Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2023 Ford Maverick.
| Overall Rating | |
| Frontal Crash | |
| Side Crash | |
| Rollover |
| Overall Rating | |
| Frontal Crash |
Component: EXTERIOR LIGHTING:TAIL LIGHTS
Ford Motor Company (Ford) is recalling certain 2023 Maverick vehicles. A missing electrical circuit may cause the trailer taillights to not illuminate as intended when utilizing the vehicle trailer tow electrical connector. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer taillights that do not illuminate as intended can increase the risk of a crash.
Remedy: Dealers will add an electrical circuit to the engine bay wiring harness, free of charge. Owner notification letters were mailed June 9, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C04.
Component: ENGINE
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.
Vehicle started to have a shake under acceleration. Reported it to multiple dealerships and requested them to specifically observe the CV axles. Finally secured an appointment on 11-24-2025 while vehicle was under factory warranty. Tenvoorde Ford informed me (the owner) that the CV axles were “fine” and a non issue. Shake was still present. Kept driving the vehicle and now, five months later with no factory warranty left on the vehicle, shake still present, and received a second opinion today. CV axle needs replacement. 68,000 miles on the odometer. I exclusively commute on interstate 94 in central Minnesota, hardly drive in cities. There is no justifiable reason when the vehicle was at the dealership that the CV axle went from being just fine to needing replacement. This is a very common concern with these Ford Mavericks and Ford needs to conduct a recall before people get injured on the public roadways.
The vehicle was at the dealer for a loud noise on the hinge area of the driver side door. I was contacted by the dealer and told That the door has cracked spot welds and needs to be replaced. The dealer contacted Ford and for opening offered to pay for a portion of the repair leaving me with over $1000 dollars out of pocket.This is a common problem with this vehicle and the Ford escape see Ford TSB 2356B. The vehicle is still under warranty but this is a defective item and should be covered 100% by Ford.
The contact owns a 2023 Ford Maverick. The contact stated that while driving at an undisclosed speed, the brake lights and turn signals failed to function as intended. In addition, the message “Brake Light Failure” was displayed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure, and the contact was informed that the parts were not available to repair the vehicle. The contact received notification of NHTSA Campaign Number: 26V104000 (Electrical System, Exterior Lighting); however, parts were unavailable for the recall repair. The contact's husband purchased and replaced the light bulbs lights. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that there was no assistance available. The failure mileage was approximately 50,000.
The 2023 Ford Maverick has 20 NHTSA recalls and 257 consumer complaints on file. It received an overall safety rating of 4 out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
| Side Crash |
| Rollover |
Component: EXTERIOR LIGHTING:TURN SIGNAL:BULBS
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal is not working correctly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: A nonfunctioning exterior turn signal will not notify other drivers that the vehicle is turning, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed January 16, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C41.
Component: ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Ford Motor Company (Ford) is recalling certain 2022-2023 Maverick Hybrid vehicles. The Instrument Panel Cluster may not properly illuminate warning lights or gauges. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays," and 102, "Transmission shift position sequence, starter interlock, and transmission braking effect" as well as FMVSS numbers 105, 108, and 208.
Consequence: An instrument panel that does not illuminate critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.
Remedy: Dealers will update the instrument panel cluster software, free of charge. Owner notification letters were mailed March 26, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C01.
Component: TIRES
Ford Motor Company (Ford) is recalling certain 2023 Maverick and Bronco Sport vehicles. The tires may have been manufactured incorrectly, which may result in a loss of vehicle handling and control.
Consequence: A loss of vehicle handling and control increases the risk of a crash.
Remedy: Dealers will inspect and replace the tires, as necessary, free of charge. Owner notification letters were mailed April 5, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S20.
Component: ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Component: EXTERIOR LIGHTING:TAIL LIGHTS
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. The Body Control Module (BCM) may inadvertently deactivate one or both rear tail lights.
Consequence: Rear tail lights that fail to illuminate can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Dealers will update the BCM software, free of charge. Owner notification letters were mailed May 10, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.
