2005 Kia Sportage Problems & Complaints

My ESP button stays on and including the air bag light and I've tried everything trying to turn it off as well as my engine light and my hard parking brake which keeps turning on and won't turn off while driving and it feels harder to press the gas and I lost complete control on the freeway some how but I believe its due to my ESP button, idk much about cars so this is the best way I can describe it, not many cars around on the freeway but I would've died if there was.. the fuel system is always having issues as well amd ive changed it many times but I'm more worried about the fact that I lost control and the fact that when i use my parking break that the car won't hold completely so please please launch an investigation so I can get my car fixed, thank you.

My 2005 Kia Sportage dropped on the rear drivers side. The rear drivers side rear constant velocity axle fell out when the rear sub-frame separated from the suspension and split apart. This caused the tire and wheel to angle to 45 degrees out from bottom to top. The rust and corrosion caused a complete failure of the sub-frame's ability to hold the rear wheels on. This was at low speed. This is a well maintained vehicle with no other problems, the engine had been replaced 5-6 years ago. The Kia Sportage of this year range is a commonly used car still utilized today. If this had happened at highway speed it would have been a disaster.

Throttle body spring broke caused car to keep accelerating. Car would not stop.

MY KIA SPORTAGE.... STALLED IN MID TRAFFIC LIKE IT LOSSES POWER RIGHT AFTER I. PUT GASOLINE IN THE CAR, ALMOST MAKING ME LOOSE CONTROL AND GET IN A WRECK. IT IS NOT GETTING FUEL .AFTER I CONTINUED TO TRY AND REFUEL IT. I NOTICED A RECALL ONLINE ABOUT MY VEHICLE NUT DEALER IS ONLY SAYINH THE RECALL IS ON A FUEL STRAP TI HOLD THE FUEL TANK UP I NEED THIS SAFELY REPAIRED

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. AFTER THE FUEL TANK WAS FILLED, THE CONTACT HAD DIFFICULTY RESTARTING THE VEHICLE. ON ONE OCCASION, THE VEHICLE SHUT OFF WITHOUT WARNING. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 05V212000(FUEL SYSTEM, GASOLINE), BUT THE VIN WAS NOT INCLUDED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 185,991.

ALL BRAKE LIGHTS WILL NOT TURN OFF, AFTER SHUTTING OFF CAR.

WIRING HARNESS PLUGS JOINING AT RESISTOR & BLOWER MOTOR ARE MELTED.

ROTTED REAR CROSS MEMBER.

TOOK CAR TO HAVE SOMETHING UNRELATED TO THIS CHECKED. WAS TOLD THAT THE FRAME IS RUSTED AND ROTTED REALLY BAD AND IS UNSFE TO DRIVE. THE VEHICLE WAS STATIONARY AND REMAINS STATIONARY FOR FEAR OF IT COMPLETELY BREAKING OFF AND CAUSING A CATASTROPHE TO MYSELF, MY LITTLE GIRLS OR OTHER DRIVERS ON THE ROAD.

