2021 Chevrolet Suburban Problems & Complaints

My 2021 Chevrolet Suburban experienced a sudden no start condition which required the vehicle to be towed for repair. A diagnostic inspection determined that both the fuel pump and the fuel pump control module had failed. I paid out of pocket for the full repair, including replacement of both components. Several months later, GM issued a safety recall for the fuel pump control module on this vehicle. I submitted a reimbursement request to GM. GM agreed to reimburse only the control module , but refused to reimburse the fuel pump, even though the pump failure was directly caused by the defective module that is now under recall. Federal recall reimbursement guidelines require manufacturers to reimburse the full cost of the remedy for the defect. In this case, the defective module caused the fuel pump to fail, making the pump replacement part of the necessary remedy. GM’s refusal to reimburse the full repair cost leaves me paying for damage caused by the recalled component. I am requesting NHTSA’s assistance in reviewing GM’s refusal to reimburse the full repair cost associated with this recall related failure.

Lane departure assist, adaptive cruise control, auto emergency braking, adaptive high beam, forward collision warning system became unresponsive while driving on highway during trip. Had to take vehicle into GM dealership for ADAS camera replacement.

Had an engine replacement in dec of 2025 and had to pay for it since wasn’t under warranty or recall. And now my replacement engine which has a warranty now. Just failed in March 2026 which about 3 months later. Had metal shavings in engine and multiple cylinders misfiring. And now I don’t have a family vehicle to drive my family around again. There should’ve been a recall on my engine, but wasn’t this is not fair. And I’m paying the price for it.

The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving at various speeds, the steering wheel was difficult to turn to the left or the right. The contact stated that the failure was intermittent, but was a recurring failure. There was no warning light illuminated. The contact stated that prior to the failure, there was an abnormal whining sound while turning the steering wheel. The vehicle was not taken to a local dealer or independent mechanic to be diagnosed or repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 33,000.

My 2021 Chevrolet Suburban experienced a sudden and complete engine failure at approximately 79,000 miles. The vehicle became inoperable and is currently at a dealership pending evaluation. There were no prior warnings indicating an imminent catastrophic failure. A sudden engine failure of this nature presents a significant safety concern, including the risk of loss of propulsion during operation. The failure has been confirmed by the dealership, and no repairs have been authorized at this time pending further review. This complaint is being submitted to document a sudden and severe engine failure and to request evaluation of potential safety-related defects involving internal engine components.

I am submitting this complaint to report a serious safety issue involving my 2021 Chevrolet Suburban equipped with the 3.0L Duramax diesel engine. The vehicle has experienced a recurring problem related to the engine wiring harness. While driving, the vehicle will unexpectedly stall without warning. At the same time, there is an immediate loss of power steering assist, significantly reducing the ability to safely control the vehicle. This creates a dangerous situation, especially at highway speeds or in traffic. The failure appears to be linked to a defect or malfunction in the engine wiring harness, which may be causing intermittent electrical interruptions to critical engine systems. There were no prior warning signs sufficient to prevent the incident. This issue poses a substantial safety risk not only to the driver and passengers but also to other motorists. Sudden engine shutdown combined with loss of steering assist increases the likelihood of a crash. I believe this may be a systemic defect affecting other vehicles of the same model and configuration. I urge the National Highway Traffic Safety Administration to investigate this issue and determine whether a recall should be issued. Vehicle Information: Make: Chevrolet Model: Suburban Year: 2021 Engine: 3.0L Duramax Diesel

On Friday, March 13, 2026, while traveling at approximately 60 mph on the highway, my 2021 Chevrolet Suburban equipped with an L87 6.2L V8 engine experienced a sudden and complete loss of motive power. The failure sequence began with a dashboard warning prompting me to "press the start button again," followed immediately by the vehicle shifting into neutral without any driver input. Despite repeatedly pressing the accelerator, the vehicle continued to decelerate and could not re-engage drive. A second dashboard warning displaying "engine recall" then appeared mid-incident. Subsequently, the rear wheels locked, forcing the vehicle to coast to a complete stop on the hard shoulder without any brake input required from the driver. Upon coming to a full stop, the start button continued flashing with repeated prompts to press it, the vehicle lock emblem illuminated on the dashboard, and the vehicle became fully and mechanically immobile, unable to shift out of neutral or transition into any other gear. The engine could not power the vehicle at all. My safety and the safety of other motorists were directly and seriously endangered, as the failure occurred without warning in the middle lane of an active highway at highway speed, leaving the vehicle unable to maneuver or accelerate out of harm's way. A responding police officer confirmed the road hazard on scene and remained present to protect the vehicle and occupants while we awaited assistance. The AAA tow truck operator independently concurred upon arrival. The vehicle was transported to Classic Chevrolet, Grapevine, TX, the same day and is currently awaiting full technical inspection by the dealership's service team; an official mechanical diagnosis remains pending. The dealership service advisor has verbally confirmed awareness of an active engine and powertrain/transmission recall affecting this vehicle. The failed component — the L87 6.2L V8 engine and associated drivetrain — is available for inspection

See attached document for complaint.

While driving the Engine warning light, service ESC light, and collision light all came on and an engine knock started. I also experienced a loss of power at the same time. Car was taken to local Chevy dealership for evaluation and repair. Dealership advised that they dropped the oil and found metal shavings in the oil. After further investigation, we were advised that it was a crankshaft connecting rod failure. We have an extended warranty and were waiting to hear back on repair coverage. GM denied the repair as this vehicle is not part of the active recall. Our warranty company also denied the repair stating we did not have adequate records of oil changes. Receipts for oil and filters were provided.

The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving 35 MPH on the highway, the vehicle stalled. The contact pulled over to the side of the road. There was no warning light illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was repaired out-of-pocket. The contact related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The manufacturer was notified of the failure and informed the contact that the VIN was not under recall. The failure mileage was approximately 92,000.

Rear Axle is grinding. Took vehicle into dealer and it is the well documented rear axle issue but this vehicle is not included in a recall. The differential fluid was replaced and figure 8s were done but there is still grinding. The rear axle also drags at times when in auto 4wd. The dealer said the next step would be to replace the axle. This is the issue: Differential Noise/Failure: Reports indicate a rubbing noise while turning, often attributed to the rear differential. In some cases, the entire rear differential has required replacement.

In April of 2022 with 26k miles my vehicle had its first engine failure, Chevrolet dealership had to replace engine lifters due to a known engineering defect with the 2021 6.2 L87 engine. Now in late February 2026 with 80k miles my engine has locked up and requires a brand new engine replacement. For some reason, even though this is a L87 6.2L 2021 engine it is not part of the broader recall for this exact same engine failure for the same engine year and model.

While driving, the engine malfunctioned. There were no warning lamps, messages, or other symptoms prior to the malfunction. The vehicle has been inspected and repaired by a Chevrolet dealership.

The check engine and traction control light came on in my car. This was accompanied by a clanking sound, shaking. The panel said “ SERVICE ESC” “ service traction control” and “ forward collision system unavailable” The Chevrolet light logo on the back of my car will also not turn off occasionally whenever the car is turned off.

My [XXX] Daughter lost the ability to put the vehicle in reverse while running errands on a Saturday. We had to push the truck out of the parking spot "backwards" in neutral in order to get the vehicle in a position to put it in "drive". She had been going in and out of shopping centers (forwards and backwards) earlier when the reverse suddenly stopped. I dropped the vehicle at a nearby auto shop in a fit of desperation (maybe 1/2 mile away). They told me they thought the transmission was shot, so I picked it up and took it to Andean Chevrolet (Dealer) in Cumming, GA. While driving it to Andean on Tuesday (2/17), the transmission went into low acceleration mode where I couldn't go into upper gears and topped-out at 3,500 rpm's max for the 13+ miles (30 min) drive. Andean confirmed on Friday (2/19) that the entire transmission is shot with metal all inside of the fluid, gears being broken, and the valve body being broken. The truck is 5.5 years old with 93K mile on it and we were just shocked. The repair for GM Reman transmission was quoted at ~$9.2K and we just finalized a call directly with GM Customer Service to see if GM would offer any discounts to the Dealer on the repairs. We are still waiting on that result while the repairs are being made. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving 45 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended, and the vehicle decelerated unintendedly. Additionally, the vehicle failed to exceed 42 MPH. Later in the day, the gear shifter was shifted to reverse; however, the vehicle failed to reverse as intended. The vehicle was taken to the dealer, where it was diagnosed with transmission valve body failure. The contact was informed that the transmission valve body needed to be replaced. The vehicle was repaired. The contact stated that the vehicle was at the dealer from December 2024 until June 2025. The vehicle was picked up from the dealer. The contact stated that while driving at an undisclosed speed, the engine seized and failed to restart. The vehicle was towed back to the dealer, where the contact was informed that the fuel pump had failed, and the battery was drained. The contact was informed that the battery and the fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 35,000.

Engine failure at 86,000 miles with documented regular oil change and recommended services

My vehicle was taken in to shop due to recall recommendation I received in GM app for fuel pump control module . After repair was done my engine begin ticking the same day and failed a week later . I documented the whole thing and filed a claim with GM however the dealership that did the repair are not responding to GM . The dealership is alm Chevorlet south in Jonesboro ,GA this vehicle stalled out while I was on the highway . Please help me this vehicle belongs to my limo fleet and this is detrimental to my business . After multiple attempts to get it diagnosed they kept telling me I had to wait in line for weeks out to get it checked out although the problem arose after the new part installation . Then when I brung it back with failed engine soon after they told me that I had to sign a liability release waiver for them to check out the vehicle stating that the vehicle was high mileage and not their fault . The service manager literally instructed me not to leave my vehicle when I wanted to because it would not speed up the process for it to be seen I brung it back when instructed but it was to late because the engine had already failed . They literally forced me to sign a waiver stating that they wouldn’t diagnose it if i didn’t sign the waiver . These people are committing a fraudulent scam and their are unsafe vehicles on the road that arent being treated properly due to these practices . Please contact the dealership and or GM to take this matter more seriously .

The contact owns a 2021 Chevrolet Suburban. The contact stated that while in reverse (R), the vehicle failed to reverse as intended. The contact’s wife continued driving at approximately 55 MPH, and an unknown message was displayed, and the vehicle failed to exceed 55 MPH. Additionally, the transmission was stuck in gear and failed to upshift into the next gear as designed. The vehicle was pulled over to the side of the road, and the battery was disconnected and reconnected, but the message remained displayed. The vehicle was towed to an independent mechanic, where it was determined that the transmission control valve needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 81,600.

My vehicle is having an oil consumption problem. 2 quarts were missing from my oils consumption test. The dealer is now doing a secondary oil consumption test and I’ve read up and learned that there have been a lot of recalls with the engine and oils changes.

