Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2003 Ford Explorer Sport.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover |
Component: EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
The contact rented a 2003 Ford Explorer. The contact stated that while driving at an undisclosed speed with the seat warmer activated, after arriving at a Rest Stop and exiting the vehicle, the contact became aware that a blister had formed on the back of her left thigh. The contact attributed the blister to a burn sustained while using the driver's side seat warmer. No warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic, but instead was returned to the rental company. The manufacturer was not notified of the failure. The failure mileage was 43,253. The VIN was not available.
There is a crack down the middle section of the liftgate for quite some time. The liftgate has been unlocking and opening automatically by itself. On only rare occasions has the liftgate opened all the way while driving. On the morning of 7/28/2022 while the vehicle was parked in my driveway the liftgate was discovered to have again unlocked by itself and opened slightly and now with one of the two hinges holding the glass sheared leaving the liftgate glass hanging by only one hinge. With the glass now hanging without having both hinge supports functioning and the inability to close and lock the liftgate, 1) the glass could fall out while driving and 2) with the liftgate unable to now close and lock, contents of the back storage area could fall out of the vehicle while driving. On 8/1/2022 the vehicle was inspected by the foreman of the Service Dept. at Healy Ford, Goshen, N.Y. I was told to take it to a body shop for realignment repair. Apparently a recall on 9/13/2022 # 04V442000 did not include my Vin. However, In driving around I do see many 2003 explorers with the identical crack on the liftgate.
The 2003 Ford Explorer Sport has 1 NHTSA recall and 1313 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Head lights are cloudy given poor visibility. Back hatch door has a crack.
The contact owns a 2003 Ford Explorer. The contact stated that while driving at approximately 25-35 MPH around a curb, the driver thought that the tire was flat. The contact pulled off the road and noticed that three of the wheel studs on the driver’s side rear wheel had sheared off. The vehicle was towed to an independent mechanic and it was confirmed that the studs had sheared off and that there was also a fractured wheel stud on the passenger’s side rear wheel. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 115,000.
Hello my name is [XXX] just writing you cause my neighbors have program my vehicle meaning they hack my 2003 explore pretty much they want to take over my driving they trying to dominate me in this matter when in reality is not going to be possible that's why I come to your people's corporate plus they have invade my family privacy they have a gang organization watching me every where I go had few confrontation they just want me to confront them so they could put me in jail this is not going to happen i apologize for the inconvenience I told police regards this matter they didn't do nothing about it . INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
drivers side rear brake line developed a hole caused by the emergency brake cable rubbing against it causing all the brake fluid to leak & the brakes failed. Fortunately my husband was driving on our rural road & not out on the main highway. We have not been able to get it repaired yet.
The driver was driving down the expressway and her back tire blew out causing her vehicle to spiral out of control and the vehicle then flipped and started rolling downhill, the vehicle airbags did not deploy in the vehicle at all. The driver and her mother are in critical condition. Yes, the safety of others safety was put at risk. I did contact Ford Manufacturer on her behind of the airbags and they said there is nothing they can do for her with the vehicle being totaled out. But my main problem is why these airbags did not deploy. The vehicle is going to be inspected by her insurance company here in the next few days. There were no prior lamps, messages, or anything that would have indicated that the airbags were defective.
WAS CLOSING BACK HATCH AND GLASS WINDOW LITERALLY EXPLODED! VEHICLE WAS PARKED IN MY YARD.
THE TRANSMISSION IS SHOT I CANT PUT IT IN GEAR AND ME AND MY HUSBAND WERE ALMOST KILLED BUT WERE ABLE TO PUT IT IN 2ND GEAR TO ROLL IT TO THE SHOP. THE 4WHEEL DRIVE GOT STUCK IN 4 WHEEL LOW AND WOULD NOT SHIFT AT ALL. WHEN WE TURNED THE CAR ON IT WOULD REV UP TO 5 BUT ONLY GO 2 MILES AN HOUR.
TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE WHEEL DETACHED DUE TO THE CONTROL ARM BEING CORRODED. THE CONTACT CALLED ELDER FORD (777 JOHN R RD, TROY, MI 48083, (248) 825-8646) AND WAS ADVISED TO SCHEDULE AN APPOINTMENT. THE VEHICLE WAS LATER TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE METAL OF THE UPPER CONTROL ARM WAS NOT A GOOD METAL; THEREFORE, THE CONTROL ARM WAS CORRODED THROUGH AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.
TAKATA RECALL .. THE SMELL OF FUEL INSIDE THE CAB AND OUTSIDE IS REALLY BAD. IT'S MAKING ME SICK AND GIVING ME HEADACHES. THE TRUCK DOESN'T RUN RIGHT AND THE MILEAGE IS AWFUL.
SHIFTER BROKEN INSIDE STEERING COLUMN. STOPPED AT A GAS STATION WHEN PUTTING INTO PARK IT BROKE. HAD TO KEEP MY FOOT ON BRAKE PADDLE FOR 2 HOURS UNTIL TWO TRUCK ARRIVED
"TAKATA RECALL" AIRBAG LIGHT KEEPS BLINKING WITH THE SEAT BELT NOISE. CHANGED THE LIGHT BULB FROM THE DASH BOARD AND NOW THE AIRBAG LIGHT STAYS ON BUT WILL NOT CONNECT WITH MILEAGE.
2003 FORD EXPLORER. CONSUMER WRITES IN REGARD TO DEFECTIVE THROTTLE IN MODEL VEHICLE. *AS *TR
VEHICLE WAS IN MOTION, MOVING THROUGH AN INTERSECTION ON A CITY STREET AND INVOLVED IN AN ACCIDENT. NO AIR BAGS DEPLOYED AT ALL.
Showing 15 of 1313 complaints