WHILE DRIVING 80MPH ON FREEWAY, CAR STOPPED WITH NO WARNING, WOULDN'T RESTART FOR OVER 30 MINUTES

THE CLUTCH WENT OUT ON OUR KIA SPORTAGE AND WHEN WE HAD IT AT THE AUTO MECHANIC, HE TOLD US, THE FRAME WAS SO RUSTY IT WAS A MAJOR SAFETY ISSUE. WE WERE ALARMED TO HEAR THIS CONSIDERING WE USED THIS CAR TO TRANSPORT OUR GRANDCHILDREN SOMETIMES AND THOUGHT ABOUT WOULD COULD HAVE HAPPENED. CURRENTLY WE DO NOT EVEN WANT THE CLUTCH REPAIRED AS WE HAVE BEEN TOLD NOT TO CONSIDER EVEN DRIVING IT UNLESS THE FRAME SUB RAILS/FLOOR ARE REPLACED. I HAVE SINCE READ OTHER REVIEWS AND HAVE FOUND SIMILAR ALARMING CONCERNS. KIA SHOULD ADDRESS THIS HUGE SAFETY ISSUE. WE CANNOT DRIVE THE CAR, CANNOT FIX THE CLUTCH, SO IT IS JUST SITTING AT THE MECHANICS. WHAT DO WE DO, JUST JUNK THE CAR? WHAT A COST INFRINGEMENT. WE WILL NEVER PURCHASE ANOTHER KIA, NOR WILL PEOPLE THAT WE INFORM OF THIS ISSUE. I SHUDDER WHEN I THINK ABOUT WHAT COULD HAVE HAPPENED, ESPECIALLY DRIVING ON THE HIGHWAY. PLEASE ADVISE...

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. WHILE DRIVING APPROXIMATELY 40 MPH, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER (KIA OF MCCOMB IN MCCOMB, MS, 601-250-1005) WHERE IT WAS DIAGNOSED THAT THE SEAT BELT WAS FAULTY. THE DEALER REFERRED THE CONTACT TO NHTSA. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT ALSO RECEIVED THE SETTLEMENT NOTICE FROM TK HOLDINGS, INC. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS APPROXIMATELY 128,000.

THIS COMPLAINT IS ABOUT THE 2005 KIA . FIRST THE AIRBAG LIGHT HAS COME ON AND HAS BEEN ON FOR THE LAST THREE TO FIVE YEARS, THE AUTO MECHANIC THAT I USE AT FIRST SAID THAT IT WAS JUST THE LIGHT INDICATOR AND WAS NOT PROBLEMATIC EXCEPT THAT THE LIGHT WAS ON BUT NOW IS SAYING THAT SINCE THE LIGHT IS ON THE AIRBAG MAY NOT DEPLOY , AND THAT OF COURSE IS A BIG PROBLEM. SECONDLY, WHEN FILLING THE GAS TANK AND WHEN COMPLETED THE CAR STALLS SEVERAL TIMES BEFORE STARTING, PROBLEM DOES NOT OCCUR AGAIN UNTIL THE NEXT REFILL. THIRD REOCCURRING PROBLEM IS THAT ONE OF THE REAR BRAKE LIGHTS SHORT OUT ON A REOCCURRING BASIS.

REAR SUBFRAME ROTTED OUT. (,UNSAFE TO DRIVE). KIA SPORTAGE 2005 LOOK LIKE 30 YEARS OLD.

FRAME CORROSION/PERFORATION IN REAR END. MECHANIC SAYS IT IS UNSAFE TO DRIVE AND CAN'T PASS SAFETY INSPECTION AS REAR AXLE COULD BREAK OFF AT ANY TIME. THIS SEEMS TO BE A WELL DOCUMENTED ISSUE FOR THIS VEHICLE. VEHICLE IS A TOTAL FINANCIAL LOSS FOR ME NOW.

THE REAR CROSS MEMBER THAT HOLDS REAR TIE RODS AND REAR CONNECTING ARMS TO WHEELS IS RUSTED SO BAD IT WILL FAIL. MY EMPLOYER HAS SAME YEAR SAME MODEL BUT IN HYUNDAI HERS IS THE SAME AND DRIVERS SIDE REAR JUST SNAPPED HIKE DRIVING IT'S THE EXACT SAME PART AND RUSTED SO BAD WHEEL COLLAPSED. THIS IS WHY I CHECKED MINE. BOTTOM LINE MAIN SUSPENSION COMPONENT ON KIA AND HYUNDAI SHORTAGE OR DANTE FE FAIL AT 10 YEARS. THERE ARE AS A RECALL TO UNDERCOAT OR REPLACE PARTS UNDER THE CAR DO TO EARLY RUST FAILURE. THIS WAS 6 YEARS AGO. THIS CROSS MEMBER IS BOLTED TO HE FRAME AND I CAN GUARANTEE MOST 2005 HAVE THE SAME FAILURE OCCURRING. IT S ALSO HARD TO LOCATE THE PART AND THEY CHARGE FROM $350- $1000 FOR IT. THE HYUNDAI EXACT SAME PART # FROM KIA IS TWICE AS MUCH AS THE KIA PART. *TR

TL* THE CONTACT OWNS 2005 KIA SPORTAGE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 05V212000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED THE FAILURE. PARTS DISTRIBUTION DISCONNECT.

