1975 Volkswagen Rabbit Recalls

Component: SERVICE BRAKES, HYDRAULIC

CERTAIN HYDRAULIC BRAKE HOSES, P/N 171.611.107B, SOLD AS REPLACEMENT EQUIPMENT FOR 1975-1985 VOLKSWAGEN (VW) RABBIT; 1985-1992 VW GOLF; AND 1980-1992 VW JETTA PASSENGER VEHICLES. POSSIBLE BRAKE HOSE RUPTURE COULD OCCUR WHICH FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 106, "BRAKE HOSES."

Consequence: BRAKE HOSE RUPTURE COULD RESULT IN LOSS OF BRAKING ABILITY, POSSIBLY RESULTING IN A VEHICLE CRASH.

Full recall detail →

Component: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

BRAKE LINES INSTALLED UNDERNEATH THE CARPETING IN THE PASSENGER COMPARTMENT MAY RUST DUE TO THE ENTRY OF WATER AND ROAD SALT. IF RUSTING REMAINS UNCHECKED, IT PRODUCES LEAKS IN THE LINES AND BRAKE FLUID MAY BE LOST.

Full recall detail →

Component: STRUCTURE:BODY

ON SOME VEHICLES, THE FENDER OPENING THROUGH WHICH THE ANTENNA CABLE IS ROUTED MAY NOT BE PROPERLY SEALED. AS A RESULT, SPLASHED WATER FROM THE TIRES COULD ENTER PASSENGER COMPARTMENT THROUGH THE OPENING, ENTER THE FUSE RELAY BOARD AND CAUSE CORROSION OF THE TERMINALS. ALSO, BECAUSE WATER IS A GOOD CONDUCTOR OF ELECTRICITY, THE STARTER CAN BE ACTIVATED ACCIDENTALLY; THE HIGH FLOW OF ELECTRICITY MAY EXHAUST THE BATTERY WITHIN A SHORT PERIOD OF TIME. THUS RESTARTING THE ENGINE WOULD BECOME IMPOSSIBLE AND PARKING LIGHTS AND EMERGENCY FLASHERS WOULD BECOME INOPERATIVE.

Full recall detail →

Component: STEERING:GEAR BOX (OTHER THAN RACK AND PINION)

ON THE INVOLVED VEHICLES, THE ROLLER BEARING INSIDE THE STEERING GEAR BOX COULD BECOME DISLOCATED. THIS COULD CAUSE LOOSENESS AND EXCESSIVE PLAY IN THE STEERING SYSTEM.

Full recall detail →

Component: VEHICLE SPEED CONTROL:CABLES

THE ACCELERATOR CABLE ASSEMBLY IN THE INVOLVED VEHICLES COULD FAIL PREMATURELY UNDER CERTAIN OPERATING CONDITIONS. THIS WOULD EITHER PREVENT THE ACCELERATOR PEDAL FROM RETURNING TO THE IDLE POSITION OR CAUSE A LOSS OF ADEQUATE ENGINE POWER.

Full recall detail →

Component: ELECTRICAL SYSTEM:STARTER ASSEMBLY:RELAY

DUE TO AN IMPROPERLY SEALED ANTENNA MOUNTING HOLE, WATER COULD SEAP INTO THE FUSE RELAY BOARD. THE WATER ENTERING THE FUSE RELAY BOARD ACTS AS A CONDUCTOR OF CURRENT, THEREBY CHARGING THE STARTER.

Full recall detail →