Loading vehicle data from NHTSA...
NHTSA recalls, safety ratings, and consumer complaints for the 2004 Cadillac XLR.
| Trim | City | Hwy | Combined | Annual fuel $ |
|---|---|---|---|---|
| 4.6L 8 cyl Automatic 5-spd | 15 | 23 | 18 | $3,850 |
| Overall Rating | Not Rated |
| Frontal Crash | Not Rated |
| Side Crash | Not Rated |
| Rollover | Not Rated |
Component: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
Consequence: A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
Remedy: TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Component: VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IF ONE OF THE TWO ACCELERATOR PEDAL RETURN SPRINGS FAILS AND THE TEMPERATURE IS -22 DEGREES F TO -40 DEGREES F, THE ENGINE MAY NOT RETURN TO IDLE WITHIN THREE SECONDS, AS REQUIRED.
Consequence: IF THIS WERE TO OCCUR, GREATER BRAKE PEDAL FORCE AND A LONGER DISTANCE MAY BE REQUIRED TO STOP THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY. THIS RECALL BEGAN ON MARCH 8, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339 OR PONTIAC AT 1-800-620-7668.
The contact owns a 2004 Cadillac XLR. The contact stated that while driving approximately 70 MPH, there was an abnormal sound like a shotgun being fired overhead. The contact pulled over and observed that the retractable fiberglass roof panel had detached from the frame of the vehicle. The contact stated that the headliner, cables, and pulleys used to retract the roof were exposed. The contact was unable to recover the panel. The contact called the dealer and the manufacturer and was informed that there were no recalls on the VIN for the failure. The contact was informed that the roof panel could be replaced out-of-pocket. The vehicle was not repaired. The failure mileage was approximately 88,000.
The roof panel that was only attached with adhesive has detached from the frame of the car. This has also caused the retractable convertible top to stop working. I have read about the roof of many of these cars flying off while driving down the road. It is only a matter of time before this poor defect causes serious injury and/ or significant property damage. I called cadillac customer service and they refused to offer any help. I recently spoke to a local body shop about getting it repaired and the estimate was upward of 1000 dollars
The contact owns a 2004 Cadillac XLR. The contact stated while driving 65-70 MPH in the rain, the contact heard wind coming from the area where the front roof panel was connected to the windshield. The roof panel then detached and separated from the vehicle. The contact pulled into a service station to get out of the rain. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The failure mileage was approximately 113,420.
The 2004 Cadillac XLR has 5 NHTSA recalls and 34 consumer complaints on file. It received an overall safety rating of Not Rated out of 5 stars in NHTSA crash testing. For the most detailed information about a specific vehicle, decode its VIN using our free decoder above.
Enter a specific VIN to get the full report — specs, recalls, safety ratings, complaints, investigations, and technical service bulletins.
Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH ONE OR BOTH REAR BRAKE HYDRAULIC LINES THAT CAN COME IN CONTACT WITH OR BE AFFECTED BY HEAT FROM THE LEFT ENGINE EXHAUST MANIFOLD AND THE LEFT EXHAUST PIPE. THE BRAKE FLUID COULD REACH ELEVATED TEMPERATURES AND BOIL.
