Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2023 Chevrolet Malibu.
| Overall Rating | |
| Frontal Crash | |
| Side Crash | |
| Rollover |
Component: STRUCTURE:FRAME AND MEMBERS
General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Malibu vehicles. The front impact bar, a structural portion of the vehicle frame, may not be properly welded to the front frame rail.
Consequence: An improperly welded front impact bar may result in the front crash sensors not performing correctly, increasing the risk of injury in a crash.
Remedy: Dealers will inspect the right-hand and left-hand side of the vehicle's motor rail for an incomplete weld. If the condition is found, the vehicle will be repurchased by GM. Owner notification letters were mailed January 20, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020.
Component: BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
General Motors, LLC (GM) is recalling certain 2023-2025 Chevrolet Malibu vehicles. The rearview camera screen may display a distorted or blank image.
Consequence: A rearview image that does not display correctly reduces the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters are expected to be mailed May 18, 2026. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N262551720. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 2, 2026.
We decided to take a road trip 2023 chev Malibu with 142000 miles and transmission goes bad
The rearview camera system fails intermittently when the vehicle is placed in reverse. The display will either show a distorted image or go completely blank without warning. This issue has occurred multiple times. This malfunction significantly reduces rear visibility and creates a dangerous condition while backing, especially in environments with pedestrians or other vehicles. The failure increases the risk of a collision because the driver cannot rely on the camera system to safely monitor the area behind the vehicle. There were no warning lights, alerts, or messages prior to or during the failure. The issue appears to occur randomly and without any clear triggering condition. The vehicle has not yet been repaired because the manufacturer has issued a recall, but the remedy is not yet available. The condition has not yet been inspected by a dealer, but it matches the known recall involving rearview camera failure. The vehicle and camera system are available for inspection upon request.
The contact owns a 2023 Chevrolet Malibu. The contact stated that while driving 75 MPH, the vehicle jerked abnormally with several unknown warning lights illuminated and unknown messages were displayed. Additionally, there was a white fuel warning light illuminated with the message “Low Fuel” displayed after refueling the vehicle. The white exclamation warning icon with the "Shift to Park" message, the check engine warning light was illuminated, and the “Engine Power Reduced message was displayed. Additionally, the power train and ESC warning lights were illuminated. The vehicle was pulled over to the side of the road and towed to the residence. The vehicle was taken to a dealer, but the failure was not replicated; an aftermarket tracker was disconnected. The failure persisted, and the vehicle was taken to the same dealer, where it was diagnosed and determined that the battery needed to be replaced. The vehicle was repaired, but the failure recurred the following week. The vehicle was then taken back to the same dealer, but the failure was not duplicated. The manufacturer was not notified of the failure. The failure mileage was 57,619.
The 2023 Chevrolet Malibu has 2 NHTSA recalls and 26 consumer complaints on file. It received an overall safety rating of 5 out of 5 stars in NHTSA crash testing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
MY 2023 CHEVY MALIBU HAS A MISSING TURBOCHARGER SCREW THAT RANDOMLY CAME OFF FROM UNDER A METAL PLATE ON ITS OWN, GMC HAS A RECALL ON 2022 -2023 CHEY MALIBU WITH TURBO CHARGER ISSUES BUT THEY WONT COVER MINES BECAUSE IT DIDNT COME FROM A CERTIAN FACTORY ALTHOUGH THEY KNOW A HELL OF ALOT OF CHEVY MALIBU OWNERS HAVE TURBO CHARGER ISSUES AND THAT FACTORIES SHARE PARTS WITH OTHER FACTORIES THEY SAY THEY WONT DO A RECALL ON ALL THE MALIBUS UNLESS ALOT OF PEOPLE REPORT AND NHTSA MAKES GMC REALL ALL CHEVY MALIBUS TURBOCHARGER ( GM launched a special coverage program for 2022-2023 models with 1.5L engines due to turbocharger failures leading to "Reduced Engine Power". The program covers, or potentially reimburses, repairs up to 15 years/150,000 miles)BUT MY VEHICLE VIN ISNT COVERED.
Tread started separation on driver front tire
When I was in a car accident I was hit on the rear passenger side of my vehicle, right near where my side air bags are supposed to be located. I was hit at 50 mph and the airbags did not deploy.
