2009 Chevrolet Silverado 3500 Problems & Complaints

The contact owns a 2009 Chevrolet Silverado 2500. The contact stated while driving 30 mph, when an unknown warning light was illuminated. The contact called an independent mechanic who informed the wiring harness was melted and needed to be replaced. The vehicle was not diagnosed or repaired. A dealer was not contacted. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 14V407000 (Electrical System), however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 195,000.

The contact owned a 2009 Chevrolet SIlverado. The contact stated that while driving at 50 MPH, the contact drifted off the highway which caused his vehicle to flip over three times and land right side up. The contact was able to escape the vehicle without major injury. The air bags did not deploy during the crash. The authorities arrived at the scene and the contact was examined by paramedics. A police report was filed. The vehicle was towed to an independent tow yard where it was destroyed. Later that evening, the contact went to the emergency room where he was treated for a broken left rib. The dealer nor the manufacturer had yet to be notified of the failure. The contact received a recall notice for NHTSA Campaign Number: 21V053000(AIR BAGS). The vehicle had yet to be repaired. The failure mileage was approximately 90,000

Takata Recall. The contact owns a 2009 Chevrolet Silverado 1500. The contact stated that the air bag warning light was illuminated. The vehicle was taken to the local dealer for NHTSA campaign number 21V052000 (Air Bags) however, the vehicle was not diagnosed or repaired for the failure. The manufacturer was not notified. The failure mileage was 105,139.

Takata recall. The contact owns a 2009 Chevrolet Silverado 3500. The contact received a recall notice for NHTSA Campaign Number 21V050000 (Air Bags) however, upon contacting the dealer, he was informed that the remedy may cause the dashboard to crack. The contact was then informed that he had to sign a waiver to ensure that the dealer would not be held responsible for any damages to vehicle. The manufacturer was then notified of the issue and confirmed that the dealer would not be held responsible for any cracks or damages to the dashboard. The contact declined to sign the waiver and the vehicle was not repaired. The contact stated that the manufacturer should cover the cost of the dashboard because of the recall. The contact had not experienced a failure. Parts distribution disconnect.

Takata Recall. The contact owns a 2009 Chevrolet Silverado. The contact received a notification for NHTSA Campaign Number: 21V053000(AIRBAGS); however, the parts for the repair were unavailable. The dealer had been notified about the recall; however, the contact was informed that the parts were not yet available. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The contact had not experienced a failure. Vin tool confirms parts not available.

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO 3500. WHILE DRIVING 35 MPH, THE CONTACT HEARD A NOISE THAT SOUNDED LIKE A GUNSHOT. THE CONTACT NOTICED THAT BOTH SEAT BELT RETRACTORS DEPLOYED WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE SEAT BELT SECURED THE CONTACT, BUT HE WAS ABLE TO RETRACT THE SEAT BELT. THE CONTACT CALLED CHAMPION CHEVROLET OF HOWELL (5000 E GRAND RIVER AVE, HOWELL, MI 48843, (866) 354-3325) AND WAS INFORMED THAT THERE WAS NO TECHNICAL SERVICE BULLETIN OR RECALLS ON THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC AND WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 233,000.

THE DASHBOARD IS CRACKING IN SEVERAL PLACES AND I'M AFRAID THAT IF THE AIRBAG IS DEPLOYED IT MAY SEND PART OF THE DASH INTO THE PASSENGER.

WHILE DRIVING THE VEHICLE, THE ENGINE SUFFERED COMPLETE FAILURE DUE TO A SHEARED CAMSHAFT PIN. THIS RESULTED IN LOSS OF CONTROL OF THE VEHICLE SINCE IT WOULD NOT RESTART. I NARROWLY MISSED HAVING AN ACCIDENT BECAUSE THIS HAPPENED ON A BUSY MAIN STREET. I FEEL THIS TO BE A VERY SERIOUS SAFETY ISSUE TO WHICH A RECALL SHOULD BE REQUIRED.

TL* TAKATA RECALL. THE CONTACT OWNS A 2009 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT THE SERVICE AIR BAG WARNING LIGHT ILLUMINATED BEFORE BEING NOTIFIED OF NHTSA CAMPAIGN NUMBER: 16V381000 (AIR BAGS). THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

THE DASHBOARD IS CRACKED ABOVE THE AIRBAG AND ABOVE THE RADIO. THE VEHICLE HAS LESS THAN 60,000 MILES AND ACCORDING TO CHEVROLET IS OUT OF WARRANTY. THIS IS A SAFETY ISSUE DUE TO THE FACT THAT IF I AM IN A WRECK THE DASH COULD PUNCTURE THE AIRBAG OR EVEN ANOTHER PASSENGER.

2009 SILVERADO CRACKED PASSENGER SIDE DASH BOARD HAD IT REPLACED BY GMC DEALER AND IT CRACKED AGAIN SAME PLACE AS THE FIRST CRACK. TRUCK HAS LESS THEN 77 THOUSAND MILES.

THE DASH PANELS ON THE TOP OF THE DASH BOARD HAVE COMPLETELY BROKEN I FEEL THAT IF THE PASSENGER AIRBAG WERE TO DEPLOY IT WOULD BE A SAFETY ISSUE. PIECES OF THE DASH COULD POSSIBLY BECOME A HAZARD AND INJURE MYSELF OR MY PASSENGERS THIS NEEDS TO BE ADDRESSED THIS IS A VERY COMMON ISSUE AMONG MANY CHEVROLET VEHICLES

#09184 AIRBAG LIGHT STAYS ON AND MESSAGE SERVICE AIRBAGS IS ON.

CRACKING IDENTIFIED NEAR THE PASSENGER SIDE AIRBAG ON THE DASH OF THE TRUCK. DISCOVERED WHEN REPLACING TRUCK WINDSHIELD. CRACKING ALSO SEEN ON OPPOSITE SIDE OF DASH.

SEVERAL CRACKS IN MY DASH (4-5). ONE IS AT THE CORNER OF THE PASSENGER AIRBAG. THE DASH IS SO BRITTLE IT CRACKS FROM JUST CLOSING THE DOOR. I'M AFRAID WHAT MIGHT HAPPEN IF I'M IN AN ACCIDENT AND BROKEN DASH PIECES GO FLYING THROUGHOUT THE CAB. THIS IS NO DOUBT A SAFETY CONCERN! NOT TO MENTION AN EYE SORE AND RESALE KILLER. THIS STARTED A FEW YEARS AGO AND CONTINUES TO GET WORSE.

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE DOOR AJAR WARNING CHIMED BEFORE THE POWER DOORS LOCKED AND UNLOCKED INDEPENDENTLY, THE GAUGES FLUCTUATED AND THE INSTRUMENT PANEL ILLUMINATED. IN ADDITION, THE VEHICLE FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

PURCHASED USED VEHICLE FROM DEALER (DANIELS CHEVROLET, BUICK, GMC TRUCKS, INC. SWAINSBORO, GA) AND AFTER SALE DISCOVERED EMISSION SYSTEM WAS DISABLED AND DPF (DIESEL PARTICULATE FILTER) HAD BEEN PHYSICALLY REMOVED; PROBABLY BY PREVIOUS OWNER.