Consequence: IF THE BRAKE FLUID BOILS IN A REAR BRAKE LINE, THE EFFECTIVENESS OF THE REAR BRAKE SYSTEM WOULD BE REDUCED WHICH COULD RESULT IN A BRAKE LINE LEAK AND LOSS OF BRAKE FLUID. IF ENOUGH FLUID LEAKS FROM THE REAR BRAKE SYSTEM SO THAT BRAKE PEDAL APPLICATION CAN NO LONGER BUILD PRESSURE TO THE REAR BRAKES. THE OPERATOR OF THE VEHICLE WILL EXPERIENCE LIMITED BRAKING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL (1) INSPECT THE LEFT ENGINE EXHAUST MANIFOLD CLIP FOR PROPER ALIGNMENT AND PLACEMENT ON THE BODY-MOUNTED STUD. IF INCORRECT, THEY WILL REPOSITION THE CLIP ON THE BRAKE LINES AND REINSTALL THE CLIP ON THE STUD; (2) THE DEALER WILL VERIFY THAT BOTH REAR BRAKE LINES HAVE THE PROPER CLEARANCE TO THE LEFT EXHAUST PIPE. THEY WILL REPOSITION THE LINES BY BENDING AS NECESSARY; (3) DEALERS WILL REMOVE THE MACHINING TAB FROM THE REAR DIFFERENTIAL HOUSING. ALSO, DEALERS ARE TO INSPECT THE BRAKE LINES FOR WEAR IN THESE RELATED AREAS AND REPAIR OR REPLACE IF THERE IS ANY SIGN OF WEAR-THROUGH ON THE NYLON OVERCOATING. THE RECALL BEGAN ON JANUARY 18, 2005. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2239 OR CHEVROLET AT 1-800-630-2438.
Component: EXTERIOR LIGHTING:TURN SIGNAL
ON CERTAIN PASSENGER VEHICLES, THE DAYLIGHT RUNNING LIGHTS (DRL), TURN SIGNAL, AND PARKING LAMPS USE THE SAME BULB. THE BULB MAY BECOME DAMAGED FROM VIBRATION WITHIN A LOOSE FITTING SOCKET OR AIR ENTERING THE BULB DUE TO AN INADEQUATE SEAL. BOTH OF THESE CONDITIONS WILL CAUSE THE BULB TO BURN OUT PREMATURELY.
Consequence: IF THIS WERE TO OCCUR, THE DRIVER WOULD NOTICE THAT THE ARROW IN THE INSTRUMENT PANEL WOULD FLASH FASTER THAN NORMAL WHEN THE TURN SIGNAL IS ACTIVATED. THE LOSS OF THE DRL AND TURN SIGNALS COULD FAIL TO WARN OTHERS OF THE DRIVER'S PRESENCE OR INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE SOCKET AND BULB IN BOTH LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339.
Component: STEERING:LINKAGES
ON CERTAIN PASSENGER VEHICLES INVOLVED IN THIS CAMPAIGN, THE LOWER CONTROL ARM BALL STUD NUT/WASHER ASSEMBLIES WITH WASHERS WERE MADE OF THE WRONG MATERIAL. THE WASHERS MAY FRACTURE AND BECOME LOOSE OR FALL AWAY FROM THE VEHICLE, REDUCING CLAMP LOAD. SEPARATION OF THE CONTROL ARM BALL STUD AND STEERING KNUCKLE, DUE TO DISENGAGEMENT OF THE TAPERED ATTACHMENT AND RETAINING NUT, IS POSSIBLE.
Consequence: IF THE CONTROL ARM SEPARATES FROM THE KNUCKLE, THE AFFECTED CORNER OF THE VEHICLE WILL DROP AND THE CONTROL ARM WOULD BE FORCED DOWNWARD, CONTACTING THE WHEEL. THE AFFECTED WHEEL COULD TILT OUTWARD AND CREATE A DRAGGING ACTION THAT WOULD TEND TO SLOW THE VEHICLE AND CREATE A TENDENCY FOR THE VEHICLE TO TURN IN THE DIRECTION OF THE AFFECTED WHEEL. IN EXTREME SITUATIONS, THE AFFECTED WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE. SEPARATION OF THE WHEEL ASSEMBLY WOULD ALSO SEVER THAT WHEEL;S HYDRAULIC BRAKE HOSE AND RESULT IN DIMINISHED BRAKING PERFORMANCE OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE BALL STUD JOINTS AND MEASURE THE TORQUE OF THE NUT FOR ALL FRONT LOWER CONTROL ARMS IN ALL MODELS AFFECTED AS WELL AS THE REAR LOWER CONTROL ARMS ON THE XLR AND CORVETTE. IF THE TORQUE IS NOT AT SPECIFICATION, THE DEALERS WILL REPLACE THE BALL STUD, THE KNUCKLE, AND THE NUT. IF THE TORQUE IS AT SPECIFICATION, THE DEALERS WILL REPLACE THE NUT/WASHER ASSEMBLY ONLY. THE RECALL WILL BEGIN ON AUGUST 25, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339 OR CHEVROLET AT 1-800-630-2438.