On December 24, 2025, the contact's 2023 Chevrolet Malibu was involved in a severe side-impact collision. The vehicle was struck on the rear passenger side by a full-size pickup truck traveling at high speed (est. 60 mph) that failed to stop at a red light. The impact caused the contact's vehicle to spin approximately 180 degrees and strike a concrete median sideways, generating high lateral G-forces. FAILURE 1: AIRBAG NON-DEPLOYMENT. Despite the severity of the impact and the violent spin into a curb (rollover trip point), the side curtain airbags and front seat-mounted side impact airbags failed to deploy. The failure of the restraint system caused the driver to be thrown against the driver-side door structure, striking their head on the window and B-pillar. The driver sustained a concussion, cervical strain, and lumbar strain. Medical records confirm the injuries are consistent with impact against the vehicle interior due to non-deployment. FAILURE 2: EMERGENCY TELEMATICS MALFUNCTION. Immediately post-collision, the driver attempted to manually activate the OnStar/SOS emergency buttons. The system failed to connect to an advisor. Instead, the vehicle's infotainment screen malfunctioned, opening a voice-to-text transcription application. The system then bypassed the vehicle's internal telematics module and attempted to route the emergency call to the owner's personal cell phone, indicating a complete failure of the vehicle's emergency communication hardware. This resulted in a 34-minute delay in coordinating professional assistance. Contact notes; while this vehicle currently shows 0 open recalls, the failure mechanism (sensor non-response during side impact) mimics the defect described in NHTSA Campaign 22V923000 (GM Recall N222392300), where improper welding of the front impact bar causes crash sensors to fail. The vehicle is available for inspection. Police and medical reports confirm the incident details. No warning lights were illuminated prior to crash.
Check engine light will come on entire car will shut off. Shuttering, braking locks up, all power is reduced, especially engine power. car will get towed to the Chevrolet dealership in temple, Tx and Killeen, Tx for repairs. When hooked up to the scanner all 7 modules show as faulty. Chevrolet of Killeen replaced only 3 of the modules stating that was the issue. two days after repair same issue has happened. when hooked up to the scanner again all modules were faulty again including the ones that were just repaired. car has been in the shop for 100 days now. the car will cool down, and the check engine light will reset itself showing no issues repeat the process.
Brake system failure lost brakes twice, went and got a diagnosis reading and it said brake system module failure. That it lost communication with the module
The contact owns a 2023 Chevrolet Malibu. The contact stated that while driving 30-35 MPH, another vehicle collided with her vehicle on the rear end of the vehicle as well as the rear passenger side. The contact mentioned that the seat belt did retract during the impact. The air bags on the front driver and passenger sides deployed partially. The vehicle was still drivable. The insurance company informed the contact that they are waiting for a response from the auto body shop. The vehicle was not deemed a total loss. The contact stated she did not sustain any injuries. No Medical Attention. A police report was filed, however the police report was unknown. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 29,000.
Vehicle is registering multiple keys from surrounding like vehicles which causes the anti theft system to activate, disabling the vehicle and/or involuntarily draining battery.
At 40,000 miles, check engine light illuminated. Code reader stated P023F fuel pump secondary circuit open. When trying to take 2023 Malibu to dealership for repairs car would not start. Had to have car towed to dealership. Dealership confirmed same fuel pump error code. Confirmed no recall. Car is currently being repaired by dealership at my expense as dealership & GM says fuel pump is not covered by powertrain warranty. Cost is over $1500! Fuel pump should last longer than 40,000 miles! Please research this faulty fuel pump!
I brought in my used vehicle to the dealership the same dealership that I purchased my car from due to another issue i was having with the car. Upon inspection from the dealership a diagnostic test was done on the vehicle, the dealership gave me a invoice stating "airbag malfunction needs the airbag on horn". I purchased this used vehicle from this dealership 4-4-25,. 6-10-25 i returned for the issue I was having and the dealership gave me this invoice with the information concerning the airbag. Yes it is available for inspection. My safety is in jeopardy if no airbag deploys for the driver if im in any type of accident. I was not made aware by the dealership of not having a airbag. No the vehicle has not been inspected by police, insurance representative. No, there was no warning lamps, messages before finding out this information at the dealership . I did receive a acknowledgement of vehicle accident history stating " This vehicle is a used vehicle that has had prior structural body repair work, indicating that the vehicle has previously been in an accident. " No further information. I have no information as towhen this accident took place.
The fuel line to the engine is leaking an 2 gallons leaked onto my driveway. Also, the vehicle cabin was consumed with fuel fumes which was a hazard and dangerous. The was danger of the vehicle exploding or catching fire. No warning lights appeared. The incident occurred on [XXX]. The fleet vehicle has been taken to Belle Tire for repair; however, not inspected by the manufacturer. My husband and my safety were put at risk because car could have exploded when ignition was turned on. Please contact me at [XXX] by 2/28/25...thank you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2023 Chevrolet Malibu equipped with Continental Tires, Tire Line: Pro Contact, Tire Size: 245/40/R19, DOT Number: 6Y66WBR27. The contact stated that while his wife was driving at highway speeds, there was a blowout of the front driver's side tire. The cause of the failure was not yet determined. The tire was replaced. The contact stated that later while inspecting the vehicle it was discovered that the front passenger’s side tire had developed a sidewall blister. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 11,000.
Showing 15 of 26 complaints