FUEL LEAKING/SPRAYING OUT OF THE REAR AUXILIARY FUEL TANK. I NOTICED A STRONG SMELL OF RAW GASOLINE COMING FROM THE REAR OF THE VEHICLE. UPON FURTHER INSPECTION I OBSERVED THE RAW FUEL WAS COMING OUT OF THE FUEL MODULE CONNECTING FUEL LINE. THE METAL FUEL LINE SITS IN A WELL OF THE REAR TANK AND WAS COMPLETELY COVERED WITH DIRT/MOISTURE/RAW FUEL. THE TANK WAS REMOVED AND WE IMMEDIATELY NOTICED THAT THE METAL PORTION OF THE FUEL MODULE METAL PIPING WAS RUSTED THRU AND THAT WAS WHERE THE RAW FUEL WAS BEING SPRAYED/POOLING IN THE WELL AREA. THE DESIGN OF THE FUEL TANK & MODULE CREATES A PERFECT LOCATION FOR DIRT/MOISTURE TO ACCUMULATE. ANY TYPE OF IGNITION SOURCE COULD HAVE CAUSED A CATASTROPHIC FIRE AND POSSIBLE EXPLOSION. THE REMOVED ORIGINAL FUEL MODULE WAS IN PERFECT WORKING CONDITION EXCEPT FOR THE ROTTED METAL PORTION OF THE MODULE. I REPLACED THE ROTTED FUEL MODULE WITH A NEW GM OEM FUEL MODULE. THIS NEW MODULE HAS THE SAME EXACT CONSTRUCTION AS THE ORIGINAL PART. SINCE THERE IS NO POSSIBLE WAY TO CLEAN OR KEEP CLEAN THE WELL AREA OF THE TANK, I CAN ONLY ASSUME THE NEW OEM PART WILL DETERIORATE IN THE SAME MANNER. THE VEHICLE HAD ABOUT 34000 MILES ON IT WHEN THE CONDITION OCCURRED. SINCE IT IS OUT OF WARRANTY THE NEW MODULE COSTS FOR LABOR AND PARTS WAS IN EXCESS OF $1000.00. IN CONCLUSION I THINK THIS MATTER SHOULD BE INVESTIGATED FURTHER BECAUSE IT IS OBVIOUSLY A SAFETY HAZARD INVOLVING RAW FUEL BEING EJECTED FROM THE FUEL TANK UNDER PRESSURE WHILE THE PUMP IS RUNNING.

WHILE DRIVING MY 2009 SILVERADO AT 33,000 MILES I NOTICED THE CHECK ENGINE LIGHT WENT ON AND IT WAS RUNNING ROUGH. AFTER TAKING TO THE DEALERSHIP IT WAS DETERMINED THE #7 CYLINDER WAS NOT WORKING. ACCORDING TO THE MECHANIC THE AFM FOR THE 5.3 LITER ENGINES HAS AN OIL CONSUMPTION ISSUE. HALF OF THE ENGINE WAS REBUILT DUE TO THE AMOUNT OF CARBON BUILT UP INSIDE THE ENGINE. AGAIN AT 78,000 MILES THE CHECK ENGINE LIGHT WENT ON AGAIN. THIS TIME THE DEALERSHIP HAD THE VEHICLE FOR 2 WEEKS TO AND DETERMINED THE ENGINE HAD EXCESSIVE CARBON BUILD UP AND A ENGINE SOAK WAS PERFORMED ALONG WITH SPLASH GUARDS ADDED TO THE VALVE COVERS TO KEEP THE ENGINE OIL FROM ESCAPING AS THE AFM WAS OPEARTIONAL. AT 98,000 MILES THE OIL PRESSURE SENSOR AND THE VALVE COVER GASKET HAD TO BE REPLACED. NOW, AT 140,000 MILES THE WATER PUMP, CRANK SHAFT AND BEARINGS HAD TO BE REPLACED. THE DEALERSHIP SAID I NEEDED A NEW ENGINE BECAUSE THEY WOULD NOT REBUILD THE ENGINE DUE TO THE MILEAGE. I HAVE CHANGED THE OIL EVERY 3,000 MILES AND STARTED USING FULL SYNTHETIC MOTOR OIL SINCE MY ENGINE ISSUES AT 33,000 MILES. GM IS AWARE OF THIS ISSUE WITH THE AFM AND CONTINUES TO DO NOTHING. I CONTACT GM CUSTOMER CARE AND THEY STATED THAT MY TRUCK HASN'T BEEN SEEN AT A DEALERSHIP IN OVER A YEAR, THEY WILL NOT ASSIST IN THE COST OF REPLACING THE ENGINE. BUT, THEY WILL GIVE ME A $1,000 CREDIT TOWARDS A NEW VEHILCE. INSTEAD OF FIXING THE PROBLEM, GM JUST TURNS THERE HEADS ON THE ENGINE PROBLEMS AND EXPECTS YOU TO PAY FOR A NEW GM VEHICLE. GM STAND BEHIND YOUR PRODUCT!!!!

CRACK DEVELOPED IN DASH AT APP 50K MILES NEXT TO PASSENGER AIRBAG. CRACK HAS CONTINUED TO EXPAND SINCE.

MAJOR OIL CONSUMPTION BURNED 4QTS BETWEEN OIL CHANGES TRUCK HAS THE 5.3L V8 NOT TO IMPRESSED DUE TO THE FACT IT ONLY HAS 75000 MILES ON IT

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE DASHBOARD ABOVE THE PASSENGER SIDE AIR BAG WAS CRACKED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

WAS TOLD BY DEALER THAT IMPACT SENSOR WAS BAD. VEHICLE HAS NEVER BEEN IN ACCIDENT. HERE THAT THIS IS A COMMON PROBLEM. SOUNDS LIKE GM IS USING A DEFECTIVE PART. VEHICLE HAS LESS THAN 20,000 MILES. COSTING ME $330 FOR REPAIR. CAN YOU CHECK INTO THIS ?

I GOT THIS TRUCK USED AT 94K MILES ON IT. IT WAS STILL IN STANDARD WARRANTY. I GOT THE OIL CHANGED STARTED GETTING THAT CLICKING/KNOCKING NOISE. I TOOK IT BACK TO THE SHOP THAT DID THE OIL CHANGED. THEY LOOKED INTO AND TOLD ME IT WAS A COMMON PROBLEM WITH CHEVY ENGINES IS THE VALVE LIFTERS BREAK AND NEEDS REPLACED ALONG WITH THE CAMS. IF I DRIVE TOO MUCH A POSSIBILITY TO ADD SHAVINGS INTO THE MOTOR AND TEAR IT UP. QUOTES FROM 3 DIFFERENT FRIEND RECOMMEND AUTO SHOPS FROM ALL OF THEM TO GET A NEW ENGINE OR GET RID OF THE TRUCK. I AM STILL MAKING PAYMENTS ON IT. SO CAN'T DO THAT. I DID TAKE IT TO THE DEALERSHIP AND THEY REFUSED TO HELP ME AT ALL. I WAS OUT OF THE WARRANTY PERIOD AND GOOD LUCK. THAT SUCKS! I DID MAKE A SCENE TO THEM IN FRONT OF CUSTOMERS. SINCE THEN I HAVE DONE SOME RESEARCH FINDING OUT THIS IS VERY MUCH A PROBLEM IN ALL CHEVY ENGINES DATING BACK TO 06. THE AFM, EXCESSIVE OIL CONSUMPTION. AT ONE POINT CHEVY DID DO A RECALL FOR A YEAR IN 07-08. FOR THIS PROBLEM. BUT NOT FOR ANY OTHER YEARS I CAN FIND. IF THEY KNEW/KNOW OF THIS PROBLEM WHY NOT SOLVE IT? I HAVE TO FIX THIS TRUCK ITS MY DAILY DRIVER AND WORK VEHICLE. TOTAL HATING CHEVY RIGHT NOW AND HAS ALWAYS BEEN MY LOVE! I AM A SINGLE MOM AND I KNOW HAVE TO COME UP WITH A NEW ENGINE ABOUT 3,500 THEN ADD LABOR AND SUPPLIES ABOUT 6K TOTAL. NOT HAVE AND VERY STRESSED OUT.

I HAVE A 2009 CHEVY PICKUP AND EVERY TIME YOU PUT THE BRAKES ON THE TAILLIGHTS COME ON BUT THEY WONT GO OFF WHEN YOU TAKE YOUR FOOT OFF THE PEDEL.NOW I'V CHANGED OUT THE SWITCH UNDER THE DASH 3 TIMES STILL THEY DO THE SAME THING SO I WENT BACK TO THE OLD SWITCH. WHY IS THIS HAPPENING TELL ME PLEASE I NOTICE I WAS NOT THE ONLY ONE THAT HAS THIS PROMBLEM???????????