The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving at various speeds, an abnormal oil consumption was noticed. No warning light was illuminated. In addition, the vehicle was previously taken to a local dealer, where an oil consumption test was performed; however, the contact was advised to bring the vehicle back for further investigation. An appointment with the same local dealer was scheduled to inspect the vehicle. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 60,000.

My vehicle will not go in reverse.

There is an electronic problem that continues to trip the warning for the Air Ride suspension system to fail leaving the vehicle stuck at its current ride height or it drops eithee the front or rear suspension to the ground while simultaneously raising the front or rear to its highest setting. It also causes the vehicle speed to drop immediately to 56 mph. Issue has been scanned by several dealers to determine air leaks, pinched wires, failing compressor and all were found to be in normal operation. This is a huge safety concern as well as a huge financial concern for the consumer.

My 2021 Chevrolet Suburban stalled while driving in late September 2025 and had to be towed to a dealership. The vehicle is subject to an active fuel pump power control module safety recall that has been in effect since 2021. The vehicle was brought in specifically for repair of this issue. The work was processed under warranty, and I was charged a deductible. After learning the repair was directly related to an active safety recall, I requested reimbursement of the deductible, as recall repairs should be completed at no cost. That reimbursement request was denied. I have since been informed that the recall repair was never “completed,” and the recall still shows open in the manufacturer’s system. I am now experiencing shuddering and symptoms consistent with a potential stall recurrence. The original stall occurred while I was transporting my children, including special needs children who require regular transportation to school and therapies. The vehicle failure left us stranded at night in an unsafe area. Due to the prior stall, the unresolved recall status, and the recurrence of symptoms, I do not feel the vehicle is safe to operate. Thank you for your attention to this matter, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The front of the fuel tank is hanging down and nearly dragging on the ground. This was with normal driving on a highway. No hitting bumps or aggressive off-road anything. We noticed when we heard a scraping noise going slowly over a slight incline in a driveway that it was hanging down.

After purchasing the car, the engine oil low light came on after driving about 2,000 miles on a fresh oil change. We took the car to the Chevrolet dealer where they said the engine was over 2 quarts low on oil and recommended a fresh oil change. After another 2,000 miles of driving the low engine oil light came on again. We took it back to the same dealership and started the oil consumption test. After several months of oil checks, it was determined that the engine failed the test and service was recommended and would be covered under warranty. Extensive repairs were performed on the engine including piston replacement. After receiving the car back from repair, we continue to have the engine oil low life light appear after a few thousand miles of driving and have to add 2 quarts of oil to the engine. We contacted the Chevrolet dealership that performed the repairs and they said that prior warranty work would not be covered since we were now out of factory warranty. We were informed that we would have to go through the oil consumption test again and pay for any needed repairs. We're concerned that with investigation EA25007, our engine could experience the bearing failure and cause serious injury.

On January 13, 2026, the engine in my Suburban failed suddenly and completely, rendering the vehicle inoperable without warning. The failure left me stranded with my children, creating a serious safety concern and requiring immediate towing. Prior to that day, the vehicle exhibited no ongoing symptoms, warning lights, or performance issues, aside from a ticking noise that appeared only on the day of failure. The vehicle was towed to an authorized Chevrolet dealership, where it was determined that the engine was damaged beyond repair and required full replacement. I was informed a new engine would need to be ordered, at an estimated cost of approximately $14,000—an extraordinary and unreasonable expense for a vehicle of this age and price point.

Engine is running low on oil all the time. took it to dealer they said, there is sludge build up. Found oil fouling on CYL 3 and and found Spark plugs with excessive oil no external leaks found recommend new engine

The car was driving at 60 MPH on a regular commute to work and the car was stalling and shaking and soon after the check engine light came on with multiple issues.

Vehicle experienced sudden engine malfunction including rough idle, hard misfire, and flashing check engine light. Vehicle was diagnosed with a collapsed lifter and internal engine failure. Metallic debris was found in the engine oil, including silver and gold/bronze particles consistent with bearing material. A Chevrolet dealer inspected the vehicle and determined that the engine requires complete replacement due to internal mechanical failure. Vehicle is equipped with the 6.2L V8 (L87) engine. The failure occurred without warning and presents a safety concern due to potential loss of propulsion. This vehicle is not currently included in the existing GM 6.2L engine recall, despite exhibiting the same failure characteristics reported in other affected vehicles with the same engine and year that were included in the recall. Vehicle has not been driven since metal contamination was discovered to prevent further damage

I have a 2021 Chevy Suburban with the L87 6.2L V8 engine. At 7k miles, we have lost propulsion, leaving the car undrivable. resulted in the dealer replacing all 16 lifters under a recognized bulletin. I never received extended 6yr 100k mile powertrain warranty as described in the bulletin. Since then, There have been 3 other issues with loss of propulsion, resulting in replacement of fuel pump modulator. belt pulley system, One of the incidents left us without power or control of our vehicle on the interstate, with no where to pull over or get out of the way of oncoming semi trucks. The last incident again left the vehicle undriveable at 84k miles, with the dealer currently reporting that it is a lifter and cam shaft issue. Resulting in a 10k bill. They state that it is not covered under the recall of these engines because it is the top of the engine versus the bottom. Clearly, the engine oil problem noted in the recall has contributed to these issues . and the crankshaft not syncing properly with the lifters.

The vehicle caught on fire in our garage The Vehicle had been parked outside than moved into the garage nothing smelled like smoke after it was parked other than the exhaust after I got out of my suburban I have a good idea what caused this but until its done being ispected I happened to look back and saw a flame in the Suburban coming from the center area of the dash on the right hand side of the divers seat I thought for sure it was gonna blow up the dogs were in the back of the garage behind the vehicle off to the side I started screaming and calling for help and had to go around the house to the front door to get my husband and him and one of my sons went out there why I called 911 and was with my other son whom has a disability and they told us to get out of the house and I could not get back to the garage we were on the other side of the house going to go out on the patio my other son and husband were in the garage trying to put it out and getting to the two dogs my son went through the smoke to reach the dogs were one ran out on her own and the young German shorthair was in shock and he had to carry the 2 year old out and put them in a safe place but my husband was still trying to put out the fire he hooked his pick up to the suburban to try to pull it out of the garage and it moved maybe a few inches he was stuffing wet towels on it also to try to stop it nothing worked the fire dept showed up and police after having to tear the inside of the front of the dash out our home owners insurance adjuster was out yesterday The Suburban has had multiple and thousands of dollars of mechanical issues even Gm putting a new engine in it after only a year in a half of owning it fluid got pushed up into the wiring after a service last year there was splater inside the dash glass after a new steering wheel was istalled and I asked the dealer if they could fix that and they said that they didn't go inside there the amount of detail that has led up to this is huge

Went into limp mode on 11/6/25, took to the dealership where they found metal shavings in the oil due to a “stuck solenoid ‘A’”. Originally said that I’d need a whole new transmission, decided to do the cheaper easier repair and just replaced the valve train (not my choice) got it back on 11/13/25. On 11/24/25 I was on a very busy highway, at a red light, hit the gas when the light changed and the car didn’t move. Just revved the RPMs, then it suddenly lurched/surged forwards. Took it back to the dealership and they said “it doesn’t have any codes showing”. This is not normal behavior for a 4 year old vehicle with less than 40k miles on it.

We have a defective engine that stopped working after 120 miles. We can drive the car because it can leave us on the road or catch fire, this is what the mechanic told us, GMC option is to buy another car.

I was driving and then the vehicle started running rough. There was no indication or warning lights before this happened. This is a huge safety issue because I could have had a wreck and injured people and my very own family. I took it to a Chevy dealership. They inspected the suburban and number 4 cylinder had a pool of oil in it. And they told me it need a new engine. Which it has the L87 engine that all the GM recalls are on. However, they are telling me mine isn't on the recall. They don't know if GM is going to cover it because it has 111,000 miles and it's out of the power train. It's the same engine they're having trouble with engines failures on. And I believe mine should be under the recall.

Engine is shaking like a bearing is going out, I've seen multiple recalls on this engine but for some reason my 6.2 isnt apart of them.

See attached document for complaint. To Whom It May Concern, I am writing regarding the recall on my 2021 Chevy Suburban. While I understand there is currently no active solution for the issue, I want to stress the seriousness of the situation. As a mother of [REDACTED] living in Wisconsin, I am deeply concerned that if my truck were to shut down due to engine failure and we could not get help quickly, my family would be exposed to the risks from the fire that inevitably could arrive. Given the harsh winters there, this poses an unacceptable safety risk. Additionally, I paid for an extended warranty, believing I had plenty of coverage left. I recently brought my vehicle in only to be told that I was 500 miles past the 60,000-mile limit, I was under the impression the warranty had not expired, and if I had known otherwise, I would have brought it in much sooner. This issue has been ongoing for at least 6 months, and I have been aware of the mileage restriction, I would have scheduled service well before this point. On top of that, my Suburban continues to emit the smell of burnt oil. It is embarrassing to have my vehicle smell like it's burning every time I drive it, and it raises serious concerns about my health. Breathing in burnt oil fumes regularly cannot be good for my lungs or overall well-being. This issue has also created a financial burden for me, as I am currently trying to sell the vehicle. In its present condition—with the burning oil smell and unresolved recall—it is essentially unsellable. No buyer wants to take on these risks and uncertainties, leaving me stuck with a vehicle I can neither comfortably drive nor reasonably sell. This matter is not just about inconvenience. It is about safety, that matters, and other concerns, trust and accountability. Chevrolet has marketed its vehicles as reliable, family-safe transportation, and I want to feel assured that GM takes immediate action to properly address this oil consumption and/or issue. Anything less is unacceptable when it comes to the safety of families who trust your brand. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

CAR BURNS EXCESSIVE AMOUNTS OF OIL AND HAVE TO ADD REGULAR QUARTS OF OIL BETWEEN THE MANDATORY OIL CHANGE. CONSIDERED VEHICLE COULD MALFUNCTION AND CAUSE AND ACCIDENT OR CATCH FIRE. DEALER SAID THEY HAVE RECALLS FOR OTHER CHEVY SUVS AND TRUCKS WITH SAME ISSUE BUT NOT MY PARTICULAR MAKE AND MODEL. THIS ISSUE WITH CHEVY'S BURNING OIL WARRANTS AN INVESTIGATION SINCE CHEVY IS NOT ADDRESSING THE ISSUE.

Engine while driving completely seized up. Crank shaft, cam shaft and oil pump water pump replaced. Low oil pressure alarm code present then sudden loss of power. Piston blown. There are similar recalls to 2021 suburbans however, this specific model is not in the recall. I was told I need a completely new engine. The car died in the middle of traffic and police had to call an emergency tow truck.

