Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2005 Ford Escape.
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover |
Component: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Component: HYBRID PROPULSION SYSTEM
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
I bought a 2005 Ford escape the VIN number on the dash and the title do match however the ECU and the door jamb VIN [XXX] which is for a 2006 Ford escape 4 cylinder 2.3. the vehicle I bought should be a 6 cylinder with a 3.0 l the mechanic says mismatched VIN the dealership refuses to listen. About the vehicle on [XXX] drove it 30 miles then was able to call the mechanic for some maintenance as his car was for my daughter and that is when I got to bad news of a mismatched VIN. Not even your odometer reading is correct has less on it now than it did back in 2018 and it's documented as accurate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Odometer Fraud. The contact purchased a 2005 Ford Escape on November 25, 2025. The contact discovered a mileage and VIN discrepancy after the purchase. The vehicle was a dealer sale. At the time of purchase, the mileage was 199,500. The vehicle was taken to the dealer for a routine inspection, and the dealer informed the contact that during the diagnostic test there was another VIN was associated with the vehicle, and the mileage listed on the diagnostic test was 199,345. The other VIN linked in the diagnostic test for the vehicle was associated with a 2006 Ford Escape, and the mileage was 199,345. It was later discovered that the dealer who had sold the vehicle to the contact had purchased the vehicle in 2018, and the mileage was 199,876. The contact stated that the mileage on the reverse side of the Title was 199,876. The Police were notified; however, no assistance was provided.
The 2005 Ford Escape has 5 NHTSA recalls and 1584 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. The high number of complaints suggests potential reliability concerns — review the complaint details above before purchasing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Component: SUSPENSION:FRONT:WHEEL BEARING
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Consequence: Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Remedy: Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Component: SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Component: LATCHES/LOCKS/LINKAGES:DOORS:LATCH
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
I had just started up my 05 Ford hybrid Escape reversed out of a parking space, applied my brakes and a loud warning noise went off, the ABS light & the Brake light went on, then I tried to brake while backing out of the parking stall. I had no brakes, petal went all the way to the floor. I shifted into drive to pull forward. The car wouldn’t stop petal just went right to the floor, had very little resistance. I almost drove through the front glass doors of the P/T office across from the pharmacy in Cool, CA. The roads are mountainous windy and steep. I was definitely scared for my safety. I had to coast very slowly on the way home. I was on my way to work but instead I dropped it off at home and called ride share to take me to work! I had to use my emergency brake to make the turn up my dirt road. I still had little to no brakes to stop the car. I parked it and haven’t driven it since. Much to dangerous to drive this car. I could have easily been killed not having brakes. It Showed no codes, had no warning at all. I just bought the car about 6 months prior. The next day it was as if it never happened.
Front Subframe rusted out causing loss of steering and control. Car came to a complete skidded stop . The front wheel nearly came off. The subframe issue is the same problem that resulted in a recall of the 2001-2004 Ford Escape.
The contact owns a 2005 Ford Escape. Upon starting of the vehicle, the contact placed the vehicle into drive(D); however, the vehicle failed to accelerate upon the depression of the accelerator pedal. The contact stated that prior to the failure, the check engine warning light illuminated and remained illuminated on the instrument panel. The contact stated while driving at highway speeds, the vehicle independently downshifted and the vehicle failed to accelerate above 30 MPH. The vehicle was shaking, and the vehicle failed to accelerate upon the depression of the accelerator pedal. The vehicle was taken to an independent mechanic where and the contact was informed that the transmission torque converter was defective and needed to be replaced. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 105,000.
The right lower control arm separated from the subframe due to subframe rust. It caused loss of handling and rendered the car immobile. It was caused by a panic stop at a low speed. The car was towed to an independent garage where it is awaiting repair. Parts affected were the subframe, CV axle joint and the front fender (From the wheel hitting it when it broke).
Hello, The engine cradle subframe on my 2005 Ford Escape has completely rusted through on the right hand side where it attaches to the steering control arm. As I was driving the subframe broke which made it impossible to steer the car. This pulled my car off the road to the passenger side. Fortunately I was not injured. Having now researched this issue, it is a common problem with 2005 Ford Escapes. This is very dangerous, and it should be addressed as it creates a life threatening situation.
The right back tire shock and spring mount broke right off
I had the hybrid battery replaced by Bill Brandt Ford in Brentwood California. A few days after having it replaced. The car broke down on a very dangerous highway. I had the car towed back to Bill Brandt Ford. They replaced the hybrid battery again. I received the car back on May 9. The car just broke down again today. Roughly Bill Brandt Ford had my car for over 250 days. I found a recall one for S as in Sam 19 for my vehicle when I type in the Vin number it says that it doesn’t pertain to my car. But when I look at the recall issue, my car is having the exact same problems. Now I need to have the car towed back yet again to the dealership. Any help would be greatly appreciated. I have over $3000 invested in this car now with Bill Brandt Ford and they’ve had it longer than I’ve had it.
My rear passenger side rusted right out completely and the strut mount is not attached to any part of the body. It caused my vehicle to swirve off the road almost hitting another vehicle when it was raining out also in the snow this occurred several times where my rear end jerked sideways pulling my truck into a complete circle.
Stalled out while driving down hwy. At 70 mph. Cars swirved and I almost got hit from behind due to my vehicle just cutting out. No warning lights came on it just shut off battery light n engine light then came on after vehicle lost power and I had to get off road without causing an accident which almost occurred due to the speed and area I was driving at time vehicle cut out I still have not figured out why it just cut out. Very dangerous all around.
The contact owns a 2005 Ford Escape. The contact stated that after her father inspected the vehicle, he made her aware that there was damage to the rear subframe. The vehicle was taken to an independent mechanic, where it was diagnosed that the rear subframe needed to be replaced. The contact became aware of NHTSA Campaign Number: 14V165000 (Structure); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 100,000. The VIN was not available.
I was heading back to Louisville Ky from bowling green Ky when my suv started to slow down and started running rough and check engine light flashed then stayed on I pulled off the road called aaa to have the suv towed back to bowling green to where I could have it checked the next day when I went to start it it was knocking and smoking and wouldn’t take gas. Talked to a local shop and was informed that my motor was blown after he came and looked at it.
Rear driver's side door will not close/latch. Latch can be manually moved, but does not engage when shutting door. Currently using bungee cords to keep door closed as I have children and no other vehicle. Vehicle was parked, door was opened from inside to allow passenger to exit, but when they attempted to shut the door, it would not latch closed. No prior problems with the door and no prior warnings/lights. Since door won't close, the door ajar dash light is illuminated and I have to turn my interior lights to off so that they don't remain on while I'm driving
Drove vehicle to drop off dog at sitters, started vehicle began to make u-turn and vehicle stalled. Attempted to restart, cranks but won't run. Recently purchased from used car dealer, new battery was installed, no trouble up to this point. Began checking usual problems, fuel delivery, crank pos.sensor, cam pos sensor, have no spark. Upon further research this appears to be faulty coils, spark plugs and pcm from factory but no recall has been employed. Possibility of collision during u-turn very likely. Loss of power to all systems could cause extreme risk to life at higher speeds. Ford Motor Company is aware of this problem, with the high number of similar problems in the NHTSA data base it is impossible for them not to know. The NHTSA should force Ford to fix this. If you make a product that can be dangerous if faulty, you are responsible to the public to do the right thing. I think that if the governmental agency responsible for traffic safety won't do their job then a class action lawsuit should be started. I bet I could find a good lawyer in the SF Bay area.
Showing 15 of 1584 complaints