2009 CHEVROLET SILVERADO. CONSUMER WRITES IN REGARDS TO CHASSIS ELECTRONIC MODULE CONTAINING INTERNAL CONTAMINATION RECALL NOTICE ISSUES. *SMD THE CONSUMER IS SEEKING REIMBURSEMENT, AS HE EXPERIENCED A FAILURE PRIOR TO THE RECALL. THE FUEL PUMP MODULE SHORTED OUT AND DAMAGED THE WIRING.*JB

2009 CHEVROLET SILVERADO. CONSUMER WRITES IN REGARDS TO THROTTLE POSITION SENSOR REPLACEMENT. *SMD THE CONSUMER STATED WHEN THE THROTTLE POSITION SENSOR FAILED, IF CAUSED A SIGNIFICANT REDUCTION IN ENGINE POWER AND DISABLED THE TRACTION CONTROL AND STABILITRAK FUNCTION. THE CONSUMER STATED THE THROTTLE POSITION SENSOR FAILED A YEAR AFTER HE PURCHASED THE VEHICLE. *JB

THE FIRST INCIDENT OCCURRED WHILE DRIVING THE VEHICLE ON THE HIGHWAY. THE ENGINE LIGHT CAME ON AND THE DASH READOUT GAVE A LOW OIL PRESSURE WARNING. THE TRUCK WAS TOWED TO THE DEALER. THEY SAID IT WAS A BAD OIL PRESSURE SENSOR AND REPLACED IT AT A COST OF APPROXIMATELY $450.00. FIVE MONTHS LATER THE SAME PROBLEM HAPPENED AGAIN WHILE DRIVING ON THE FREEWAY TOWING A HORSE TRAILER. I AGAIN HAD THE VEHICLE TOWED INTO THE DEALER. THEY SAID THE OIL WAS LOW AND DID AN OIL CHANGE. THE WARNING LIGHT WAS OFF WHEN WE GOT THE TRUCK BACK. THE LATEST INCIDENT HAPPENED ON 4/18/2015. THE ENGINE LIGHT CAME ON AGAIN. I BROUGHT THE TRUCK TO AN AUTO PARTS STORE WHERE THEY READ THE FAULT CODE. THE CODE IS P0521 - OIL PRESSURE SENSOR OR OIL LOW. I CHECKED THE OIL IT WAS NEARLY FULL BUT I ADDED A LITTLE ANYWAY. THE LIGHT STAYED ON. I MADE AN APPOINTMENT AT THE DEALER. THE LIGHT WENT OFF THE DAY BEFORE OUR APPOINTMENT. I BROUGHT THE VEHICLE TO THE DEALER AND NOW THEY ARE TELLING ME THAT THE TRUCK PROBABLY NEEDS AN OIL PUMP AND A VALVE COVER AND IT WILL COST APPROXIMATELY $1075.00 TO FIX. I HAVE DONE EXTENSIVE RESEARCH ON THIS PROBLEM ON THE INTERNET. THERE ARE HUNDREDS OF OWNER COMPLAINTS ON VARIOUS WEBSITES DOCUMENTING THE SAME PROBLEM I AM HAVING. THERE APPEARS TO BE A DEFECT IN THE DESIGN OF THE OIL SYSTEM IN THESE VEHICLES. MY TRUCK JUST WENT OUT OF WARRANTY IN DECEMBER 2014. THEY WANT ME TO PAY FOR THIS REPAIR EVEN THOUGH I HAVE ALREADY PAID FOR REPAIRS FOR THE SAME PROBLEM WHILE IT WAS UNDER WARRANTY. THIS APPEARS TO BE A SERIOUS PRODUCT DEFECT AND GM SHOULD ISSUE A RECALL. *TR

WIFE DROVE TRUCK TO THE STORE IT WAS RAINING HARD THIS DAY. CAME OUT AND TRUCK WAS DEAD. JUMPED THE TRUCK AND TOOK IT HOME.LOOKED AT THE BATTERY. STILL HAD FACTORY BATTERY. REPLACED THE BATTERY. NEXT MORNING THE TRUCK WAS DEAD. JUMPED THE NEW BATTERY TRUCK STARTED . TURNED TRUCK OFF /COULD HEAR SOMETHING RUNNING IN THE FUEL TANK. FOUND OUT THAT THERE WERE PROBLEMS WITH THE FUEL MODULE ABOVE THE SPARE TIRE. CALLED THE DEALERSHIP FOR THE THIRD TIME. CREG SMITH AUTO GROUP. GALION OHIO 44833. COULD NOT GET THE SERVICE MANAGER ON THE PHONE. LEFT HIM A VOICE MAIL. NEVER RETURNED MY CALL. NEXT DAY CALLED FOR SERVICE MANAGER. THEY COULD NOT FIND HIM IN THE BUILDING. TOLD A MAN ON THE OTHER END OF THE PHONE EVERYTHING THAT WAS GOING ON. SOMETHING WAS DRAINING MY BATTERY AND SOMETHING WAS RUNNING.24/7. MAN TOLD ME HE WOULD CALL ME BACK. NEVER DID. LEFT FOR DEALERSHIP WITH THE TRUCK. TRUCK STOPPED ON ME IN MIDDLE OF THE ROAD HAD IT TOWED HOME. NEVER MADE IT TO THE DEALERSHIP. I AM VERY UPSET WITH EVERYTHING NOW. I TURNED THE KEY AND THE TRUCK STUCK ON WAS STILL TRYING TO START AFTER I TURNED KEY OFF. . WAS AFRAID OF THE FUEL SYSTEM AND ELECTRICAL SYSTEM TOGETHER. .ONE SPARK COULD BLOW ME UP. NOW TRUCK WILL NOT START AT ALL. PLEASE HELP ME. I WAS TOLD BY DEALER THAT I HAD TO COME TO A DEALER .ALL PARTS HAD TO BE REPROGRAMMED FOR THE TRUCK. I HAVE NO MONEY ! ONLY OWE 2,400 AND TRUCK IS PAID OFF PLEASE HELP ME. *TR

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. WHILE DRIVING AT 35 MPH, THE VEHICLE LOST POWER. IN ADDITION, THE CONTACT STATED THAT REDUCED ENGINE POWER WAS DISPLAYED ACROSS THE MESSAGE BOARD. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 59,000. UPDATED 5/29/15*CN UPDATED 9/29/2017*CN

LOCKS STARTED LOCKING/UNLOCKING. GEAR INDICATOR WAS GOING FROM DRIVE TO PARK. HEAT CAME ON BY ITSELF AND FAN WENT FROM HIGH TO LOW. SPEEDOMETER WENT FROM 70MPH TO 55 MPH WITH LOSS OF ENGINE POWER. HEADLIGHTS WERE FLASHING ON AND OFF. AFTER PULLING OFF I-75 AND GETTING TO A SAFE STOPPING AREA THE TRUCK WOULD NOT START AFTER TURNING THE ENGINE OFF. THE ENGINE COMPARTMENT FELT EXTREMELY HOT: ESPECIALLY THE BATTERY. AFTER 10 MINUTES, THE TRUCK WAS ABLE TO START AND CONTINUE THE REST OF THE TRIP. AFTER DOING SOME INTERNET RESEARCH, THIS PROBLEM IS WELL DOCUMENTED ON VARIOUS CHEVY FORUMS AND CAR MESSAGE BOARDS. REPLACING THE MEGA FUSE AND BATTERY CABLES APPEARS TO SOLVE THE MAJORITY OF THE ISSUES AS IT DID IN MY CASE. THE DEFECTIVE MEGA FUSE AND BATTERY CABLES CAUSED THE EXCESSIVE VOLTAGE THROUGH THE CABLES, CAUSING EXTREME HEAT WHICH RESULTED IN SCORCH MARKS ON THE TERMINAL ENDS OF THE BATTERY CABLES AND THE INSULATION OF THE CABLES CHANGING COLOR AS WELL AS THE ABOVE ISSUES. I AM VERY GRATEFUL THAT AN ELECTRICAL FIRE DIDN'T HAPPEN WHICH I BELIEVE COULD HAVE EASILY BEEN THE CASE. *TR

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE PASSENGER SIDE DASHBOARD CRACKED WHERE THE AIR BAG WAS LOCATED. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 19,000. THE VIN WAS UNAVAILABLE. UPDATED 4/13/15*CN

THE BRAKE SYSTEM WENT OUT. THE DEALER REFUSED TO REPAIR UNDER WARRANTY, BECAUSE IT IS OUT OF WARRANTY. THIS IS THE SECOND 2009 WITH BRAKE PROBLEMS. ....UPDATED 04/02/15 *BF

TL*THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE STALLED WITHOUT WARNING. THE FAILURE RECURRED NUMEROUS TIMES. THE CONTACT DIAGNOSED THAT THE FUEL SYSTEM CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 56,000.