The top roof panel separated while driving on the highway, and almost struck another vehicle causing it to swerve to miss it. The vehicle then proceeded to follow me as he though I was to blame. Once I got off the highway he got out of his car an violently started screaming at me for almost causing an accident.
The contact owns a 2004 Cadillac XLR. The contact stated that fuel had begun to leak from the fuel pump without warning. The contact took the vehicle to an independent mechanic who diagnosed the failure and informed him that while the motor was running, the fuel would leak from the rear driver's side wheel; the leak would stop once the engine was shut off. The mechanic later discovered NHTSA Campaign Number: 11E009000(Fuel System, Gasoline) which he linked to the failure. The dealer was notified and an appointment was made for a diagnostic. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was 24,089.
The contact owns a 2004 Cadillac XLR. The contact stated there were strong fumes coming from the vehicle. The contact parked his vehicle in the garage and then leave it partially cracked due to the fumes. The contact changed the gas cap; however, the fumes continues. There were no warning lights illuminated. The contact called the local dealer regarding the failure; however, it was not diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 70,000.
The contact owns a 2004 Cadillac XLR. The contact stated while driving 65 MPH, there was an abnormally loud whistling sound coming inside the vehicle. The contact looked up and noticed that the sunroof glass had detached from the vehicle. The contact pulled over to the side of the road and retrieved the sunroof glass. The vehicle was then towed to an auto body shop to be inspected. The contact was informed that there was a defect in the glue used to secure the sunroof to the sunroof assembly. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.
My roof panel is separating from the roof frame of my 04 Cadillac XLR. If it come off it will cause property damage to another vehicle or death! It a GM defect that should be recall !!!! Thanks!
Was driving on interstate and top panel on convertible top flew off.
I PURCHASED A 2004 XLR IN 2019 FROM AN AGENT IN FL. I IMMEDIATELY OR WITH-IN 200 MILES I BEGAN TO RECEIVE MESSAGES ON MY DASH! FIRST IT WAS TRACTION CONTROL THAT APPLIED THE BRAKES AND CAUSED THE CAR TO VET VIOLENTLY TO THE LEFT AS SOON AS I HIT 65 MILES AN HOUR. THEN THE CHECK GAS CAP FOLLOWED BY CHECK ENGINE LIGHTS CAME ON. MY CADILLAC DEALER WAS AT A LOSS TO SOLVE THE PROBLEM WITH TRACTION CONTROL UNTIL THEY CONTACTED THE CORVETTE ENGINEERS IN BOWLING GREEN, WHICH TOOK A WEEK! THEY REPLACED THE GAS CAP AND THAT PROBLEM WENT AWAY ONLY TEMPORALLY! ON FURTHER INSPECTION THE TECH'S AT MY LOCAL CADDY DEALER DETERMINED BY A SMOKE TEST THAT THE CROSSOVER HOSE BETWEEN THE TANKS WAS LEAKING! THEY GAVE ME AN ESTIMATE OF CLOSE TO A $8000.00 REPAIR! THE CAR HAS LESS THAN 54,000 MI. I HAVE RESEARCHED THIS PROBLEM AND I AM SEEING THIS PROBLEM OCCURRING IN THIS MODEL YEAR PERHAPS BECAUSE OF ENGINEERING CHANGES MADE TO CONFORM TO GOVERNMENT EMISSIONS STANDARD CONTROLS! I AM RESEARCHING ALTERNATIVES TO HAVING THE REPAIR DONE BY MY LOCAL DEALERSHIP AS THEY REALLY DON'T SEEM TO BE VERY CAPABLE. THE CAP HAS BEEN CHANGED TWICE AND THE SAME PROBLEMS REOCCUR!