MY AIRBAG LIGHT WENT ON JULY 16 2016. I TOOK THE CAR TO SUSSMAN KIA IN JENKINTOWN PA.TO CHECK LIGHT. I WAS TOLD IT IS A FAULTY SEAT BELT .THE AIR BAG MAY NOT DEPLOY PROPERLY. I WAS TOLD TO REPLACE THE SEAT BELY ASSEMBLY $715.25. THE WORK ORDER INVOICE #52875--20 JULY 2016.SHOULD THIS NOT BE A RECALL ITEM FOR SAFETY BY KIA MOTORS?

AIR BAG LIGHT ON CONTINUALLY. NO ACCIDENT OR DEPLOYMENT.

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. THE CONTACT STATED THAT THE ENTIRE SUBFRAME UNDER THE VEHICLE WAS CORRODED. IN ADDITION, THERE WAS A HOLE IN THE FUEL TANK LINE AND THE CATALYTIC CONVERTER BRAKE LINE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE VEHICLE WAS BADLY CORRODED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 117,000.

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. THE CONTACT STATED THAT THE AIR BAG LIGHTS ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SEAT BELT BUCKLE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000.

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. WHILE REFUELING THE VEHICLE, THE FUEL PUMP CONTINUED TO CLICK OFF AS IF THE VEHICLE WERE FULL. THE FAILURE RECURRED ON SEVERAL OCCASIONS. ON ONE OCCASION, WHILE REFUELING, FUEL LEAKED FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THERE WAS NOT A LEAK IN THE FUEL TANK, HOWEVER, THE MECHANIC STATED THAT THE FUEL SENSOR/OVERFLOW VALVE WAS FAULTY AND NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT INQUIRED ABOUT NHTSA CAMPAIGN NUMBER: 05V212000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE VIN TOOL CONFIRMED THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. WHILE GETTING THE VEHICLE INSPECTED, THE INSPECTOR NOTIFIED THE CONTACT THAT THE CROSS MEMBER WAS BEGINNING TO RUST. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 119,000.

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. WHILE APPROACHING A STOP, THE ENGINE STALLED WITHOUT WARNING AND THE FUEL TANK WAS DIFFICULT TO REFUEL. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON ANOTHER OCCASION AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THERE WAS FUEL ON THE CHARCOAL CANISTER AND THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 05V212000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 114,075.

AIR BAG LIGHT CAME ON AND HAS REMAINED ON EVERY SINCE. NO ACCIDENTS INVOLVED. BASED ON ANOTHER COMPLAINT I SEEN, MUST BE A FACTORY FAULT. *TR

AIR BAG LIGHT STAYS ON! TOOK THE CAR TO MY MECHANIC TO "FIX IT" FOR $72, AND ONLY TWO WEEKS LATER, THE LIGHT WENT ON AGAIN. I WAS TOLD TO PULL ON AND JIGGLE THE PASSENGERS SEAT BELT TO MAKE IT GO OFF, HOWEVER, THAT DOESN'T WORK. DO I WANT TO SPEND ANOTHER $72 TO "FIX IT"? THE COST TO REPLACE THE SENSOR WOULD BE APPROXIMATELY $435. WHEN THE AIR BAG LIGHT IS ILLUMINATED, THE BIG RISK IS THAT THE AIR BAGS WILL NOT RESPOND IN AN ACCIDENT. *TT

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. THE CONTACT STATED THAT WHEN ACCESSING THE REAR LIFTGATE, ONE OF THE TWO HINGES FRACTURED, CAUSING IT TO RELEASE ABRUPTLY ONTO HIS LEFT ARM. THE CONTACT SUFFERED FROM LACERATIONS AND BRUISING TO THE LEFT ARM. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE BOTH LIFTGATE HINGES WERE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 78,600.