WELL MAINTAINED VEHICLE WITH LESS THAT 78K MILES AND TRANSMISSION FAILING. GM SHOULD BE FORCED TO STEP UP AND PAY FOR THE REPAIRS. VEHICLE IS A LEMON. HAVE REPLACED AND FIXED MULTIPLE OTHER ISSUES. 3 DOOR LOCK ACTUATORS GONE OUT...2 TIMES FIXED FUEL SYSTEM VAPOR CANISTER...PASSENGER WINDOW SWITCH FAILED...CRUISE NOT WORKING... *TR

I WAS DRIVING IN HEAVY TRAFFIC AND USED MY LEFT TURN SIGNAL ALL OF THE LIGHTS IS THE TRUCK STARTED FLASHING AND THE DOORS UNLOCKED AND LOCKED THEM SELVES. THEN TWO MILES LATER STILL IN HEAVY TRAFFIC I FLASHED MY LIGHTS AT A TRUCK TO LET HIM KNOW HE COULD SAFELY ENTER MY LANE AT WHICH POINT THE TRUCK CUT COMPLETELY OFF GOING 35 MPH IN HEAVY TRAFFIC. THIS IS VERY UNSAFE AND I AM LUCKY THAT NO ONE WAS FOLLOWING TO CLOSE. *TR

ACCELERATOR STUCK DRIVING ON AN INTERSTATE GOING 65M/H. SLAMMED ON MY BRAKES TOOK A GOOD 30 SECONDS BEFORE I COULD GET IT TO SLOW DOWN AND STOP ON THE SIDE OF THE ROAD. HAS NOT HAPPENED SINCE. *TR

WENT OUT TO TRUCK TO MOVE IT AND NOTICED WIPERS UP ON WINDSHIELD, TRIED TO START IT AND ONLY CHECK ENGINE LIGHT CAME ON , LOOKED UNDER HOOD TO FIND AN ELECTRICAL BURNING SMELL COMING FROM FUSE BOX. DISASSEMBLED FUSE BOX TO FIND IT WAS MELTED AND FOUND EVIDENCE OF COMBUSTION, WIRING HARNESS CONNECTOR X2 PIN N5 WAS MELTED AND CONNECTOR X5 PINS G1 H1,2,3,4 K 4,5,6 AND J 2,3,4 HAD MELTED THIS IS ALL THE DAMAGE THAT I FOUND. *TR

THE DASH ON MY 2009 CHEVROLET SILVERADO HAS CRACKED AROUND THE PASSENGER SIDE AIR BAG. THIS CONCERNS ME AS IF THE AIR BAG DEPLOYS THIS WILL CAUSE PIECES OF THE DASH TO INJURE THE PERSON IT IS SUPPOSED TO PROTECT. THERE IS NUMEROUS INFORMATION ON THE INTERNET WITH PEOPLE WITH THE SAME PROBLEM. I TOOK THIS TO THE CHEVROLET DEALER I BOUGHT THE VEHICLE FROM IN FOLEY AL AND THEY REFUSE TO DO ANYTHING ABOUT IT. *TR

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE HAVING THE ANNUAL SERVICE PERFORMED, THE TECHNICIAN NOTIFIED THAT CONTACT THAT THE FRONT BUMPER WAS EXPOSED TO WATER CAUSING A SHORTAGE IN THE SENSOR. THE FAILURE CAUSED THE AIR BAG LIGHT TO ILLUMINATE AND IT WOULD PREVENT THE AIR BAG FROM DEPLOYING DURING A CRASH. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 76,600. UPDATED 12/9/14*CN THE CONSUMER STATED THE LEFT FRONT CRASH SENSOR HAD WATER DAMAGE. THE VEHICLE WAS REPAIRED. UPDATED 6/1/2015 *JS

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 55 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE AIR CONDITIONER TURNED OFF WARNING INDICATOR FLASHED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE THERMOSTAT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,000.

DASH BOARD CRACKED AT PASSENGER SIDE AIRBAG, CONCERNED ABOUT SAFETY OF PASSENGER IF BAG DEPLOYS IMPROPERLY DUE TO THIS COMPROMISED DASH. *TR

MY CHEVY TRUCK IS A C1500.I ALSO HAVE A CRACK IN THE DASH ABOVE MY PASSENGER SIDE AIR BAG ON THE DASH.I NOTICED IT WHEN MY TRUCK ONLY HAD 10,000 MILES ON IT. IT'S NOT FROM THE SUN BECAUSE MY TRUCK STAYS IN THE GARAGE.IT SEEMS THERE ARE MANY OF US THAT HAS THIS ISSUE. *TR

KEY COMES OUT OF THE IGNITION WHILE TRUCK IS RUNNING. *TR

REAR PASSENGER DOOR LOCK DOES NOT LOCK OR UNLOCK ON 2009 CHEVY SILVERADO. WHILE DRIVEING THE GRAND KIDS TO SCHOOL THE REAR DRIVER SIDE DOOR OPENED WHILE GOING AROUND A CORNER. THE GRANDSON DID ADMIT THAT HE HAD HIS HAND ON DOOR HANDLE. COME TO FIND OUT THAT THE DOOR LOCK HAS FAILED ON THIS DOOR. WE ARE LUCKY THAT WE INFORNCE THE SEATBELT RULES OR THIS WOULD HAVE BEEN A REAL ACCIDENT. I CONTACTED GM AND HAD THE VECHILE LOOKED AT. THE DOOR LOCK MOTOR HAS FAILED AND THE DELAER TOLD ME THAT IT IS A KNOWN PROBLEM AND THEY HAVE CHANGED 100'S OF THEM. I CONTACTED GM AND OPENED A CASE BUT GM SAID THAT THEY WILL NOT ADDRESS THE PROBLEM. ANOTHER LOCK HAS FAILED AND AGAIN GM WILL NOT ADMIT THAT THERE IS A PROBLEM WITH THE DOOR LOCKS. I SEE THAT THERE ARE 1000'S OF POSTS ON THE WEB ABOUT FAILED DOOR LOCKS ON THIS YEAR VECHICLE.

WHILE DRIVING DOWN THE HIGHWAY, HEARD A NOISE AND THEN NOTICED THE DASH ABOVE THE AIRBAG HAD DEVELOPED AN OBVIOUS CRACK THAT IS APPROXIMATELY 1 INCH LONG. UPON CLOSER INSPECTION OF THE DASH, NOTICED THAT THERE IS ALSO A HAIRLINE CRACK IN THE DASH ABOVE THE AIRBAG APPROXIMATELY 4 INCHES TO THE RIGHT OF THE FIRST NOTICED CRACK. *TR

ON THREE SEPARATE OCCASIONS THE FUEL GAUGE ON MY 2009 SILVERADO READ FULL, WHEN IT WAS ACTUALLY NEAR EMPTY. THE FIRST TIME WAS DRIVING THROUGH THE DESERT ON HWY 395 IN CALIFORNIA. THE OUTSIDE TEMPERATURE WAS OVER 100 DEGREES. I KNEW I HAD DRIVEN TOO FAR FOR THE GAUGE THE BE CORRECT. THERE ARE VERY FEW GAS STATIONS ON THAT ROAD. THE SECOND TIME IT HAPPENED WAS ON THE SAME ROAD A YEAR LATER DRIVING THROUGH THE DESERT. I FINALLY REALIZED THE PROBLEM WAS THE HEAT, WHEN IT HAPPENED AT MY HOME TOWN IN JAMUL, CA WHEN IT WAS OVER 100 DEGREES. THE LOW FUEL WARNING NEVER CAME ON AND THE GAUGE SAID FULL. I TURNED THE TRUCK ON AND OFF AND IT STILL SAID FULL. THE GAUGE CORRECTED AFTER I ADDED FUEL. I INQUIRED AT THE DEALER IF THERE WERE ANY RECALLS AND THEY SAID THERE WAS NOT. *TR