The headlight adjustment screw is broken. Was never used or adjusted and now the headlights point to the ground. GM does not offer a replacement part for the adjustment screw, the only fix is to purchase a whole new headlight assembly which is roughly $1,000 before installation costs. This causes a dangerous situation since the drivers side headlight points to the ground and it is hard to see in front of you at night.

While driving along on a city street, the check engine light came on. Once I turned onto the highway, there was a pop from the engine, and the vehicle started missing and vibrating. I turned around and drove the vehicle back home. A mechanic looked at it and said there were a lot of problems and recalls on these vehicles for misfiring. He said the problem is the lifters and they need to be replaced as soon as possible. He encouraged me not to drive it due to it may cause more damage.

Engine light comes on and now flashes. The service traction control and esc comes on. The whole vehicle shakes when idling. Certified GM dealer hooked it up and it says misfiring cylinder 6. All spark plugs replaced, new GM coil, new spark plug wires. Nothing has fixed it yet.

I was driving when I received messages saying service ESC, Forward collision System Unavailable, & Service Traction Control. The vehicle began to shake hard when I applied brakes, had loss of power when pressing the gas pedal, and sounded like metal grinding. All of this put my children & I at risk as we were on interstate 35 with cars flying past us and I’m losing power. Initially the spark plugs and coil was were changed to no repair. It was towed to a dealership where they confirmed the lifter & cam failed which put metal in the oil. My only option is a full engine replacement costing 20k on a vehicle that’s 4yrs old. It’s not ok that I have to spend that in order to get my 70k car drivable. Im now without a car, still paying a car note, unable to get my kids places, and having to get help from friends all bc GM can’t build a quality vehicle. I also haven’t been able to get a loaner car. This isn’t happening in only the 6.3L. This is a widely known issue with the 5.3L as well. *There were ZERO warning signs that something was wrong. Drive just fine that morning*

Driving vehicle on a highway at 55mph, tried to speed up, no propulsion. Fuel injector went bad.

I was standing at a red light with my foot on the brake and the car went into neutral and stalled. I could not restart the vehicle and had to be towed to the dealership where there confirmed a fuel pump module failure. There were no precipitating factors or warnings. This is extremely dangerous. The car is only 4 years old and many people have reported the same incident online, which often recurs, even after replacing the fuel pump. The dealership has ordered the part however it is on backorder without any estimated ship time. For a vehicle I paid over $70K for, this is concerning and frustrating. There is a known recall for 2021 Suburbans for this exact issue.

The contact owns a 2021 Chevrolet Suburban. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, an abnormal sound was coming from underneath the hood. The check engine warning light was illuminated. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 130,000.

My suburban is 4 years old and needs a new engine. The dealership is seeing a lot of 21's with the same issue. Bank 1 and 2 have failed, both powerods are broken and the cans and lifters have failed. There were no prior warning. We were driving and 2 warnings popped up and we took it to a dealership. We then went to a private repair shop for second opinion. The warranty is 70k miles and my car is 72k miles. This should not be happening with a 4 year old. The other Suburban engine has been recalled but mine has no current recalls on it.

Was driving about 45 mph on 2 lane road. All of a sudden, without warning we lost power (had no propulsion). Luckily there was a residential side street that we were able to turn onto and get off of the highway with no shoulder. We coasted to the side of the street and called a tow truck. Had we not been able to get off the road, we would have been dead in the road, blocking an entire lane of a busy 2 lane highway without a shoulder to pull off on. There was no warning prior to incident but a message did appear during the incident. I believe it said "Loss of propulsion." We turned off the vehicle, then tried to restart it. Engine attempted to restart, but it made a horrible noise & wouldn't restart. Still had battery power. Vehicle was towed to a local dealership where it is currently being evaluated. We know of a massive recall on the 6.2 l engines. Ours is a 5.3 l engine. So far I'm seeing many people having problems but no official recall for the 5.3 l engines that are having THE SAME issue as the massively recalled 6.2 engines. This needs to be looked at. Our Vehicle only had less than 30k miles on it. We bought it new and have done routine maintenance.

After a major HVAC repair involving the evaporator core (performed at a Chevrolet dealership), my vehicle began experiencing serious electrical issues. The second-row 12V outlet no longer functions, and the vehicle has gone completely dead three times while the engine was off due to the auto stop/start system — once while stationary on a major highway, creating a dangerous situation. Each time, the engine failed to restart automatically, and the entire electrical system became unresponsive.

On 7/26/2025 approximately 8:30pm (PDT), driving south on CA I-880 in third lane from right traveling at approximately 50mph when vehicle engine died and went into neutral gear. Dashboard alert indicated to press start engine button, but would not start. Managed to maneuver vehicle to right shoulder amid rush hour traffic. Fortunately, a CA Highway Patrol officer saw us and was able to render assistance. Vehicle would not restart or go into neutral after several attempts to restart engine. Special tow vehicle was called to give us a tow home. This incident happened after we received a Chevrolet recall notice back in May or June about the engine and did take the vehicle in for service on 6/10/2025. The dealership service recommended using higher weight oil and it would help mitigate any potential issue. Obviously, this was not the case. We were very fortunate to avoid any serious injury or damage on the highway due to engine failure.

The contact owns a 2021 Chevrolet Suburban. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where the map sensor was replaced; however, the failure persisted. Additionally, the vehicle failed to start. The vehicle was towed to another mechanic, where it was diagnosed and determined that the fuel pump sensor module had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 62,000.

My wife was driving the vehicle and was pulling into a parking lot. The brakes failed and would not stop the vehicle. She pressed on the brakes very hard, multiple times, for several seconds, before the vehicle finally came to stop. She then proceeded into a parking spot where the brakes again failed to stop the vehicle promptly. Several lights illuminated and a “System Brake Failure 43 MPH Top Speed” message appeared, alternating with several other messages appearing. The vehicle is in for service at Classic Chevrolet in Granbury, Texas. They are telling me that they reset the codes and that the codes are not returning. I am extremely concerned that if I pick up the vehicle at this point, the brakes could fail again and cause an accident with serious injury.

There is an issue with the transmission when i accelerate at a slow pace. The car shakes and vibrates. Theres a possibility of an issue with the transfer case 4x4. When i turn the steering wheel and drive, it feels like it locks. It feels like 4x4 is on and theres a odd sound as well. I took my car to Hamilton Chevrolet and paid for inspection. They told me that there was no issue, but the issues i mentioned earlier in this message was mentioned to them. Those issues are still occurring. This is a recall issue but when i put my VIN number in, my car shows that there is no recall on it. There was many people who mentioned this problem.

Vehicle lost power, debris in cylinder from internal damage, crank case leaking air, oil leaking into cylinder, P0300, P0308, and P050D

Engine is skipping when in reverse.

What component or system failed or malfunctioned, and is it available for inspection upon request? Fuel pump How was your safety or the safety of others put at risk? Yes, vehicle stopped unexpectedly and and wasn’t accelerating Has the problem been reproduced or confirmed by a dealer or independent service center?no Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear?no

The vehicle started rumbling/vibrating/shaking when getting up to speed and at a consistent speed. Brought to an independent service center and was old that the torque converter is failing. No warning lamps or other problems prior to rumbling/vibrating that started on 5/22/25.

The contact owns a 2021 Chevrolet Suburban. The contact stated that the vehicle was listed under the application TURO. The contact stated that a person rented the vehicle and informed him there was an abnormal sound coming from the engine. The contact test drove the vehicle, and while driving 30 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light illuminated, and the contact heard an abnormal sound coming from the engine. The vehicle was towed to an independent mechanic, who diagnosed the vehicle and determined that the lifters, push rods, and two valves, and cylinder 6 had failed and needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was taken back to the independent mechanic; however, no cause for the failure was found. The independent mechanic stated that the vehicle was consuming an excessive amount of oil and in cylinder #1, the lifters had failed. The vehicle was repaired; however, the failure persisted. The vehicle was taken back to the independent mechanic and was diagnosed with oil intrusion into the bank covers and piston damages. The vehicle was repaired for the most recent failure. The manufacturer was not contacted. The failure mileage was approximately 107,000.

What component or system failed or malfunctioned, and is it available for inspection upon request? -My engine started to make a loud ticking and knocking noise. I brought it into Good Chevrolet in Renton WA 6/3/25 where they told me there is an “internal engine failure due to failure of the lifters.” When I asked the dealership for the repair estimate so I could possibly have a second opinion, they said they were “not comfortable giving their information and the problem in writing.” They refuse to give us any documentation but were insistent that even though NHTSA has issued a mass recall for this exact same issue on the larger engine in my same year of vehicle, “it’s unrelated.” How was your safety or the safety of others put at risk? -The engine is failing and had we not brought it in for diagnosis, I could have had full engine failure while driving with my children and been in a catastrophic crash. Has the problem been reproduced or confirmed by a dealer or independent service center? -Yes the problem can be reproduced and has been confirmed by Good Chevrolet. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? -Good Chevrolet inspected the engine but refuse to give us documentation though they had us file a claim with GM (I will attach the claim email) Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? -I noticed a small noise after I had fans replaced in September but the noise gradually increased so it was brought in for diagnostics. There were no warning lamps or messages.

The contact owns a 2021 Chevrolet Suburban. The contact stated that while his wife was driving at undisclosed speeds, there was an abnormally loud banging sound coming from the engine compartment. The contact stated that the failure was related to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed and determined that the rods were bent, and the lifters needed to be replaced. The vehicle was repaired. The manufacturer was not contacted. The contact called the warranty company, who confirmed there was no repair coverage on the vehicle for the failure. The failure mileage was approximately 109,069.

While driving at normal highway speed, the vehicle speed is suddenly reduced and it feels and sounds like the transmission has shifted into low gear. The following warning light activated: Reduced Acceleration Drive with Care. The GM dealership service center stated that the transmission control valve body needed to be replaced. They indicated that this was a known issue. I believe a safety recall should be issued for this defective part.

The contact owns a 2021 Chevrolet Suburban. The contact stated that while pulling out of a parking spot in a parking lot, the vehicle stalled. The contact attempted to restart the vehicle and observed a knocking sound coming from the engine compartment. The vehicle was not able to restart. The vehicle was towed to the dealer where it was diagnosed and determined that the engine had seized and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 23,906.

Sat may 3rd We went for tire change from that date since that day, every time we try to start the car there’s always a different warning light The warning light is never the same issue. On may 15 when we received a warning light about transmission we went to the dealership that day they said they were about two weeks backed up but flushed the transmission and paid $504 for the service. Since that day we also received numerous warning light which include. Driver window. Esc. Winshield fluid. Tire pressure. Lift gate open. Forward Collision System Unavailable. Your 2021 Chevrolet Suburban detects a battery, starter or connection issue. Lastly the check engine light came on and the car won’t start.