Component: POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will update the HPCM software, free of charge. Owner notification letters were mailed May 22, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S33.
Component: VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
Ford Motor Company (Ford) is recalling certain 2023-2024 Maverick, Ford Bronco Sport, and Mustang Mach-E vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.
Consequence: Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the windshield wiper motor as necessary, free of charge. Owner notification letters were mailed on December 6, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S51.
Component: BACK OVER PREVENTION:SOFTWARE
Ford Motor Company (Ford) is recalling certain 2022-2024 Ford Maverick vehicles equipped with Connected Touch Radios (CTR). The rearview camera image may freeze when the vehicle is in reverse.
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the Connected Touch Radio (CTR) software, free of charge. Owner notification letters were mailed on March 21, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S59.
Component: ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles. The 12-volt battery may experience degradation and suddenly fail.
Consequence: Battery failure can result in a loss of electrical accessories, including the hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and if necessary, replace the 12-volt battery, free of charge. Owner notification letters were mailed May 2, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S02. Vehicles in this recall were previously repaired under 24V-267 and will need to have the new remedy completed.
Component: EXTERIOR LIGHTING:TURN SIGNAL
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 23V-848. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal has failed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: A nonfunctioning exterior turn signal cannot notify other drivers that the vehicle is turning, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed March 27, 2025. Owners may contact Ford customer service at 866-436-7332. Ford's number for this recall is 25C04.
Component: EXTERIOR LIGHTING:TAIL LIGHTS
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 24V-293. The body control module (BCM) may inadvertently deactivate one or both rear tail lights.
Consequence: Rear tail lights that fail to illuminate can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed March 28, 2025. Owners may contact Ford customer service at 866-436-7332. Ford's number for this recall is 25S07.
Component: ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Ford Motor Company (Ford) is recalling certain 2022-2023 Maverick Hybrid vehicles previously repaired incorrectly under recall number 24V-140. The instrument panel cluster may not properly illuminate warning lights or gauges. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 101, "Control and Displays," and 102, "Transmission shift position sequence, starter interlock, and transmission braking effect" as well as FMVSS numbers 105, 108, and 208.
Consequence: An instrument panel that does not illuminate critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.
Remedy: Dealers will update the instrument panel cluster software, free of charge. Owner notification letters were mailed April 9, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C06.
Component: POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2022 Escape, and 2021-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 24V-330. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will update the HPCM software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S16.
Component: POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
Consequence: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.
Component: ENGINE
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S54.
Component: BACK OVER PREVENTION:SOFTWARE
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Component: EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Component: ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
CV axle fails prematurely, causing vehicle shaking under acceleration, and potentially unsettling vehicle stability at speed. First noticed the shaking at 49K miles. I have not had an opportunity to schedule an appointment with the dealer to have it replaced yet. This is a known issue on these vehicles that Ford has not acknowledged, with many drivers reporting they need the CV axles replaced ever 30k miles or so.
CV axles are covered under the Ford Powertrain Warranty. I am experiencing a driveline vibration consistent with axle failure. I would like a warranty diagnosis and documentation explaining why this is not considered a warrantable defect. Dealerships are refusing to evaluate a powertrain warranty issue involving driveline vibration consistent with axle failure. The vehicle exhibits driveline vibration under normal operation. That is not normal function and indicates a defect under warranty terms. Powertrain issues with axles present a safety concern. I see Ford has superseded the original NZ6Z axle part numbers to SZ6Z and now PZ6Z revisions. That indicates a known issue with earlier components. My vehicle is exhibiting the exact failure symptoms—this should be evaluated under powertrain warranty.
Hybrid Ford Maverick electrical system began to go into a save battery mode -no interior lights, only driver side door operated, and other system failures. Dealer replaced battery under warranty and general recall for this issue. A few months later same characteristics started showing up -interior lights not working, only driver's side door operational, etc. This time the warranty had expired and the dealer, along with Ford Motor, told me any repairs would be at my expense, 100%. I feel problem was never resolved, even with replacement battery. Ford and dealer should address this problem. I'm sure I'm not the only one with this battery and electrical issue. After all, there was a full recall for the battery failure. Having no interior lights, unable to enter except driver's side, and other manifestations are inherently unsafe.