THE PROBLEM; SERVICE AIR BAG ILLUMINATES AND SHOWS UP IN THE MESSAGE CENTER. WENT TO CHEVROLET DEALER AND THEY TRIED TO CLEAR THE CODE WITH THE READER AND NO LUCK. THEY DON'T KNOW WHERE TO START, IT COULD BE ANYTHING THEY SAID. I DON'T WANT TO DUMP THOUSANDS OF DOLLARS TO RESEARCH A PROBLEM THEY DON'T KNOW IF THEY CAN CURE. HAS ANYONE ELSE EXPERIENCED THIS ISSUE? 2009 CHEVROLET 2500HD DIESEL. *TR

EXTREME CHATTERING OF THE REAR BRAKES UPON APPLICATION WAS OBSERVED BY THE OWNER/DRIVER, INCLUDING LOCK-UP OF THE REAR WHEELS (EVEN THOUGH ABS EQUIPPED). THE VEHICLE WAS TAKEN TO THE AUTONATION CHEVROLET SUPERSTITION SPRINGS DEALERSHIP (6330 E. SUPERSTITION SPRINGS BLVD, MESA, ARIZONA 85206) FOR INSPECTION AND REPAIR (SELLING DEALER). THE DEALERSHIP INFORMED THE OWNER THAT BOTH REAR BRAKE SLAVE CYLINDERS HAD FAILED AND LEAKED HYDRAULIC FLUID ONTO THE LININGS. THIS LEAKAGE HAD CAUSED THE STICKING OF THE LININGS TO THE BRAKE DRUMS AND RESULTING CHATTERING/LOCKUP OF THE BRAKES. POST REPAIR, THERE HAVE BEEN NO FURTHER ISSUES IN THE LAST 3000 MILES OF USE. THE REPAIR WAS AT THE EXPENSE OF THE CUSTOMER. AS THIS OCCURRED AT 36094 MILES AND FOUR YEARS OF SERVICE IN RESIDENTIAL USE, I CONSIDER THIS A PRODUCT FAILURE DUE TO SOME FORM OF MANUFACTURING AND/OR INSTALLATION DEFECT WITH THE BRAKE SLAVE CYLINDERS. IN 40+ YEARS OF AUTOMOBILE OWNERSHIP OF MANY BRANDS WITH MILEAGES INTO THE 140K+ RANGE, I HAVE NEVER HAD A SLAVE CYLINDER FAILURE, NOR HAVE I EVER HEARD OF A DUAL FAILURE. THIS WAS THE SAME COMMENT BY THE SERVICE TECHNICIAN AT THE DEALER. PLEASE INVESTIGATE, OR AT A MINIMUM, ADD THIS TO YOUR WATCH LIST DATABASE. I REVIEWED THE NHTSA'S WEBSITE LIST OF DEFECTS, BUT FOUND NOTHING REGARDING THIS TYPE OF INCIDENT. THE FACT THAT IT WAS A DUAL COMPONENT FAILURE AND COULD HAVE RESULTED IN AN ACCIDENT IF HARD BRAKING HAD BEEN REQUIRED BY THE OPERATOR, THE MANUFACTURER SHOULD BE MADE AWARE OF THE ISSUE. I ATTEMPTED TO DO SO PERSONALLY, BUT FOUND THE EXPERIENCE UNSATISFACTORY. *TR

USED THE VEHICLE FOR VACATION IN 2011 AS IT WAS JUST 1 YEAR OLD. VERY LITTLE BRAKE PED LEFT GOING DOWN HILL. GOING DOWN HILL AND STEP ON THE BRAKE AND THERE WAS A BAD VIBRATION AND GROWLING NOISE FROM THE BRAKES. I HAD IT CHECKED AND THE DEALER GROUND THE BRAKE ROTORS. THIS NEVER SOLVED THE PROBLEM, SO THEY REPLACED THE ROTORS. THIS SOLVED THE PROBLEM FOR THE WARPED ROTORS FOR A WHILE. NOW THE PROBLEM STARTED AGAIN WITH 23000 MILES AND ONLY GROWLS AND VIBRATES WHEN GOING DOWN HILL WHERE YOU HAVE TO STEP DOWN A LITTLE HARDER. HAD IT CHECKED OUT AGAIN AND THEY SAY THE ROTORS ARE WARPED AGAIN. I REPLACED THE ROTORS AND PUT NEW BRAKE PADS ON AND THE PROBLEM IS STILL THERE. I DO NOT DRIVE THE VEHICLE HARD AND ONLY ABOUT 4000 MILES PER YEAR. WHATS CAUSING THE BRAKE ROTORS TO KEEP WARPING. *TR

SEVERAL TIMES WHILE DRIVING AT VARIOUS SPEEDS THE STABILITY CONTROL WARNING LIGHT WOULD FLASH, THE DOOR LOCKS WOULD CYCLE AND THE GAUGES WOULD STOP WORKING. AFTER A FEW SECONDS THE WARNING LIGHT WOULD GO OFF AND THE TRUCK WOULD RETURN TO NORMAL. *TR I TOOK THE VEHICLE TO THE DEALER AND I WAS INFORMED THAT BOTH BATTERY CABLES HAD HIGH RESISTANCE AND NEEDED TO BE REPLACED. IT IS RIDICULOUS THAT BATTERY CABLES NEED TO BE REPLACED AT 62000 MILES. THE SERVICE ADVISER MADE A COMMENT THAT THIS WAS A COMMON PROBLEM BUT IT USUALLY HAPPENS WHILE THE VEHICLE IS STILL UNDER WARRANTY.

USED THE TRUCK AND PARKED THE TRUCK WITH NO PROBLEMS. THEN THE TRUCK SAT FOR 1DAY AND HAD HEAVY RAIN STORMS COME THROUGH THE AREA. THEN WENT TO USE THE TRUCK AND WHEN I WENT TO START IT UP THE TRUCK WOULD NOT TURN OVER DEAD AND HAD A STRONG SMELL PLASTIC BURNING WITH THE CARGO LIGHT STAYING ON .CHECK THE CIRCUIT BOARD UNDER THE HOOD AND FOUND THAT SOME OF THE FUSES HAD MELTED .NO OTHER PROBLEM WITH THE TRUCK UNTIL NOW. *TR

I HAVE A 2009 CHEVY SILVERADO 1500. THE SERVICE AIRBAG LIGHT CAME ON WHEN I STARTED THE CAR. I NOTICED THERE WAS A RECALL ON THIS EXACT THING IN THE YEAR AND MAKE OF MY VEHICLE. MY VIN NUMBER WAS NOT INCLUDED IN THE RECALL. AFTER TALKING TO A CHEVY REPRESENTATIVE THEY INDICATED THE BEST WAY TO SOLVE THIS PROBLEM WAS TO MAKE A CLAIM BECAUSE IT IS THE SAME PROBLEM SEEN IN OTHER 2009 CHEVY SILVERADOS, AND MY VIN MAY BE ACCEPTED THROUGH THE CLAIM. THE VEHICLE WAS PREVIOUSLY REGISTERED IN MISSOURI, A STATE THAT UNDER THE RECALL OF SOME OF THESE VEHICLES QUALIFIED. *TR

DRIVING ON I10 HEADING TO HOUSTON, THE ENTIRE TRUCK COMPLETELY SHUT DOWN, AND THEN TURNED BACK ON, THIS AGAIN HAPPENED 02/2014....THE WHOLE TRUCK SHUT DOWN , THANK GOD THE WHEELS DID NOT LOCK UP OR WE WOULD HAVE BEEN KILLED BOTH TIMES. IT IS AT THE DEALERS ...FREEDOM CHEVY SAN ANTONIO TX....SOMETHING IS BAD ON THE TRUCK...LIKE PLAYING WITH A LIGHT SWITCH...THE DASH, EVERY INSTRUMENT SHUT OFF BOTH TIMES, NOW I AM WORRIED THAT IT WILL HAPPEN AGAIN, AND I CAN NOT AFFORD ANOTHER TRUCK. I THOUGHT THAT THE 1ST TIME WAS JUST A FLUKE, BUT WHEN IT DID IT AGAIN, I KNOW NOW SOMETHING IS NOT RIGHT AND IS VERY DANGEROUS FOR ME AND MY LITTLE GIRL...PLEASE REPLY IF A HUMAN REALLY READS THIS. *TR

