEM, GASOLINE

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

Consequence: FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Remedy: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.

Component: EXTERIOR LIGHTING

CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy: TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

Component: EXTERIOR LIGHTING

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Component: PARKING BRAKE:CONVENTIONAL

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS. IF A VEHICLE IS PARKED WITH THE PARKING BRAKE NOT FULLY APPLIED AND NOT IN FIRST GEAR, AS DIRECTED IN THE OWNER GUIDE, AND THE SELF ADJUSTMENT PAWL SUBSEQUENTLY SKIPS ONE OR TWO TEETH, THE VEHICLE COULD MOVE ON SOME GRADES.

Consequence: THIS COULD RESULT IN UNINTENDED VEHICLE MOVEMENT AND A VEHICLE CRASH WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL MODIFY THE PARKING BRAKE CONTROL AND INSTALL A PLATE OR OVER-BRACKET TO THE CONTROL TO LOCK THE SELF ADJUST MECHANISM IN POSITION FOLLOWING ADJUSTMENT.

Component: SEAT BELTS:FRONT:ANCHORAGE

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.

Consequence: IF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.

Remedy: DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.

Component: VEHICLE SPEED CONTROL

VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.

Consequence: IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.

Remedy: DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.

MY SEAT BELTS DO NOT FUNCTION WELL. SOMETIMES, THEY RETRACT VERY SLOW, LOSE AND SOMETIMES THEY DO NOT EVEN RETRACT. ALSO, SOMETIME THEY GET STUCK. WHEN I BRAKE HARD, THEY STUCK AND TOO TIGHT....ON THE OTHER HAND SOMETIMES THEY ARE VERY LOSE AND DOESN'T STAY TIGHT TO MY CHEST, SAME IS THE CASE WITH THE NAVIGATOR SEAT BELTS AND ALSO THE REAR SEAT SEAT BELTS. IT BEEN HAPPENING FOR COUPLE OF WEEKS.

INTAKE MANIFOLD CRACK DESTROYING ENGINE. CYLINDER HEAD SPARK PLUG BLOW OUT. HEATER CORE FAILURE. CONVERTIBLE TOP DETERIORATING. FUEL PUMP FAILURE ALL LESS THAN 1200000

TL* THE CONTACT OWNS A 1999 FORD MUSTANG. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 70 MPH WITH THE CRUISE CONTROL ENGAGED, THE VEHICLE FAILED TO DECREASE IN SPEED WHEN THE CRUISE CONTROL WAS DEACTIVATED. THE CONTACT ALSO STATED THAT THE BRAKE PEDAL WAS APPLIED, BUT THE VEHICLE FAILED TO STOP. THE CONTACT SHUT THE ENGINE OFF WHILE DRIVING IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 99V062001 (VEHICLE SPEED CONTROL). THE APPROXIMATE FAILURE MILEAGE WAS 165,000.

TL* THE CONTACT OWNS A 1999 FORD MUSTANG. WHILE DRIVING 15 MPH, ANOTHER VEHICLE CRASHED INTO THE CONTACT'S VEHICLE. THE AIR BAGS DEPLOYED AND IMPACTED THE CONTACT IN THE FACE WITH EXCESSIVE FORCE, CAUSING UNKNOWN INJURIES. MEDICAL ATTENTION WAS REQUIRED AND A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000. THE VIN WAS NOT AVAILABLE.

THE CAR WAS BUILT WITH A PLASTIC INTAKE MANIFOLD. THE MANIFOLD BEGAN LEAKING AT THE THERMOSTAT HOUSING AND THEN THE HEATER HOSE CONNECTION ON THE INTAKE MANIFOLD SUDDENLY BROKE. I NOW HAVE TO HAVE THE ENTIRE INTAKE MANIFOLD REPLACED BECAUSE OF POOR DESIGN AND MATERIAL SELECTION. FORD KNEW OF THE PROBLEM BUT REFUSES TO ADDRESS THE ISSUE AND HOPES IT WILL JUST GO AWAY. THEY SHOULD REIMBURSE THE OWNERS OF THE VEHICLES FOR REPAIRS THAT WERE DUE TO POOR DESIGN AND MATERIALS USED TO MAKE THIS PART. *TR

TL* THE CONTACT OWNS A 1999 FORD MUSTANG GT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, SHE SMELLED A STRONG ODOR OF ANTIFREEZE. THE CONTACT PULLED OVER AND NOTICED A CRACK IN THE PLASTIC MANIFOLD AND COOLANT LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS, WHO STATED THAT THE MANIFOLD WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THERE WAS NOT A RECALL RELATED TO THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 75,000. THE WAS UNAVAILABLE.

SPARK PLUG BLEW OUT OF AN ALREADY FIXED HEAD!!! *TR

MUSTANG REAR PASSENGER SEAT BELT STUCK. *TR

TL*THE CONTACT OWNS A 1999 FORD MUSTANG. THE CONTACT STATED THE VEHICLE HAD A CRACKED MANIFOLD AND IT WAS LEAKING ANTIFREEZE. THE VEHICLE WAS TAKEN TO A MECHANIC WHO STATED THAT THE MANIFOLD NEEDED TO BE REPLACED. THE DEALER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE MANUFACTURER INFORMED HIM THAT THERE WERE NO RECALLS OR WARRANTIES AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 67,000.

TL*THE CONTACT OWNS A 1999 FORD MUSTANG. THE CONTACT NOTICED THAT THE FRONT DRIVER AND PASSENGER SEAT BELTS WOULD NOT RETRACT SIMILAR TO NHTSA CAMPAIGN ID NUMBER: 99V250000 (SEAT BELTS:FRONT:ANCHORAGE). THE VEHICLE WAS TAKEN TO THE DEALER AND THE CONTACT WAS ADVISED TO HAVE THE ENTIRE MECHANISM FOR BOTH SIDES REPLACED. THE CONTACT DID NOT INFORM THE MANUFACTURER NOR WAS THE VEHICLE REPAIRED. THE CURRENT MILEAGES WERE 92,658 AND THE FAILURE MILEAGES WERE UNKNOWN.

TL*THE CONTACT OWNS A 1999 FORD MUSTANG. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SEAT BELTS HAVE MALFUNCTIONED. THE SEAT BELTS HAVE FAILED BY NOT RETRACTING ENOUGH NOR DOES IT SECURE THE PERSON PROPERLY. THE VEHICLE WAS INSPECTED BY A DEALER WHO ADVISED HIM THAT HE HAD TO REPLACE THE SEAT BELTS. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000.