Vehicle "shakes and vibrates" when accelerating along with odd clicking noises when turning. The sunroof also leaks during car washes.
"2023 Ford Maverick Hybrid (VIN: [XXX] ). The vehicle has a chronic 12V parasitic drain defect. Authorized dealer Champaign Ford City provided false information, stating software was current when it was not. This led to a 100% discharge in freezing temperatures, requiring multiple jump-starts to reach the dealer. This discharge destroyed a high-quality owner-purchased AGM battery. Despite Safety Recall 25S02 mandating no-cost battery replacements for these vehicles, the dealer charged me for a Ford battery. Safety concern: Vehicle unreliability in sub-zero temperatures and dealer failure to adhere to federal recall reimbursement guidelines." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Drivers door became hard to open and close. Found driver front door stop damaged / welds broken and separated from door interior.
Found Drivers door hard to open and close. Took vehicle to Body shop. Had to replace door.
The throttle body component of the vehicle failed at approximately 40,000 miles. While this is an engine component that experiences normal wear and tear, throttle body valves fail anywhere between 75,000 and 100,000 miles. I have owned previous vehicles, each crossing the 100,000-mile mark, with no replacement or concern with the throttle body. My concern with this vehicle's throttle body relates to the outdoor weather conditions when the vehicle reported an issue. The outside air temperature was 3 degrees Fahrenheit with moderate winds and a wind chill of approximately -10 degrees Fahrenheit. Researching online, this appears to be a recurrent issue among other owners of this particular vehicle. When started, the vehicle appeared to misfire, potentially entering limp mode. An amber wrench light illuminated, indicating to have the vehicle serviced, and the engine light illuminated, indicating a problem with the emissions system. Additionally, the vehicle pushed a notification to my smartphone that stated the following: "The engine control system has detected the electronic throttle body is not responding as commanded and requires service." The vehicle was turned off and sat for 15 minutes. When the vehicle was restarted, the wrench light turned off, but the engine light remained on, not flashing. The vehicle operated normally, with no misfire. The failure of the throttle body in adversely cold conditions may cause the engine to stall or misfire, decreasing driver control and increasing the potential of a crash. It is of concern that this component seems to have failed early compared to other vehicles currently on the market. I believe the weather to be a contributing factor. The servicing dealership has confirmed that the throttle body must be replaced and has the appropriate part on back order. As this vehicle was not involved in an accident, no police reports or insurance claims have been filed. I plan on reaching out to the manufacturer to address these concerns.
Battery is constantly in battery saving mode. It use to do it only when I was on vacation for a week or so. Now it has been doing this every single day for about the last two month.
Battery goes into deep sleep truck will not crank this the 3rd time for this truck.
I had a problem once with the interface module, and since it was still under warranty, the Ford dealership in Fairfield, California replaced it and at 3:32 AM today January 3, 2026. The interface module turned off for a couple seconds and then turned back on which was basically the same problem as it was when I complained and had them replace it.
I believe the OEM 12v battery that is used in the Ford Maverick hybrid is underpowered and has issues that seem to plague the vehicle. I’ve owned the truck for almost two years now and started getting “battery saver” alerts when the truck would sit for a few days over the week or during a vacation. But recently I’ve been getting the warning far more frequently and not even siting for more than 24 hours. Last month I had a warning that the power could turn off at any moment and need to pull over immediately. The warning went away after powering the vehicle down and turning back on. Last weekend the car was completely dead after using it all week and only letting it sit Saturday evening to Monday morning. The battery seems to be an issue that plagues the vehicle and I think an investigation needs to be conducted to have this corrected. I even see new 2025 models having similar issues.
Showing 15 of 257 complaints