TRUCK COMES TO SCRETCHING HALTWITH MOTOR RUNNING BUT WONT GO, DOOR LOCKS AND ALL GAGUES GOING UP AND DOWN A 100 MILE AN HOUR. SOMETIMES EVERYTHING DEAD AND ALL OF A SUDDEN IT COMES BACK ON. AIR COMES AND GOES. ALL LIGHTS FLASH. THOSE UPRANDOM CODES. NO WARNING ITS GOING TO HAPPEN. RADIO WILL START PLAYING VERY LOAD CANT SHUT OFF. WHEN IT DOES THIS IT SOMETIMES LUNGES FORWARD ABOIT TWENTY FEET AND MAY RUN FINE OR DO IT AGAIN. WENT TO DEALER TRUCK STAYED 2 MONTHS. SAID THEY FIXED. FEW MONTHS LATER STARTED AGAIN, NEXT DEALER SAID THEY COULDNT FIND ANYTHING. CONTACTED GM ON BOTH INCIDENTS. NOTHING HAPPENED. *TR

AFTER HEARING ABOUT THE RECALLS ON CHEVROLET CARS ABOUT THE IGNITION I HAD TO TELL YOU THAT THE SAME THING HAPPENED TO MY TRUCK. THERE WAS A SUDDEN JARRING & THE TRUCK SHUT DOWN & WOULD NOT START BACK UP. *TR

DASHBOARD IS CRACKED IN SEVERAL PLACES, FROM AIRBAGS TO WINDSHIELD, AND IN FRONT OF INSTRUMENT CLUSTER. ALL ON TOP OF DASH. IT IS CRUMBLING AND I FEAR FOR MY SAFETY IF I AM IN A COLLISION. *TR

DRIVING DOWN HIGHWAY, CHECK ENGINE LIGHT POPS UP, TRACTIONS CONTROL INDICATOR LIGHT, ALONG WITH DIGITAL DISPLAY SAYING SEVERAL THINGS. SUCH AS, ENGINE REDUCED POWER, SERVICE TRACTION CONTROL SOON..........PULLED OVER, HAD A VERY ROUGH IDLE. MADE IT TO PARTS STORE AND HAVE THE TRUCK SCANNED. TURNS OUT IT NEED THE THROTTLE POSITIONING SENSOR NEEDS REPLACED. HAD THEM CLEAR THE CODE, DROVE FEW MORE MILES AND ALL HAPPENS AGAIN. *TR

AFTER UNLOCKING THE MANUAL DOOR LOCK ON THE TRUCK THE INTERIOR DOOR HANDLE WOULD NOT OPEN THE DOOR. THE LOCK WAS DISCONNECTED FROM THE INTERIOR LOCKING MECHANISM, EFFECTIVELY TRAPPING ME IN MY VEHICLE. AT THIS TIME I UNROLLED THE WINDOW AND USED THE KEY IN THE OUTSIDE DOOR TO TRY TO UNLOCK THE DOOR, BUT THE LOCK WAS JAMMED AND I WAS UNABLE TO LEAVE MY VEHICLE USING EITHER THE INSIDE OR THE OUTSIDE HANDLE OR LOCKS OR THE DRIVER DOOR. I WAS FORCED TO EXIT THE VEHICLE FROM THE PASSENGER SIDE DOOR. THIS IS A RECURRING PROBLEM AND SEEMS TO OCCUR MOST OFTEN AFTER RAINFALL OR A CAR WASH. THIS IS A SERIOUS SAFETY CONCERN IN THE EVENT OF A COLLISION, CAR FIRE OR WATER CRASH OR OTHER EMERGENCY THAT COULD POTENTIALLY BE FATAL AND SHOULD BE RECALLED TO PROTECT PEOPLE FROM BEING TRAPPED IN THEIR VEHICLES. IT IS ALSO NOTABLE THAT CONSUMER REPORTS HAS LISTED "LOCKS AND LATCHES" AS A COMMON PROBLEM AREA FOR A 2009 SILVERADO. I CONTACTED A CHEVROLET DEALERSHIP AND THEY REFUSED FULLY COVER THE REPAIR COST, WHICH WAS WELL OVER $250 AND THEY STATED THAT THE "DOOR LOCK ACTUATOR WAS DEFECTIVE". THE CORPORATE GM PHONE CALL CENTER WAS NOT HELPFUL AND TOLD ME IT WOULD NOT BE FULLY COVERED BECAUSE MY VEHICLE WAS JUST OUT OF BUMPER TO BUMPER WARRANTY. I BELIEVE THIS SHOULD BE RECALLED TO PROTECT CONSUMERS. *TR

ON 6/23/13 MY FATHER WAS MAKING A LEFT TURN OVER A 4 LANE STREET. HE WAS HIT BY A 2008 NISSAN ROUGE GOING BETWEEN 37-40MPH ON THE DRIVERS SIDE DOOR. MY FATHERS TRUCK WAS IN MOTION AT 4-6MPH. THE TRUCK SUFFERED EXTENSIVE DAMAGE, AND MY DAD PASSED AWAY HOURS LATER AT THE HOSPITAL DUE TO INTERNAL BLEEDING OF PELVIC AREA. THE TRUCKS DRIVE SHAFT WAS CUT IN A HALF. THE TRUCK HAS A 5 STAR SIDE CRASH SAFETY RATING, I DO NOT UNDERSTAND HOW A CAR THAT WAS NOT EVEN SPEEDING CRUMPLED THE TRUCK THAT BADLY. THE FRAME OF THE TRUCK WAS PUSHED SO FAR BACK THE GAS AND BRAKE PEDAL WERE ONE. *TR

CPSC:I13B0038A. 2009 CHEVROLET SILVERADO. CONSUMER STATED THE DASHBOARD RECENTLY CRACKED AFTER A RECENT COLD SNAP OF WEATHER. *LN GM OFFERED THE CONSUMER A 50% DISCOUNT, OFF THE $1,000 IT WOULD COST TO REPAIR IT. HOWEVER, THY WOULD NOT ADMIT IT WAS A DESIGN FLAW.

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE ENGINE POWER REDUCED SIGNIFICANTLY. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION, WHO STATED THAT THE THROTTLE POSITION SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 22,302. ...UPDATED 07-10-13 *BF

THE AMERICAN GENERAL 245/70/17 TIRES ON 2009 WORE OUT DOWN TO THE TIRES WEAR BARS 2/32 AT 16,000MILES THERE WAS HEAVY EDGE WEAR CHUNCKING PIECES OF TREAD . TIRE WERE ROTATED EVERY 5000 AND ALIGNMENT CHECKED. TOOK TO LOCAL CHEVY DEALER AND THEY FOUND A RECALL OR TECHNICAL SERVICE BULLETIN FROM AMERICAN TIRE AND ALL FOUR TIRES WERE REPLACED FREE OF CHARGE. HOWEVER THEY WERE REPLACED WITH AMERICAN GENERAL GRABBER H/T WHICH ALSO HAVE TO SOFT OF A RUBBER COMPOUND AND ARE WEARING OUT QUICKLY THE TRUCK HAS 26150 MILES ON IT NOW AND THE NEW TIRES ARE DOWN TO 7/32 WITH LESS THAN 10000 MILES ON THEM. START PUTTING BRIDGESTONE TIRES BACK ON THE TRUCKS CHEVROLET. *TR

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT SHE HAD THE CHILD LOCK ACTIVATED ON THE REAR PASSENGER SIDE DOOR. THE CONTACT ATTEMPTED TO OPEN THE DOOR FROM THE OUTSIDE OF THE VEHICLE BUT IT FAILED. THE CONTACT HAD TO ENTER THE VEHICLE FROM THE OTHER SIDE IN ORDER TO GET THE CHILD OUT. THE CONTACT ALSO MENTIONED THAT SHE WAS ABLE TO OPEN THE DOOR FROM THE INSIDE WHILE THE CHILD LOCK WAS ACTIVATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE CHILD LOCK NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 50,000.