My 2021 Chevy Suburban Premier suffered a sudden internal engine failure due to collapsed lifters and a damaged camshaft. The vehicle began experiencing performance issues, including rough idling and loss of power. After taking it to a certified mechanic, it was confirmed that the lifters failed and caused significant damage to the camshaft, requiring a major repair that I had to pay for out of pocket. This issue is widely known among GM vehicles with the 5.3L and 6.2L V8 engines and has been the subject of numerous technical service bulletins and customer complaints. While my vehicle is not included in the current recall (NHTSA ID: 25V-274), which covers crankshaft and rod failures on L87 6.2L engines, this lifter failure is part of the same engine family and indicative of a broader defect in GM’s V8 engine platforms from 2021–2024. I’m requesting that NHTSA investigate these lifter and camshaft failures as a safety and reliability concern, and urge GM to expand the existing recall to include these known engine issues. Many customers, including myself, are incurring thousands of dollars in repair costs for problems that are clearly tied to manufacturer defects.

I am contacting you regarding a critical engine failure in my 2021 Chevrolet Suburban LT, which is equipped with the L84 5.3L V8 engine. Due to a valve lifter malfunction, the engine suffered catastrophic failure, with metal shavings found throughout the oil system and internal components. I’ve been quoted approximately $14,000 by the dealership/service center to replace the engine, and the vehicle is currently awaiting repair. I was driving the car with my son when the vehicle began to shake, make ticking noises, and the check engine light went on. I pulled off the road and several error codes popped up including "Service ESC" and "Service Traction Control." This is the second time that a lifter valve has failed on this vehicle. In 2022, the lifter valves on the left side were replaced under warranty. It appears one of the left side lifter valves failed again, this time causing significant cam shaft damage and damaging the engine. Given that this issue appears to be affecting many owners with similar engine configurations, I would appreciate your assistance in investigating this matter to see if these issues stem from possible manufacturing defects which could result in engine damage or failure. I reached out to General Motors to ask if I qualify for extended coverage or any known service programs to address this situation and they told me I should talk to the dealership because they are unwilling to offer assistance. I've attached receipts for repair of the lifter valve in 2022 and the current diagnosis of engine failure, cam shaft damage, and lifter valve failure. This vehicle is only four years old and was regularly serviced by General Motors. It is available for further inspection. Please let me know what other documentation or information you require. Thank you.

[XXX] Vehicle had multiple engine lights on I immediately called dealership Battery and injectors replaced. [XXX] check engine lights on again Vehicle had an intake lifter break and damage the camshaft and caused cylinder misfire. Vehicle was said to be repaired. [XXX] Vehicle had total loss of forward power while driving causing me to drift to safety (Hazard)before being restarted lost the ability to be placed in reverse and limp mode took over. Vehicle was towed to Jim Shorkey Chevrolet in Bakerstown Friday April 11th 2025. (Unsafe to drive) Vehicle is in their possession with no replacement vehicle. I am waiting on a part that is not available and unknown when it will be available. Part unavailable Ten speed valve body part #24065354. Contacted service manager no calls back. Contacted Chevrolet Customer Care number [XXX] . Customer care claims the dealership does not respond to their requests. Currently without a vehicle a whole month. Service Advisor continues to promise courtesy vehicle with no follow thru. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My vehicle went from completely fine to having a loud knocking noise while I was driving 65 mph down the 4 lane highway. My vehicle lost power and slowed down. I was 50 miles from a dealership. They had to replace my entire engine and crankshaft. It cost over $12,000.00. This exact issue has been recalled by GM, but websites say my vehicle is not covered. The dealership had my vehicle for a month doing repairs.

The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving 20 MPH and approaching a light, there was an abnormal ticking and knocking sound coming from the vehicle. There were no warning lights illuminated. The contact stated that the vehicle failed to accelerate above 25 MPH. The contact stated that the failure was related to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The vehicle was taken to an independent mechanic who determined that the vehicle had experienced engine failure. The vehicle was taken to an unknown local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no further assistance was provided. The failure mileage was 132,000.

The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving 25 MPH, the vehicle was shaking and jumping and shut down unintendedly. The check engine warning light illuminated and was flashing. The vehicle was towed to the local dealer where it was diagnosed that there was catastrophic engine failure and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and confirmed there was no recall on the VIN. The failure mileage was approximately 104,000.

Safety Defect Complaint Vehicle Equipment: - Anti-lock Brakes - Full Front Air Bag - Passive Disabling Anti-theft Device Introduction: I am the registered owner and primary driver of a 2021 Chevrolet Suburban. I am filing this safety complaint regarding a serious system malfunction that occurred during an accident in 2023, resulting in injury to myself and my daughter. As a responsible vehicle owner who has maintained this vehicle according to manufacturer specifications since its purchase on July 21, 2021, I am deeply concerned about the safety implications of this incident. Safety Defect Description: In 2023, my vehicle experienced a critical system malfunction during a collision incident. While the vehicle was not in a rollover situation, the system incorrectly detected one, resulting in: 1. Complete vehicle shutdown during active accident conditions 2. All airbags deployed simultaneously 3. False rollover detection despite vehicle only experiencing vertical displacement when something from another vehicle hit the front of my vehicle Injuries and Medical Response: - Driver (self) sustained mild concussion requiring emergency transport - Daughter required emergency medical evaluation - Both occupants transported via ambulance to hospital Insurance Claim Impact: - MetLife denied accident and hospital claims - Denial basis: Absence of traffic citation - Virginia State Police report indicated no-fault accident - This denial has created significant financial hardship due to medical expenses and vehicle repairs - The vehicle's system malfunction has contributed to difficulties in proving accident circumstances Ongoing Vehicle Issues Post-Incident: - Persistent power loss issues, Multiple alignments required, Compromised driving dynamics and handling, vehicle does not track correctly despite repairs Safety Concern: The vehicle's incorrect rollover detection and subsequent complete shutdown during an active accident scenario presents a serious safety risk.

While at stoplight, check engine light came on and car starting shaking and could feel it hard shifting between gears. Heard banging noise from engine when trying to drive. Took it to the dealership and problems with camshaft and rod.

The lifters in the engine are failing

My sub starting making an unusual banging noise when shifting. I reported it once to the dealer and they chucked it up as cause by the vechioe being driving in auto and not set to 2 wheel drive or 4 but instead auto. Was odd, but it still happens and now there a recall but the site does not include my vin even though maybe this is my problem.

I bought the vehicle on January 11, 2025. Within 2 weeks the service leveling system indicator light came on the dashboard. The vehicle's front left air suspension system was not working properly and the vehicle lowered to the crash shield. The vehicle would not go over 55 miles and hour and was bouncing all over the road. The vehicle went back to the dealership and they reset and calibrated it. A few weeks later, the same thing happened. The vehicle again went down in the front, and was unsafe to drive. The dealership had the vehicle for 3 weeks, had difficulty assessing the situation and changed the front left air suspension arm. They told us it was fixed. We picked it up and as we were driving it home the service leveling system indicator came on, we brought it right back. They had the vehicle another 2 weeks and changed the solonoids, reset and recalibrated and had us pick it up. Within a few weeks the same thing happened, but worse. As I was driving it, an explosion sounded from the vehicle and the whole entire front of the vehicle lowered to the crash shield, making it extremely unsafe to drive. I have asked for the dealership to get a certified mechanic from GM to come and look at the vehicle and to start the repurchase process, no one is getting back to us and the vehicle is unsafe to drive.

While driving cross-country, my 2021 Chevrolet Suburban Z71 (5.3L V8) experienced several progressive symptoms leading to total engine failure. For months prior, there was a noticeable coolant smell from the engine bay despite no visible leaks. Multiple Chevy/GM shops noted the smell, and pressure tests showed no external coolant loss. On the trip to Colorado, the engine ran normally, but at idle, the temperature would steadily rise to ~235°F before fans would engage. Upon arrival in Colorado, I found the coolant reservoir was low again. The final time the vehicle started, it shook violently at idle for nearly a minute before settling. The next day, it would crank but failed to start, and has not started since. There were no check engine lights or warning messages at the time of failure. A GM dealership has since diagnosed the engine as “locked up” and quoted a $14,500 remanufactured engine replacement (GM Part 19420610). I’ve been told my engine is the 5.3L V8 (RPO L84), which is currently not included in GM’s safety recall 25V-274 affecting similar failures in the 6.2L L87 engines. Right before this occurred, I had a NC inspection (passed), a fresh oil change the same day, and had coolant added. This failure happened without warning, while traveling out of state, leaving the vehicle stranded in a garage and requiring towing. The situation presented a safety risk and significant financial burden. Given the similarities in symptoms and failure type to the recalled L87 engines, I believe this may be a related manufacturing issue.

While attempting to regain entry onto a major highway, our engine had a major system failure and the entire vehicle started to violently shake. We were able to reexit the highway and get to safety. We were then able to slowly drive it to a service station where it was determined after two days, that it was a major engine failure and would need a full engine rebuild. We were in Missouri when this occurred, driving back from Christmas vacation with family, on our way home to Texas. We had to find a hotel and stay two nights there, then had to rent two cars- as there were no cars available large enough for our family of 6 and our luggage, to then drive back to Houston. We then had to have our car transported down here to our mechanic. The repairs that our mechanic completed: BTR Gen V DOD/AFM Conversion Kit $1301.75 Full synthetic oil change and oil filter $110.00 Prestone Dex-Cool 50/50 prediluted antifreeze/coolant 2@$33.23 ACDelco GM Original Spark Plug 8@$20.32 GM Spark Plug Wire Set $142.44 GM Camshaft $200.04 Cloyes Engine Timing chain tensioner $44.54 Standard Ignition Manifold Absolute Pressure Sensor $47.85 Head Gasket, R&R $5010.00 Labor Oil Change $110.00 Labor Computer Programming $2000.00 Labor (reprogramming needed to shut off the Fuel Economy Management system that caused the camshaft to ultimately break) Total $9434.29 We were without our car for 4 months while this repair was conducted and the subsequent computer programming was problem solved. We learned there was a case already with your department, but waited to file out claim until we had the full repair and receipt from our mechanic. We could not afford to just sell the car as we would have gotten so little for it. Thus we didn't have much of a choice but to get it repaired. This week we are hearing of the massive recall of many GM vehicles, ours included, for this same problem. We are hopeful that we will get some sort of financial return to cover what we paid to fix their issue.

Worried about the safety of driving this vehicle due to the numerous reports of the engine seizing while driving. I have read about there being hundreds of thousand vehicles with the same engine having this problem. Thanks

Car would not start. towed into dealer for repair. This is the second time this has occurred, a well-known issue with GM trucks. on both occasions was a defective part, Fuel pump power control module.