TL* THE CONTACT OWNS A 2004 CADILLAC XLR. WHILE THE VEHICLE WAS BEING PULLED INTO THE GARAGE, THE CONTACT NOTICED THAT THE HEADLIGHTS MELTED AND MADE IT IMPOSSIBLE FOR THE CONTACT TO SEE CLEARLY. THE CONTACT CALLED SEVERAL DEALERS, INCLUDING WALLACE CADILLAC (772-286-3555, LOCATED AT 3555 SE FEDERAL HWY, STUART, FL 34997). THE CONTACT WAS INFORMED THAT THEY NO LONGER MADE THOSE TYPE OF HEADLIGHTS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED THE CONTACT WITH SEVERAL WEBSITES TO SEARCH FOR USED HEADLIGHTS. THE CONTACT FOUND A COMPANY IN CHICAGO THAT HAD THE HEADLIGHTS, BUT THE COST WAS TOO EXPENSIVE. THE CONTACT MADE AN OFFER THAT WAS NOT ACCEPTABLE TO THE SELLER. THE CONTACT CALLED SEVERAL OTHER COMPANIES, INCLUDING EBAY, BUT WAS UNSUCCESSFUL. THE CONTACT CALLED THE FEDERAL TRADE COMMISSION AND THE STATE ATTORNEY GENERAL AND BOTH REFERRED THE CONTACT TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 42,000.
TL* THE CONTACT OWNS A 2004 CADILLAC XLR. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE INTERIOR DRL HEADLIGHT ASSEMBLIES MELTED AND CAUSED THE HEADLIGHTS TO ILLUMINATE DIMLY. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. WALLACE CADILLAC(3555 SE FEDERAL HWY, STUART, FL) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE CONTACT WAS INFORMED THAT THE FRONT HEADLIGHT ASSEMBLIES NEEDED TO BE REPAIRED. THE FAILURE MILEAGE WAS 42,000.
WHEN DRIVING I NOTICED A SEVERE WHISTLING SOUND COMING FROM JUST ABOVE THE REAR VIEW MIRROR. UPON INSPECTING, I NOTICED THAT THE ROOF PANEL HAD A 8' SECTION THAT HAD SEPARATED. WHEN GOOGLED, I SAW SEVERAL PEOPLE HAD REPORTED THAT THEIR XLR'S HAD A ROOF PANEL SEPARATE WHILE DRIVING. I IMMEDIATELY TOOK IT TO A BODY SHOP AND THEY RE-GLUED THE PANEL BY INJECTING GLUE INTO THE SEPARATION. I HAVE NO IDEA IF THIS IS A RECOMMENDED SOLUTIONN BY GM.
WHILE DRIVING ON THE FLORIDA TURNPIKE SUDDENLY THERE WAS A RUSH OF AIR COMING FROM THE REARVIEW MIRROR AREA. I STOPPED AT THE NEXT SERVICE PLAZA AND OBSERVED THE FRONT OF THE ROOF PANEL SEPARATING FROM THE FRAME. GM USED A ADHESIVE ON THESE XLR ROOFS THAT IS FAILING NOW. CORVETTE ROOFS PANELS WERE RECALLED FOR THIS ISSUE AND FAILED ADHESIVE, BUT GM HAS NOT RECALLED THE XLR YET. THEY OPENED A INVESTIGATION AT THE END OF SEPTEMBER OF 2018.
CHECK GAS CAP, CHECK ENGINE LIGHT. DEALER SAYS I NEED A NEW RT FUEL TANK BUT NONE ARE AVAILABLE. WHAT DO I DO NOW?
Showing 15 of 34 complaints