WHILE DRIVING ALONG HIGHWAY I NOTICED THE SPEEDOMETER NEEDLE WAS ON ZERO. UPON FARTHER INVESTIGATION I FOUND ALL INSTRUMENT PANEL LIGHTS WERE OFF AND DIRECTIONAL AND HAZARD FLASHERS WOULD NOT OPERATE. I STOPPED, RECYCLED MASTER SWITCH OFF THAN ON, LIGHTS WORKED PROPERLY. EVENT OCCURRED AGAIN SIX DAYS LATER. *TR ## VIN FAILED ##

2009 CHEVY SILVERADO LOST TRACTION ON HIGHWAY DURING SLIPPERY ROAD CONDITIONS, VEHICLE SPUN OUT AND HIT A METAL ROPED FENCE HEAD ON AND ALSO WENT ACROSS THE MEDIAN AND SLAMMED THE FRONT END OF VEHICLE INTO A GUARD RAIL STOPPING IT INSTANTLY FROM GOING INTO ON COMING TRAFFIC. THE VEHICLES DAMAGE WAS ON THE FRONT END DIRECTLY IN THE CENTER CAUSING A WEDGE INTO THE RADIATOR, ENGINE AND BENT THE FRONT OF THE FRAME. THE IMPACT WAS VERY LOUD AND SOLID. THE IMPACT CAUSED THE TRUCK TO STAND ON THE FRONT OF VEHICLE, SLAMMING THE BACK END OF THE VEHICLE ON THE GROUND WITH GREAT FORCE. THE AIRBAG DIDN'T DEPLOY WHICH AT THE SPEED OF AROUND 60 MPH AND THE PLACE THE VEHICLE WAS HIT IN, MAKES ME VERY CONCERNED ON THE SAFETY OF THIS VEHICLE. MY 5 YEAR OLD SON SAID HIS RIGHT ARM WAS HURTING AFTER THE ACCIDENT AND WITH IN THE HOUR OF HAVING THE ACCIDENT MYSELF ENDED UP IN THE HOSPITAL WITH A STIFF NECK AND A VERY SOAR AND BRUISED BACK, I WAS RELEASED WITH MINOR INJURIES AND I CONSIDER MYSELF LUCKY. PLEASE LET ME KNOW IF ANYTHING CAN BE DONE ABOUT THIS SITUATION AND THE SAFETY OF MYSELF AND MY SON. *TR

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, THE ENGINE STALLED AND THE REAR DIFFERENTIAL SEIZED, CAUSING THE VEHICLE SKID. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND CALLED ROAD SIDE ASSISTANCE. THE REPRESENTATIVE THAT WAS SENT BY THE ROADSIDE ASSISTANCE SERVICE ADVISED THE CONTACT THAT THE THROTTLE CONTROL SYSTEM MALFUNCTIONED AND ADVISED THAT THE VEHICLE WAS NOT SAFE TO DRIVE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO HIS HOME WITHOUT FURTHER INCIDENT. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO REPLACE THE THROTTLE CONTROL SYSTEM. THE FAILURE MILEAGE WAS 62,000.

YOU CANNOT OPEN THE DOORS WITH THE HANDLE FROM INSIDE THE TRUCK IF DOORS ARE LOCKED. PULLING ON HANDLE WILL NOT UNLOCK THE DOOR. I FEEL THIS IS A MAJOR SAFETY ISSUE AS YOU WOULD NOT BE ABLE TO UNTIL YOU USE THE UNLOCK BUTTON. IF YOU ARE IN A CRASH YOUR INSTINCT WOULD BE THE USE THE HANDLE NOT TO UNLOCK IT FIRST. *TR

RAILROAD HYRAIL VEHICLE EQUIPPED, AFTER MARKET, WITH HYRAIL WHEEL ASSEMBLIES WHICH ALLOW THE VEHICLE TO OPERATE ON RAILROAD TRACKS. ONCE HYRAIL (FLANGED) WHEELS ARE RETRACTED, THE VEHICLE IS OPERATED OVER THE HIGHWAYS AND PUBLIC ROADS LIKE ANY OTHER VEHICLE. ON 10/9/12 NEAR FAIRVIEW, PAA RAILROAD EMPLOYEE WAS OPERATING VEHICLE ON THE RAILROAD TRACKS WHEN IT STRUCK A STANDING EQUIPMENT AT APPROX. 15 MPH. AIRBAGS DID NOT DEPLOY. CONCERN IS THAT THE INSTALLATION OF HYRAIL WHEEL ASSEMBLIES MIGHT BE IMPACTING THE AIRBAG SENSOR. THE HYRAIL WHEEL ASSEMBLIES EXTEND APPROX. ONE FOOT OF STEEL FRAMEWORK AHEAD OF THE FRONT AND REAR BUMPERS. THE PLACEMENT OF THESE ASSEMBLIES MIGHT INADVERTENTLY BE AFFECTING AIRBAG DEPLOYMENT IN CRASHES ON THE RAILROAD TRACK AND ON PUBLIC ROADS. *TR

TL* THE CONTACT OWNS 2009 CHEVROLET SILVERADO EQUIPPED WITH GOODYEAR WRANGLER TIRES, LINE SIZE (235/80/R17) DOT PJAB35HV4109. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH THE REAR DRIVER SIDE TIRE BLEW OUT. THE CONTACT STOPPED THE VEHICLE ON THE SHOULDER OF THE ROAD. THE TIRE WAS REPLACED. THE CONTACT INSPECTED THE OTHER TIRES AND NOTICED BUBBLES ON THE FRONT AND REAR PASSENGER SIDE TIRES. THE CONTACT HAD ALL FOUR TIRES REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE STATED THE TIRES WOULD BE INSPECTED BY AN ENGINEER. THE APPROXIMATE FAILURE MILEAGE WAS 27,000...UPDATED 10/22/12 *BF THE CONSUMER INSPECTED THE REAR TIRES AND DISCOVERED THE INSIDE DUAL HAD FAILED. THREE OF THE SIX TIRES ON THE AMBULANCE PROVED TO BE DEFECTIVE WITH AIR BULGES ON THEM. UPDATED 10/22/12

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO ADVISED THAT THEY NEEDED TO REPLACE THE WIRING HARNESS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND STATED THAT SOMEONE WOULD RETURNED HIS CALL LATER. THE FAILURE AND THE CURRENT MILEAGE WAS 56,000.

EXCESSIVE OIL CONSUMPTION AT OR ABOVE 1 QUART OF OIL PER 1,000 MILES. ALL PLUGS FOULED OUT AT 39,000 MILES AND ONE PLUG CRACKED. I CHANGE OIL EVERY 3,500 MILES AND REGULARLY TOP OFF OIL. THERE IS NO LEAKING OIL BUT IT IS SOMEHOW VAPORIZING RAPIDLY. THERE WAS NO REASON FOR THE VEHICLE TO FAIL LIKE THIS AT THIS STAGE IN ITS LIFE. CHEVY HAS COME TO STATE IN A BULLETIN CONCERNING A TWEAK TO THE VALVE COVERS TO KEEP THE OIL FROM VAPORIZING. CHEVY HAS EVEN MORE RECENTLY COME OUT WITH A RECALL AS OF 1/17/2012 TO ANNOUNCE THERE IS A LEGITIMATE ISSUE WITH THE OIL CONSUMPTION ON THIS MODEL CHEVY. THIS IS UNACCEPTABLE AND GM SHOULD PAY FOR ANY CURRENT DAMAGE TO THE TRUCK, WORN PARTS AND ALL. *TR

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, HE FELL ASLEEP AND LOST CONTROL OF THE VEHICLE. THE VEHICLE CRASHED INTO A CEMENT WALL AND THE FRONT DRIVER'S AIR BAG DID NOT DEPLOY. THE CONTACT SUFFERED HEAD INJURIES DURING THE CRASH. THE VEHICLE WAS REPAIRED. THE MANUFACTURER INVESTIGATED THE FAILURE AND CONCLUDED THAT THE AIR BAG PERFORMED AS DESIGNED. THE FAILURE MILEAGE WAS 46,000 AND THE CURRENT MILEAGE WAS 55,000.