History of transmission shifting issues shortly after purchase (CPO from Dealership). Vehicle was taken to two separate dealerships, several times for this issue while still under the 100,000 mile CPO warranty. Dealerships claimed they could not replicate the issue, however problem continued. Now at 1198xx miles, the transmission failed while driving. was accelerating from stop and and the vehicle bucked, the rpms jumped, the service indicator illuminated, and when the vehicle stuck in limp mode. I spoke with one of the dealerships and explained the history and suggested my vehicle failure was exactly as described in the safety recall and they informed my VIN was not included in any recall or service campaign and the could do nothing for me. I called the GM customer service number, pled my case and was told the same thing

For the past 2 years my windshield wipers will fail randomly while using them during a rain storm. I will have to pull over and completely turn the vehicle off turn back on and they may start working again or restart a couple more times. I’ve taken it to the dealership twice over it and the one time it was when they didn’t work and no codes showed up. It just happened again while on the turnpike during a rain storm. It’s very scary because some roads you can’t pull over right away and It’s very hard to see when the windshield is completely covered and the wipers won’t work. A major safety issue. I wanted to take a video but it’s not safe when I’m driving and trying to see out the window. I have 2 little kids and currently pregnant so this is very scary with my kids in the car.

After making a left turn on the street and picking up speed to 30mph the vehicle suddenly almost stopped and the engine raved up. It was so dramatic and unexpected that we thought the vehicle behind us was gonna hit us. Now vehicle only drives forward without shifting gears and doesn’t go reverse.

Chevrolet is telling me my engine has failed at 75,000 miles. While driving on the highway recently I lost all power. I had my 3 kids in the car and was driving at highway speeds on a crowded highway and lost all power. I had to move over to the side of the road while in neutral with no power. Once I was on the side of the road, I was able to then turn the car off and turn it back on. I then drove to the nearest exit to get myself and family out of harms way. The car then began making a significant loud screeching/knocking noise. I have video of this noise. Ultimately was towed to a dealership where I am now told that the car needs a new motor. Additionally, I regularly service my vehicle at the Chevrolet dealerships with on time oil changes as soon as the car says I am due. Twice since owning, my car has been so low on oil that I have to immediately add oil in between oil changes. Car is currently at the Chevrolet dealership and has not been fixed at this point. The vehicle has only been inspected by Chevrolet service tech at the dealership. No warning lights or other symptoms, besides the oil issue have ever occured with this vehicle. Please help!

[XXX] DIAGNOSE UNITS: 1.00 TECH(S) :1244 CUSTOMER STATES VEHICLE IS RUNNING ROUGH, MAKING A NOISE WHILE DRIVING COMING FROM THE REAR, PLEASE CHECK & ADVISE, FEELS LIKE RIGHT REAR WHEEL IS RUBBING checked over and found noise to be coming from rear differential. found bulletin #21-NA-028 for rear axle moan type noise on turns. followed service procedure per bulletin and drained and refilled rear diff service multiple times to correct customer concern. test drove vehicle after repair and noise is no longer present at this time. May be necessary to Drive vehicle multiple times to work lubricant into clutch pack. may require 1 more drain and refill if noise returns. If hesitation is still felt, recommend getting appointment set up for transmission diagnostic ARTS - - 0B # 1 - QTY - - - FP - NUMBER - [X] [XXX] -DESCRIPTION OIL 8.800 LIST PRICE-UNIT PRICE- $58.43 $58.43 JOB # 1 TOTAL PARTS JOB # 1 TOTAL LABOR & PARTS 179.00 $350.58 $350.58 $529.58 J# [XXX] *REAR DIFFERENTIAL UNITS: TECH(S) :1244 268.80 Added Operation [XXX] @ 03/05/2025 15:01) CUSTOMER REQUESTS PERFORM SYNTHETIC REAR DIFFERENTIAL SERVICE 3*#[XXX]& #[XXX] (07/22 AT TEMPERATURES OF 300 DEGREES & UP, TREMENDOUS STRESS IS PLACED ON THE DRIVE TRAIN LUBRICANTS. CONSEQUENTLY, THERMAL BREAKDOWN & DEPOSIT FORMATION HAVE BECOME COMMON, SHORTENING THE LIFE OF GEAR LUBRICANTS & THE COMPONENTS THEY ARE [XXX] SUPPOSED TO PROTECT. PERFORMED SYNTHETIC REAR DIFFERENTIAL SERVICE AND ADDED CONDITIONERS. INVE ARTS QTY - - - FP -NUMBER- -DESCRIPTION- - LIST PRICE-UNIT PRICE- ERANG JOB # 3 TOTAL PARTS 0.00 Company JOB # 3 TOTAL LABOR & PARTS $268.80 I am very disappointed at this dealership because they turn in the car and the problem is steel the same and they charge me $730.11 for a work that it was not done RADLEY CHEVROLET 11301 PATRIOT HWY FREDERICKSBURG, VA 22408 (540) 898-4000 WWW.RADLEYCHEVROLET.COM RADLEY CHEVROLET [XXX] Certified Service INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Lifter failure. At 30,000 miles the engine had lifter failure and was diagnosed and repaired by Donaldson Chevrolet in Silsbee Texas. This was covered under the original manufacturer warranty. Lifter failed occurred again approximately 13 months later and at 63,000 miles. There was no initials warning lights prior to the failure. The failure was sudden. Loud ticking/ knocking sounds and loss of power. At ideal vehicle would severely shake. Check engine light did come at time of failure. Both times the failure occurred during acceleration from a stop to approximately 40mph.

With no warnings from the vehicle, I noticed a loud knocking sound while driving home. I was able to make it home and have the vehicle towed to the dealer where it was found to be in engine failure due to failure of engine bearing. I had to have a complete engine replacement. My car only had 65k miles and was purchased brand new and had all regular maintenance completed at the local chevy dealership.

The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving at various speeds, the vehicle jerked while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and the contact was informed that the VIN was not covered under NHTSA Campaign Number: 24V797000 (Power Train), which the contact linked to the failure. The contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 75,000.

The contact owns a 2021 Chevrolet Suburban. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with fuel pump power control module failure. The contact was informed that the fuel pump power control module needed to be replaced. The vehicle was not repaired. The contact was informed that the parts to repair the vehicle had been ordered. The manufacturer was not made aware of the failure. The failure mileage was approximately 54,000.

Vehicle suddenly died and wont restart. The fuel control module was previously replaced. There was a recall for certain VINs but mine wasn't included even though I experienced the failure of the recalled part! This is extremely dangerous for the vehicle to suddenly die under way. In 2022 the fuel control module was replaced after the dangerous failure. The NHTSA recall that was for this part but excluded my vehicle is N212332040. You need to immediately include other VINs for this recall! Today I experienced the same symptoms. The car died while in gear and running and would not restart. The dealer is diagnosing the issue to determine if it is the same fuel control module. I highly suspect it is. If it isn't, there is another extremely dangerous defect with this vehicle.

Connecting rod bearing failure at 62,000 miles

My wife, [XXX] , was running some errands last night before taking our oldest daughter to dance practice and the check engine light appeared and the Suburban lost all power immediately. The engine wouldn’t restart and thank God she wasn’t on the highway. She called AAA roadside assistance who came out and checked the battery which was fine but ultimately had to get the vehicle towed to Bowman Chevrolet in Clarkston, MI. Vehicle is a 2022 Chevrolet Suburban and this is a serious situation that could have been catastrophic if this occurred on the highway that my wife was just on. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Chevrolet Suburban. The contact stated that while operating the vehicle, the infotainment center malfunctioned and displayed a black screen. The contact stated that the backup camera was inoperable. The contact stated that due to the failure, the vehicle was unable to receive over-the-air updates from the manufacturer that were safety-related. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was provided. The failure mileage was 88,000.

My car has 118,000 miles. The engine cam shaft just came apart, mechanic ordered new engine end of December and I’m told I’m still on a waiting list. I had to replace both sets of lifters when I had very few miles on car..of course the engine is now out of warranty. Thanks

While driving, a message appeared on the dash that stated 'reduced acceleration'. My car was not able to accelerate over 40mph. The engine was much louder than normal and sounded like a loud fan was running. The check engine light came on as well.

We were driving our Suburban and out of no where the check engine light starts flashing. Mind you we had no problems leading up to this very moment. We took it to a mechanic the very next day and were told we needed a new engine.

I was driving our 2021 Chevy Suburban, which had ~107,000 miles on it, at approximately 75 miles per hour. With no other indication, the low oil pressure light came on, then within two seconds I lost all power (motor shut off) and lost electronics in the car. I had to man-handle the vehicle to get it off the road without power or dash controls. Our family was stranded near the California/Nevada border with no cell reception in the middle of the night for over seven hours. I spent a fortune having the vehicle towed to a Chevy dealership (Wild West Chevrolet in Yerington, NV) where they indicated that there was a main bearing failure which caused the engine to seize. A full L87 motor replacement is required. The motor is currently on backorder with GM due to the high number of L87 engine failures. GM has not provided an estimated date of when they plan to have the motor replaced.

Loud ticking noise coming from the engine bay and extreme shaking. All happened after dropping off clients and getting on the highway on September 5, 2023. Took vehicle to two different mechanics and they said the camshaft and lifters had to be replaced. They recommended it would be cheaper and better if I replace the whole engine, which I did and had to pay out of pocket.

Hi, my name is [XXX] . I have two major issues with my 2021 Chevrolet Suburban: The value body failed for the 2021 Suburban in December, causing engine power reduction and the engine transmission was not shifting properly. This was covered by my extended warranty, which I paid $2500 extra for at the time of purchase. Also, this VIN is for a Chevy Suburban Duramax Diesel. The Emissions Control Module ( ECM ) light has come on several times, starting from about 20K miles to now 61K miles. I noticed the ECM light comes on at about a 8K mile interval. I take it into the dealership and they have told me this is due to a software issue and then they reset the light. This has happened on at least 4 occasions since about 20K miles. However, now at 61K miles, they are telling me that the exhaust system has a leak and it may not be a covered repair under even my extended warranty. Basically, General Motors has kicked the can down the road on the ECM issue until it is no longer under warranty, and now they want me to pay for this expensive repair. This is wrong, I hope you can protect me and other Duramax owners from GM's unscrupulous business practices. You can reach me at [XXX] for more details. Thank you, I am considering legal action against GM for this issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Driving at 65MPH on a three-lane highway with heavy traffic, there was a sudden loss of motive power without any prior warning. As the motive loss occurred, the check engine repair light illuminated. I immediately illuminated my hazard lights. Luckily I had enough momentum to safely glide the vehicle over three lanes to the breakdown lane. I was fortunate that other vehicles gave way to me or that I was not on an incline, otherwise the vehicle would have been stopped in the middle of the highway. After repeated attempts, the vehicle would not restart and had to be towed to a dealership. The dealership confirmed the problem and repair was covered under warranty.

brake master cylinder failure, took car to chevy after brakes got super hard to push , luckily no accident , felt like no brakes, at the point of failure, brake light, abs light, check engine light all went on ,at some point abs and brake light went off but check engine light stayed on and screen on Dash indicated max speed 62 then in a couple of minute screen showed max speed 42 mph , then lights go off except check engine and vehicle works as it should it randomly does this in one day so vehicle was taken in to dealership where they had a hard time figuring out if thats the problem and contacted gm tech support gm and they said with these codes it should be the brake master cylinder, and it would cost me 3000.00 to fix. on an 80 000.00 car that's a 2021 with 82,000 miles and they are pretty certain that will fix the problem, I'm pretty sure I don't want to get in an accident at 65 to 70 mph and die I feel this is a huge safety issue and thank god wife and kids weren't in the car considering this is my wife's car to drive the kids around in

Rear drive shaft friction Message on the display read: Service Transmission Now Unable to Shift Soon

The fuel tank strap bolts became loose and fell out, causing the fuel tank to drop. The vehicle has the original fuel tank and to our understanding, it has never been removed. We purchased the vehicle new and are the only owners.