THIS HAS BEEN ON GOING FROM DAY ONE MY TRUCK HAS 30900 MILES ON IT AND ALMOST 3 YEARS OLD HEAD LIGHTS FLICKER OR DIM OUT FOR NO REASON ALONG WITH THE DASH LIGHTS DEALER SAID IT WAS NOTHING THEY COULD DO IT WAS JUST THAT TYPE OF VOLTAGE REGULATOR. *TR

AT 46,487 MILES HAD TO SPEND $415.75 TO CORRECT ENGINE LIGHT COMING ON. NOW DOOR CHIME COMES ON AT RANDOM TIMES WHEN KEY IS NOT IN IGNITION. *KB

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED WHILE DRIVING THE CRUISE CONTROL WOULD NOT DISENGAGE. THE CONTACT DEPRESSED THE BRAKE PEDAL BUT IT FAILED TO STOP THE VEHICLE. IN ORDER TO STOP THE VEHICLE HE HAD TO SHIFT INTO NEUTRAL GEAR AND TURN THE VEHICLE OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 32,500.

WE COULD HEAR THE TRUCK MAKING A GRINDING NOISE AS WE SLOWED FOR A STOP SIGN. WHEN WE LOOKED, THE WHOLE BRAKE PAD WAS MISSING FROM THE DRIVERS SIDE REAR BRAKES. THIS CAUSED EXTENSIVE DAMAGE TO THE ROTOR. WE HAVE SINCE REPLACED THE REAR BRAKE PADS SEVERAL TIMES BUT THE FRONT BRAKES HAVE NOT BEEN REPLACED A SINGLE TIME.

TL*THE CONTACT OWNS A 2009 CHEVROLET SILVERADO 3500. THE CONTACT STATED THE BRAKES WERE VERY SPONGY WHEN HE DEPRESSED THEM AND THEY EXTENDED TO THE FLOOR. HE HAD TO APPLY EXTREME PRESSURE BEFORE HE COULD STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO INFORMED HIM THAT THE BRAKES WERE FUNCTIONING NORMALLY AND HE HAD TO USE MORE PRESSURE WHEN DEPRESSING THEM. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 6,600.

WHILE DRIVING 60MPH ON A HIGHWAY, THE TRUCK SUDDENLY LURCHED AND TWO WARNINGS CAME ON THE DASH; SERVICE STABILITRAC AND SERVICE TRACTION CONTROL. THE TRUCK ALSO OPERATED UNDER REDUCED POWER AND I HAD NO CONTROL OVER THE ACCELERATOR. GOING UP HILLS WAS AN ADVENTURE. THIS IS A SERIOUS SAFETY HAZARD FOR THIS TO HAPPEN WHILE DRIVING AT ANYTIME ANYWHERE. DID EXTENSIVE RESEARCH ONLINE, AND FOUND THIS IS A COMMON PROBLEM WITH GM STABILITRAC. BROUGHT TRUCK TO DEALER FOR REPAIR AND THEY SAID THIS IS THE FIRST ONE THEY HAD SEEN WITH THIS CONDITION. TRUCK HAD 37,400 MILES. DEALER REPLACED THROTTLE CONTROL BODY FOR FREE UNDER THE POWERTRAIN WARRANTY. TRUCK CURRENTLY RUNS FINE, BUT THE TRUCK DOES NOT IDLE AS WELL AS IT USED TO, SLIGHT VIBRATION AND STUTTER, DEALER SAID GM SAID THIS IS COMMON AND NOT A PROBLEM, IT IS SET ELECTRONICALLY AND CANNOT BE ADJUSTED. DO WE REALLY NEED ALL THIS ELECTRONIC CRAP? *TR

2009 CHEVROLET SILVERADO TRUCK HAD A FIRE IN THE DASH BOARD ON THE PASSENGER SIDE WHILE THE TRUCK WAS PARKED AND IN THE OFF POSITION. THE FIRE WAS ON THE TOP SECTION OF THE DASH OVER THE PASSENGER AIRBAG AREA. *TR

2009 CHEVROLET SILVERADO. CONSUMER STATES PROBLEM WITH VEHICLE ROTOR *TGW THREE WEEKS AFTER THE VEHICLE WAS PURCHASED, THE VEHICLE HAD TO BE SERVICED FOR A FRONT ROTOR PROBLEM. SINCE THEN, THE ROTORS HAVE BEEN TURNED AND REPLACED. ON AUGUST 24, 2010 THEY WERE TURNED AGAIN. *JB

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO 3500. THE CONTACT STATED WHEN DRIVING AT 40 MPH AND PULLING A 40 FOOT TRAILER LOAD, THE VEHICLE WOULD STALL WITHOUT WARNING. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE AND DID NOT PROVIDE A REMEDY FOR THE FAILURE. THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER FOUR TIMES IN RELATION TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ADVISED THE CONTACT TO TAKE THE VEHICLE BACK TO THE DEALER FOR FURTHER INSPECTION. THE FAILURE MILEAGE WAS 76,000 AND THE CURRENT WAS UNKNOWN.

TL* THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 35 MPH AND APPROACHING AN INTERSECTION, THE VEHICLE ABNORMALLY VEERED OFF THE ROAD. THE VEHICLE PROCEED TO TRAVEL OFF THE ROADWAY AND WENT AIRBORNE OVER AND EMBANKMENT BEFORE CRASHING INTO A DITCH. THE AIR BAGS DID NOT DEPLOY UPON IMPACT AND THE CONTACT SUSTAINED MODERATE TO SEVER INJURIES. THE CONTACT WAS TRANSPORTED TO THE HOSPITAL VIA AMBULANCE AND A POLICE REPORT WAS FILED ACCORDINGLY. THE VEHICLE WAS TOWED TO A CHEVROLET DEALER FOR REPAIRS. THE FAILURE WAS 13,800 UPDATED 7/16/10 *CN UPDATED 08/18/10

ENGINE JUST SHUTS DOWN. NO POWER. HAVE TO PULL OVER AND WAIT 5 MINUTES OR SO AND THEN IT WILL RESTART. NO PATTERN. HAS HAPPENED TRAVELING ON HWY. *TR

ON MARCH 10, 2009 WE PURCHASED A BRAND NEW 2009 CHEVROLET SILVERADO FROM NU CAR CHEVROLET IN NEW CASTLE, DELAWARE. ON SEPTEMBER 25, 2009, WHILE ON VACATION IN OCEAN CITY, MD, THE VEHICLE CAUGHT ON FIRE WITH US AND OUR TWO YOUNG CHILDREN (AGES 2 AND 5) INSIDE, STRAPPED IN THEIR CAR SEATS. WE WERE ABLE TO PULL THEM FROM THEIR CAR SEATS (TERRIFIED) AND GET A FIRE EXTINGUISHER FROM THE RESTAURANT WERE WE WERE PARKED TO EXTINGUISH THE FIRE. WE HAD THE VEHICLE TOWED BACK TO NU CAR CHEVROLET ON SEPTEMBER 26, 2009 AND IT HAS REMAINED WITH THEM EVER SINCE. THE DEALERSHIP AND GENERAL MOTORS DETERMINED THE CAUSE TO BE A DEFECTIVE WIRING HARNESS AND HAS ADMITTED FAULT (THERE WAS NO AFTER MARKET WIRING IN THE VEHICLE AND NO PREVIOUS ACCIDENTS). AS OF TODAY, FEBRUARY 5, THEY HAVE BEEN UNABLE TO REPAIR THE ISSUE AND ARE NOW GOING BACK AND FORTH WITH US TRYING TO GET US TO PAY MORE MONEY FOR A NEW VEHICLE SINCE THEY CAN'T FIND A 2009 REPLACEMENT MODEL. WE ARE REFUSING TO PAY ANY ADDITIONAL MONEY AND STATED THAT WE WILL ACCEPT A REPLACEMENT VEHICLE WITH SAME FEATURES AT NO COST OR WE WANT A FULL REFUND OF OUR VEHICLE PURCHASE. *TR

TL*THE CONTACT OWNS A 2009 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE SUN VISORS DO NOT BLOCK THE SUN ADEQUATELY. HE FEELS THAT THIS IS A SAFETY HAZARD BECAUSE VISIBILITY IS POOR AT SUNSET. THE CURRENT MILEAGE WAS 2,006 AND THE FAILURE MILEAGE WAS UNKNOWN.