Has been in the dealer multiple times for very hard shifting issues. Jerks when shifting gears from stop or in lower speeds. They have tried everything and cannot figure it out. But the techs have felt it when driving as well. It has been doing it for a long time. And it’s a concern when driving, I do not feel safe.

My wife was driving the car witb our kids when the check engine light came on and it started struggling and smoking. We got it to autozone to be scanned. The scan showed that it was a misfire on cylinder 3. After a mechanic trying to troubleshoot the problem he found that there was no compression. We towed the vehicle to a Chevrolet dealership where the found that the lifters in 1 bank needs to be replaced. This a known issue and a letter of coverage has been issued. However I'm being told that my vin number is not covered even though it is the exact same issue.

The fuel pump power control module (p129F, I believe) failed. I was in the carpool line when the engine sputtered then turned off, and would not turn back on. The engine light also came on. I had to walk my children the rest of the way, then got a tow truck. There were no dash light or other indications of a problem ahead of time. My local GM dealership was not able to get to me for multiple days, so I towed the vehicle to an independent mechanic. The mechanic informed me that there was already a recall on this part (Recall number N212332040). I paid for the repair, and when I contacted GM, was told that my VIN was not included in this recall. I would like my VIN added to the recall and other VINs with this same part that were not originally included in the recall.

The headlamps are defective and unexpectedly break causing them to aim basically straight down towards the pavement making it unsafe to drive at night. In February of this year I took the vehicle to Cox Chevrolet in Bradenton and they said the headlamps would need to be replaced and it would cost several thousand dollars. I rarely need to drive at night and have been taking our son's car since then. There is a chance one broke and I didn't notice at first then the second one but, at this point, it is unsafe to drive the vehicle at night. I have found several posts on online forums where owners of other GM/Chevrolet vehicles with the same headlamps have had the same experience. Some have mentioned that an adjuster pin breaks and is not repairable (which I have confirmed with a service advisor at another Chevrolet dealership). I am [XXX] who drives responsibly (i.e. not going off road in my Suburban) so having an issue like this is of concern as it makes the vehicle suddenly unsafe to drive at night. This is not a defect that is noticeable during the day so anyone purchasing a used vehicle with this problem wouldn't know they essentially don't have headlamps (I can see maybe 10 feet in front of the car) until they get on the road at nighttime. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was sold a vehicle from a dealership in Green Bay Wisconsin under the impression all safety regulations were met. The day I drove it off the lot, I had issues with the back drivers' door, making wind noise. I had messaged the salesman, he stated it may have been the door seal. Days went by, it wasn't sitting well with me, I made an appointment with a local body shop in. regard's to the door and suspicion of something not right. I brought it to the body shop, they informed me, that the back air bags were deployed and stuffed back into the roof, body work on the left side was done incorrectly and is very unsafe to drive, seat belts where my children sit were finger tightened, frame is held on by a bolt etc. The body shop states that if this vehicle were to be in an accident, it would not sustain impact the way vehicles are designed to do so. The owner of the dealership I had bought from refuses to come to an agreement about this situation. I have all the paperwork and documents from the body shop along with another local dealership near me who I also brought it to look it over as well so the owner could understand that this vehicle should have never been able to be sold on his lot. They also agree that this is super unsafe and should not be driven until it is fixed properly and all safety standards should be met. They believe that it should have been totaled out, it is very obvious that the left side was hit and smashed in. I also asked the owner if he would feel safe for his children to drive in this vehicle and he said, “no” I have many documents/pictures/reports to share once needed.

The headlight adjuster failed. As a result, the headlight points straight down creating a safety issue at night. I have read online this is a common problem on suburbans and tahoes. This happened on my car around 60k miles and only ~3 years.

The 22 inch rims on my vehicle are cast aluminum I'm assuming. I have had several cracks causing me to rapidly loose air on the tires while driving at highway speeds. I have had three cracks in different rims within the last week and have had the rims repaired twice. The vehicle has 75k miles on it. This is a major concern and safety issue. I've never seen that many cracks happen at once. Some say well your hitting potholes but that isn't the case here.

Rims keep cracking on the inside where the tire is sealed. This has happen a total of three times to both front and rear passenger side. Tire pressures are 36psi as recommended by manufacturer. No major pot holes or other road hazards have been hit.

The contact owns a 2021 Chevrolet Suburban. The contact stated while driving 55 MPH, the vehicle shut off unexpectedly and failed to restart. The transmission was in park(P) and failed to shift to neutral(N). The contact stated that several unknown warning lights were illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 21V739000 (Fuel System, Gasoline). The vehicle was towed to an independent mechanic, who determined that the failure was due to the fuel pump module. The vehicle was towed to the local dealer, where it was diagnosed that the failure was due to the module and a battery replacement was needed. The dealer jumpstarted the vehicle. The vehicle was repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 90,000.

Yesterday marked the 2nd time that the front windshield wipers on my 2021 Chevy Suburban (58k miles) randomly stopped working while driving down the highway in a rainstorm. They would not come out of the resting position regardless on what setting they were put to on the wheel switch. They continued to not work for the hour drive back to my house. The last time this happened all fuses, motor, etc were checked and tested good. The wipers started working again a day or so later, using the windshield wiper fluid button to test. This marks the second time my family has been put in a situation driving on the highway in a rainstorm with the wipers randomly stopping to work and having to navigate to safety with extremely limited visibility. This appears to be a fairly common issue with newer GM vehicles with the auto sense technology, found plenty of forums with the same experience. The major concern I have is that when this happens the wipers don’t work at all in any mode. Even trying to run in manual mode rather than auto sense the wipers will not move from the resting position. It leaves a driver with zero way to clear rain and see when this randomly occurs.

Service safety restraint constantly reappears. Taken into dealership 3 times and still has not been fixed. This could cause serious injury or harm and I have 4 children 10 and younger. This has been an on going problem.

A warning message appeared on my 2021 Chevy Suburban dashboard that says "Service Safety Restraint System". This impacts the airbag control module under the driver seat. After doing some research on my own this is a TSB PIT5759 but it is not covered under a recall, as per my local dealership. I took the vehicle to the Chevy dealership where purchased and was told this is not a recall or warranty part. This is very disappointing as it impacts the airbag controls which in an accident could cause severe injury or death.

Seat, mirror, steering column pre-set driver adjustments do not come into proper driving configuration on a regular basis when starting vehicle. This is a dangerous situation when a malfunction does occur. Seat has tendency to squeeze driver torso into steering column and knees into dash. LH mirror inadvertently and unexpectedly tilts down toward the ground and ofter unnoticed. This makes for a dangerous condition where the driver assumes that there is no oncoming rear traffic and it's safe to pull away from a curb from a stopped position. This condition has occurred for over a year and while the vehicle was covered under factory warranty. Numerous trips to Bonner Chevrolet in Kingston service department for remedy have yielded nothing. Bonner Chevrolet walked away from this serious issue and told us there's nothing more they can do and said, sorry. In contact with Chevrolet through Chat messaging, the recommend other surrounding dealers. None are interested at this point. the chat messaging is as useless as Bonner Chevrolet. Meanwhile I'm driving and paying for a useless and dangerous vehicle which no one knows how to repair. This has been an ongoing event since June, 2023.

Started car, noticed check engine light on and rough idle. Car barely would go in reverse to exit parking spot, so I attempted to pull back in. Car would not move forward. Able to switch to neutral and push back into spot. Could have been a very dangerous situation if it had occurred while driving or with my children in tow. Car would not restart at that point. Failed fuel pump @ 50,000 miles.

The contact owns a 2021 Chevrolet Suburban. The contact stated while driving at an undisclosed speed, the Forward Collision Avoidance system activated and abruptly applied the brakes, dramatically reducing the speed of the vehicle. Later, the contact stated that while driving at an undisclosed speed with the Adaptive Cruise Control activated, the vehicle inadvertently accelerated, requiring the contact to depress the brake pedal to avoid a collision. The vehicle returned to normal functionality, but the failure became a regular occurrence. The Forward Collision Avoidance warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the Forward Collision Avoidance warning light and the Adaptive Cruise Control module. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 28,000.

my car was hit on the side passenger back door in a parking lot while parked and nobody inside- had it look at by the chevrolet dealer- diagnosis is it needs a new engine??? make this make sense??? super disappointed with this car from the very beginning! will never buy chevrolet again

Same like my other 2 claims for livery vehicles Vehicle started losing RPMs and jerking while clients on board. Excessive fumes from exhausts started Diagnostics- misfire on a cylinder cause by faulty engine lifters. They all start like that. That also caused a cam shaft damage. Repairs paid out of pocket $14,000 for new engine. Incident happened around first week of December 2023. 200,000 miles Forums can tip you that there are many other similar cases with engine lifters issues from GM. Escalades and Suburbans and pick up trucks I will do my best to make other limo drivers from Chicago to submit same report. From my investigation problems occur between 30,000 and 200,000 miles.

At approximately 43,000 miles driving down the highway and lost power braking followed with a number of dash messages and lights. Took to dealer to discover the ABS Master Cylinder is bad and needs replaced and parts are 2 weeks out to have repaired. It appears after reading online this looks to be a problem with numerous people leaving comments etc.

The contact owns a 2021 Chevrolet Suburban. The contact stated while driving 5 MPH up the driveway, the vehicle lost motive power. The check engine warning light was illuminated. The contact was able to restart the vehicle; however, while the vehicle was idling, the engine shut off upon depressing the accelerator pedal. The vehicle was towed to the dealer, where it was determined that the fuel pump power control module had failed and needed to be replaced; however, the part was on a national backorder. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V739000 (Fuel System, Gasoline). The manufacturer was notified of the failure and informed the contact that the vehicle could not be repaired under the recall because the VIN was not included. The failure mileage was approximately 46,000.

Originally we had an engine light come on upon the engine chugging and the vehicle lunging forward at times. The diagnostic showed a bad lifter on the passenger side. They then replaced the passenger side lifters. We asked them to replace both sides since this was a known problem with our year, make, and model. They said they weren't replacing both sides of the lifters. Luckily we were still under the warranty for this repair. Now, a little over a year later on the day we were taking it to trade in, the engine light came on and the engine started chugging again. I knew immediately what the problem was. I took it to the same dealership and they quickly diagnosed it with a lifter failure on the driver side. Unfortunately we are out of warranty at 80,200 miles. The vehicle is only 2 years old. We have been advised not to drive the vehicle until it is repaired. I should not be responsible for the cost of the repair when this is obviously a known defect with the lifters for my year, make, and model. They should have replaced all lifters when the vehicle was originally brought in for the passenger side lifter failure. This should already be a recall by GM for the amount of vehicles that have and will experience this lifter failure. There is actually a class action lawsuit filed against GM for the lifter failure.

The contact owns a 2021 Chevrolet Suburban. The contact stated while driving 45-55 MPH, the vehicle lost motive power inadvertently. There was no warning light illuminated. The contact was able to veer to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed that the fuel pump power control module had failed and needed to be replaced. Additionally, the dealer informed the contact that the battery needed to be replaced. The contact related the failure to NHTSA Campaign Number: 21V739000 (Fuel System, Gasoline) however, the dealer informed the contact that the VIN was not included. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 90,000.

Vehicle stalled while driving in center lane on I-4 in Orlando in traffic. There were no warnings prior to the vehicle stalling. When trying to restart it, the low fuel warning appeared along with the check engine light. I was unable to restart the vehicle leaving us stranded in the middle lane of I-4 in heavy traffic. FL Road Rangers arrived to offer aid and had to manually place the vehicle in Neutral under the vehicle at the transmission. Vehicle was then pushed off the highway onto the shoulder. Vehicle was towed to Starling Chevrolet which was the closest Chevrolet dealer from the incident. Starling's Service Department had to replace the battery in order to run a diagnostic. Once the battery was replace, the diagnostic indicated that the issue is with the Fuel Pump Power Control Module Part No. 13544060 / 13554821. This part is on back order with no known availability time provided. Vehicle is still sitting at Starling Chevrolet. Although my vehicle does not show any open recalls, I found that the fuel pump power control module for the 2021 Chevrolet Suburban is part of a known Product Safety Recall N212332040 Stall While Driving.

The fuel pump power control module caused the fuel pump to fail and resulted in unexpected engine stall. The issue cause me and my 4 children to be stuck in the middle of the road waiting for a tow truck for over 3 hours. The vehicle could only be put in neutral while the car was on. Since I couldn’t start my car I could not put it in neutral to move the vehicle out of 2 way traffic. We want the issue confirmed by the dealership but the police who aided me and my children inspected the vehicle and recommend getting the fuel pump look at. No warnings were displayed.

Fuel pump incident identified in recall N212332040. NHTSA says our 2021 Suburban was not involved in the recall. But the incident happened 3 separate times. Our dealer made the repair under warranty.

While night driving driver noticed the driver side headlight completly pointing down providing no visibility. Vehicle was brought into GM dealership where is was discovered the Driver LED headlight adjuster screw broken causing a safety issue, where the light beam pointed down. Vehicle light assembly is currently being inspected for replacement under manufacture warranty under 36,000 miles.

The contact owns a 2021 Chevrolet Suburban. The contact stated while driving approximately 35 MPH, the engine started to misfire, and the vehicle lost motive power. The contact stated that the check engine and other unknown warning lights were illuminated. The contact was able to drive the vehicle to a dealer who diagnosed the vehicle and determined that the lifters had collapsed. The lifters were replaced on only one side of the engine. The vehicle was repaired. The contact stated that the failure recurred one week after the repair. The manufacturer had been informed of the failure. The failure mileage was 36,126.

The computer component surged, and the vehicle is available for inspection. The vehicle brake function is lost. Stepping on the brake paddle did not apply brake. Brake function was disabled by the computer. I took the vehicle to dealer, they said it was a component that has high resistance that cause it. But not sure why it has high resistance at that time and the resistance is gone after driver restarted the vehicle. No one else inspected the component beside the dealership. There was no warning at all and this is the first time it happens. Driver was just driving normally and suddenly all the light in the instructment panel started blinking and driver tried to apply brake but nothing happen. Luckly it wasn't rush hour, and driver was able to let the vehicle roll to the freeway exit on ram and use the up ram to slow the vehicle until it almost stop and changed gear to Park to stop the vehicle. Driver then restarted the vehicle and the problem is gone.

Second row drivers side seat headrest latching mechanism failed. The head rest will not stay in the upright position and is a safety hazard if someone is sitting in the seat as it hits the passenger in the back of the neck.

The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving at 25 MPH, the brake pedal seized while depressed, and the vehicle failed to stop immediately. The check engine warning light was illuminated, and "Brake System Failure" and another unknown message were displayed. The contact coasted to the shoulder of the road and parked the vehicle before shutting off. The contact's husband then restarted the vehicle and drove to the residence while the vehicle made an abnormal grinding sound when the brake pedal was depressed. The vehicle was taken to the dealer, where it was diagnosed that the master brake cylinder needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 30,000.

While driving on the I-4 interstate on Saturday August 5, 2023 - my 2021 Cheverolet Surburban stalled as if it had no fuel (had 3/4 of a tank). I was barely able to get over to the shoulder across three lanes of traffic on an overpass before it completely shut off! The Surburban would not start - when pressing the start button the ignition clicked for an extended period of time. We used On Star to contact GM/Chevy roadside support. They ran a remote diagnostic stating an issue with the Fuel Management System. I was told that this is a common problem with the fuel pump failure. I see there are open recalls for many other GM vehicles but not for my VIN currently. My Surburban has 40,669 miles. We waited over 3 hours for the tow truck that was dispatched by GM/Chevy. We were not in a safe location. Turns out my Surburban cannot be placed in neutral without the vehicle being started, which means it had to be dragged on and off the tow bed. I had to pay $450 to have it towed to my my home town dealer as we were 90 miles from home. We were originally going to tow it to a local dealer when the Surburban stalled but they told me not to as they are backed up and could even look at it for 9 days. I am now waiting on word from my dealer. Clearly the recall needs to be expanded based upon what we are finding online and from what everyone is telling us locally.

The vehicle is fixed

Engine stalled while driving on middle of the highway, lucky i was able to pull over to the breakdown lane by putting vehicle in neutral. I had reported the issue to the Chevrolet Onstar roadside assistance but while trying to get tow truck I had tried to start the engine multiple times and finally it started and left the engine light on dashboard. It was really scary with my kids in vehicle. Chevrolet should really look into this issue. My vehicle less than couple of year old and has only 16k miles.

3rd row middle seat belt covers (2) detached and fell off and seat belt retracted inside roof of vehicle. I had to fish out the seatbelt and tie to a metal clip to prevent the seatbelt from retracting inside the roof again. Third row middle seat belt is not usable.

The contact owns a 2021 Chevrolet Suburban. The contact stated while driving 15 MPH, the vehicle lost motive power and stalled without warning. The contact was unable to restart the vehicle. The vehicle was towed to the dealer, and the dealer stated that the fuel control module needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and stated that the part to repair the vehicle was not available. The failure mileage was 30,000. The VIN was not available.

On 27 Feb 2023 the vehicle started as usual. After parking and letting the engine idle while I assisted my elderly mother into the car, the vehicle unexpectedly stopped running. Several attempts were made to restart the car, but it only sputtered for a few seconds as if it were out of fuel. I then called GM roadside assistance and the vehicle was towed to Sandy Sansing Southern Chevrolet in Foley Alabama. My service Advisor Ronny advised me that this was a common failure of the Fuel Pump Power Control Module, however, there is no current recall. Except I did find a recall for a similar issue for other GM vehicles (Product Safety Recall N212332040 Stall While Driving) The dealership currently has 25 other vehicles awaiting a new module which could take up to 2 months.

My vehicle died unexpectedly in the middle of the road while backing out of my driveway with cars coming and going around me. It would not start up again nor could I put it in neutral to move it out of the way. I’ve learned my 2021 Suburban has a defective high pressure fuel modular. Also learned there is a parts shortage as well.

"SERVICE SAFETY RESTRAINT SYSTEM" message will often and randomly display, stay illuminated for random lengths of time, and then clear. Dealer Service centers are not taking the random/intermittent fault of the Safety Restraint System seriously. Passengers are at risk (unknow severity, assume the worst) due to a Faulty Safety Restraint System.

Multiple issues with transmission since owned. It randomly goes into "limp" mode and everything will blink and it won't start back. The transmission has always shifted hard and sounded funny they told me if was normal for the vehicle. Leaking transmission fluid when owned for 4 months. I have had to the dealer multiple times, several repairs, told it is safe to keep driving by GM. The inverter is bad and told me it was ok to drive until they can repair. GM will not give me a fair response or answer. The dealership won't buyback, and offered to purchase for nearly 30k less than I bought it for 18 months ago brand new. The engine light comes on and off randomly told me it was ok with a diesel it may do that when it gets cold.

2021 CHEVROLET SUBURBAN. CONSUMER WRITES IN REGARD TO SAFETY RECALL ADVISING THE THIRD ROW SEATING POSITION BEING UNSAFE.

- unknown what system or component failed? - while awaiting to make a left turn from left turn lane with two vehicles in front and unknown number of vehicles behind me, vehicle suddenly shut off - problem has not been reproduced or confirmed by dealer, nor has shut off re-occurred since first incident October 26, 2022 - vehicle or component has not been inspected by others - there were no warning lamps, messages, or other symptoms prior to the failure on October 26, 2022, the vehicle just seemed to quietly idle down and stop

2021 CHEVROLET SUBURBAN. CONSUMER WRITES IN REGARD TO NHTSA SAFETY RECALL 22V-617. THE CONSUMER STATED THE RECALL NOTICE INFORMED HER NOT TO USE THE 3RD ROW UNTIL THEY ARE ABLE TO FIX THE SAFETY ISSUE WITH THE SEATBELT BUT DO NOT HAVE A REMEDY FOR THE RECALL.

I'm writing to complain about the proposed temporary resolution of the recall. I received a letter today advising me that repair parts were unavailable and that I should simply not use the third row seats until the inspection/repairs are completed. Like many people who own Suburbans, I bought this vehicle because we are a family of six. This is the only vehicle in our home that can fit both adults and all four children. Not using the third row is simply not an option for us. This is an unacceptable solution, no matter how temporary.

With cruise control activated, at least 10 times since I bought this expensive vehicle the automated emergency braking activated at highway speeds - causing the vehicle to full brake without warning and nearly causing an accident each time (handling risk and risk of being impacted from behind by a following vehicle). I have formally reported this issue to dealers in MN and MT, and they only thing they said was they could not duplicate the condition during brief test rides and this was not a know problem. I personally know this was a known problem and GM did a safety recall for this condition on MY15-20 Suburbans. This condition is definitely an unreasonable risk to motor vehicle safety. In additional, the original tires supplied by GM (Firestone) failed under normal driving conditions after only about 35,000 miles, and both GM and Firestone denied there was any warranty coverage. Since then, new Les Schwab tires failed at about the same mileage. Something is obviously not right with this vehicle, and this condition is also an unreasonable risk to motor vehicle safety. Finally, last week my front passenger wheel cracked. I have not hit anything significantly hard with that wheel - but it is nonetheless cracked. This is also obviously defective and an unreasonable risk to motor vehicle safety.

In traffic, approx. 10-15 MPH car in front stopped short. I put foot on the brake pedal and pushed the brakes pedal to the floor. The car did apply the brakes equally as hard as I was Appling brakes at the pedal

We were traveling approximately 30 mph approaching an intersection of a 5 lane road. A vehicle in front t of us had pulled into the turn lane. As we approached the vehicle that was already completely in the other lane, our car suddenly braked to a complete stop even though my foot was only on the accelerator as it is a 40 mph speed zone.

I was driving on the freeway about 65 mph on Saturday June 18. In a sudden instant, there was a message on my dash "brake module failure" and "speed limited to 62 mph". Also warning message that "forward collision warning was off" , etc. The ABS light, the "check brakes light", and the check engine light all were on. Also, the power brakes went completely out and to stop I had to press really hard with manual brakes. I don't think a small framed person would have been able to stop and if I had been at a moment where I needed to stop quickly I don't think I would have been able to stop had there been a need to stop quickly. The dealer tells me that the brake master cylinder failed. The car has 43,000 miles and has been well maintained.

2nd time in less than a year it has had lifter failure. we travel almost every weekend and this puts my family in danger being broken down on a highway, especially at night. yes it has been confirmed and have been told that it is a wide spread problem no notice before it happened

While driving, I received a notice identifying a problem with the ESC system and that there was a brake system failure. I have received an advanced diagnostics alert about the antilock braking system. the vehicle was difficult to stop and required excessive pressure on the brake pedal.

The contact owns a 2021 Chevrolet Suburban. The contact stated while driving 80 MPH, the vehicle started shuddering and the engine was misfiring. The traction control, adaptive cruise control, and check engine warning lights illuminated. The vehicle then downshifted to 40 MPH independently. The contact turned the hazard lights on and continued to drive approximately 35-40 MPH. The vehicle was taken to the local dealer where it was diagnosed that two sets of engine lifters were bent and needed to be replaced. The manufacturer was notified of the failure and covered the replacement of one set of engine lifters under warranty while the other set was replaced at the owner’s expense. The vehicle was repaired. The failure mileage was approximately 12,800.

This vehicle has a problem with their lifters in the motor. It breaks down and you cause your engine to start shaking and makes a click sound like if its rubbing to something in the motor to cause a future problem in the motor and Engine light comes on. Many people have experienced this same problem with this make and model. My left lifter when out and they fixed it but what about my right lifter why didn't they replace the right lifter. This is a problem that Chev knows, and they have not recalled the lifters. Chev going after the company that made these lifters, so they know it's a problem why hasn't this been recalled? What if I was on a long road trip when this happens. This could blow out the motor and I could be stranded in the middle of now where if this happens.

Came to a stoplight and the car came to a stop. The car then automatically shifted into park on its own. The car would not shift out of park an the engine would not start. The car just died. Police showed up as I was in the middle of traffic and no one could even get the car to shift into neutral to push it out of the road. Very dangerous situation. Tow truck came and they could not even get the car in neutral. So they had to drag the car onto a flat bed. Dealer has examined the car. The starter was bad, the fuse box was bad but the major issue was in the engine where the lifters went out. To have the lifters go out at less than miles is unacceptable. The dealer commented that they are seeing this issue constantly from 2021 Chevy SUVs. This is a major safety issue in that there is no was to put my 2021 suburban in neutral when this happens to clear the vehicle from a busy highway. Please investigate this.

The contact owns a 2021 Chevrolet Suburban. The contact stated while driving 45 MPH, the driver’s side low-beam headlight was pointing inward, affecting his visibility of the roadway. The contact stated that the failure later occurred with the passenger’s side low-beam headlight. There were no warning lights illuminated. The vehicle was taken to the dealer who diagnosed that the headlights needed to be replaced. The manufacturer was not notified of the failure. The vehicle was not repaired. The approximate failure mileage was 62,000.

Car suddenly swerved, loud knocking started. Multiple system failures started flashing. Forward collision, ECS, traction control, the car was vibrating, jerky. I have multiple videos as well. The dealership literally told me they’d seen a ton of these when I called immediately and then told me to keep driving because the damage was done and if the engine died well then it’s under warranty. I have 3 children under 5 and that is NOT an appropriate answer when I asked about it being safe to drive considering it’s jerky/shaking/knocking, and has multiple systems down. I’ve also googled and joined forums and this is apparently a common issue in the 2021 V8s and Chevy refuses to issue a recall. Would be more than happy to provide videos as well it won’t let me upload them with the photos. Was told it could be weeks before they even have parts

My seat belt recall was not done said they did but did not do it ask them when were going to do it would never call or answer me need them to complete there recall on rear seat defective

After getting it serviced for airbag issue at the blasius chevrolet dealership in waterbury, ct. A week later, the car was was shaking while driving back home for work, the ESC message came up, forward collision came up, and traction control message also came up. Dropped it off at the dealership and said it was bad gas. Two days later, I was told that the misfire is caused by the lifter and pushrod was broken and that another 2021 suburban came in with the same issue but was suggesting it was our fault. There has been alot issues L84 engine that the misfire is due to a collapse lifter with less than 20K miles.

We have had several incidents of issues with the engine and electrical system. There are as follows: - NO CHECK ENGINE LIGHTS and engine failed. - Engine continues to be sluggish and hesitant. Headlights do not come on when in "auto" and it is dark outside. - Doors lock with the keys inside and the engine is off. - Keys are showing in sleep mode or not present when they are present. The engine went down on May 6, 2021 and I was on the highway with 2 of my children. I could not accelerate. There was traffic and could not keep up. I was able to get the truck to the delearship to have inspected and repair attempted. NO check engine lights.

Transmission leaked oil and the suv didn’t advice the loss of fluid. Still under repair

The lifter rods failed on my vehicle that has approximately 8,000 miles on it. The dealer said that this is a known issue and that there is a service bulletin out for it.

Drove up to a stoplight 4th car in a turn lane, came to complete stop. Some cars closed ranks a little further so i released my foot off the brake and moved up a few more feet and stopped again. The car then accelerated with brake fully depressed and wouldn't stop. I then put gear to neutral Tac was very high maybe 5000. Put car into park and then turned off the engine. Restarted car and continued on my way. Contacted Chevrolet and my dealership for a service diagnosis coming up July19,2021. No image to anyone but I have heard of this problem before a malfunction of electronics controlling the drivetrain. Can something be done before any injury or death occurs.

Purchased the new 2021 Chevrolet Suburban, 4 miles on odometer and left the dealer. Less than 20 minutes from dealer AC stopped working. Called dealer thinking it was small error. While on phone I looked under the vehicle which was now emitting foul burning odors. Noticed a very large amount of oil(1quart+) dripping from everywhere from engine to exhaust mid way down vehicle,oil cooler line was blown off. Towed newvehicle to dealer. Chevrolet wants me to keep this vehicle even though there was a TSB issued last year about this same issue. Chevrolet was supposed to fix before shipping vehicle and demanded dealers to do the same but did not follow its own advice. Now they want me the consumer to take a vehicle that now has 17 miles on it that has been repaired even though the issue was supposed to be remedied by manufacturer. GM/Chevrolet considers this a new vehicle even after major service for a known issue and wants me to marry this vehicle for 6 years of payments. I put down $22500 cash and this is the slap I get as consumer!

This evening while driving the windshield wipers started (while the wipers were in the off position). When using the turning signal it speeds up to approximately 3 times the normal speed. The display says the back hatch is open and the cargo light is on (the back hatch is closed). We turned off the car multiple times and the conditions persist.

The contact owns a 2021 Chevrolet Suburban. The contact stated while driving approximately 75-80 mph, the lifter collapsed and the contact heard the engine rattling. The contact pulled over and contacted the manufacturer, who provided a tow to the dealer. The dealer diagnosed the vehicle with a bent push rod and that the lifter had collapsed. The contact related the failure to the Technical Service Bulletin number: PIP5776C. The vehicle was repaired. The failure mileage was 6,600.

I WAS INVOLVED IN A 40 MPH FRONTAL IMPACT COLLISION WITH ANOTHER VEHICLE. THE INITIAL IMPACT OCCURRED ON THE DRIVER SIDE FRONT CORNER OF THE VEHICLE. DURING THE INITIAL COLLISION ME HEAD SWUNG SIDEWAY STRIKING THE B POST WINDOW AREA AND KNOCKED ME UNCONSCIOUS FOR A SHORT TIME. I THEN T-BONED A TRUCK AND FINALLY CAME TO REST AGAINST ANOTHER VEHICLE. AT NO TIME DID MY AIRBAGS (FRONT OR SIDE) DEPLOY. NOR HAS MY VEHICLE EVEN REGISTERED THAT I WAS INVOLVED IN A COLLISION. I REQUIRED MEDICAL ATTENTION AND WAS TRANSPORT TO THE HOSPITAL. AFTER EXAMINATION AND SCANNING/XRAYS, ETC. I HAD RECEIVED A CONCUSSION. I HAVE THE POLICE REPORT AS WELL AS MORE PICTURES IF REQUIRED. THE IMPACT WAS STRONG ENOUGH TO BEND THE FRAME ON MY VEHICLE.

WE WERE STOPPED AT A RED LIGHT ON FLORIDA STATE ROAD 54 TURN LANE TO GO ON US 75 WHEN THE OTHER CAR REAR ENDED US AND DROVE US INTO THE CAR IN FRONT OF US. NO AIR BAGS DEPLOYED. FLORIDA HIGHWAY PATROL CRASH NUMBER 88482185. WE ONLY HAD THE VEHICLE FOR 10 DAYS.