PURCHASED 2005 (NEW) RIGHT FROM THE SHOWROOM. EIGHT YEARS LATER FIND OUT THAT THE REAR SUBFRAME IS COMPLETELY ROTTED OUT. AND THAT'S PUTTING IT MILDLY. BROUGHT IT TO KIA DEALERSHIP TO HAVE THEM LOOK AT IT. SAID THEY NEVER SEEN ANYTHING LIKE IT BEFORE. TOLD ME IT WAS UNSAFE TO DRIVE, THAT IF THE FRAME BROKE IN HALF THE BACK TIRES WOULD FALL OFF. ONLY THING HOLDING IT ON IS THE TRAILING ARMS. CLAIM WAS FILED BUT KIA WONT DO ANYTHING BECAUSE OF THE MILES ON THE VEHICLE AND SAID THAT IT WAS FROM THE SALT ON THE ROAD IN THE WINTER. ONLY PROBLEM IS THAT'S THE ONLY PART UNDER THE VEHICLE THAT'S ROTTED AND EVERYTHING ELSE IS SOLID WITHOUT RUST. HMMMM!!!! I HOPE THAT AN INVESTIGATION IS OPENED BECAUSE THIS IS A SERIOUS MATTER AND KIA DOESN'T WANT TO TAKE RESPONSIBILITY FOR IT. IVE TAKEN PICTURES AND EVERYONE THAT I'VE SHOWN CANT BELIEVE THERE EYES, SAYING THERE'S NO WAY A VEHICLE OF THIS YEAR SHOULD THE SUBFRAME LOOK LIKE THAT. KIA SAID THEY'VE HAD A LOT OF COMPLAINTS ABOUT RUST BUT THIS CAN'T EVEN BE CONSIDERED RUST THE HOLES ARE SO...OOOO BIG I COULD PUT MY FIST THROUGH IT. PLEASE INVESTIGATE THIS MATTER BEFORE SOMEONE GETS SERIOUSLY HURT OR KILLED. THIS IS NO LAUGHING MATTER!!!!! *TR

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. THE CONTACT STATED THAT THE VEHICLE STARTED SMELLING OF GASOLINE FUEL. THE CONTACT ALSO STATED THAT IT WAS DIFFICULT TO REFUEL THE VEHICLE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V212000 (FUEL SYSTEM, GASOLINE), BUT WHEN SPEAKING WITH THE MANUFACTURER, WAS ADVISED THAT THE VEHICLE HAD BEEN CHECKED IN AUGUST 2005 UNDER THE RECALL CAMPAIGN AND WAS DETERMINED TO BE FINE. THE REPAIR WAS NEVER ACTUALLY PERFORMED AND THE VEHICLE HAD 1,040 MILES AT THE TIME. THE FAILURE MILEAGE WAS 21,000 AND THE CURRENT MILEAGE WAS 22,000. *TR UPDATED 06/18/13*LJUPDATED 06/21/2013*JS

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. THE CONTACT STATED THAT WHILE APPLYING THE BRAKES AT APPROXIMATELY 30 MPH, THERE WAS AN ABNORMAL GRINDING SOUND. THE CONTACT INSPECTED THE BRAKES AND DISCOVERED THAT THE BRAKES WERE TOO LARGE FOR THE FRONT DISK BRAKES. THE CONTACT REPLACED THE BRAKES WITH THE APPROPRIATELY SIZE BRAKES AND REPLACED THE ROTORS. THE REAR BRAKES WERE NOT REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 89,000. ...UPDATED 04-03-13 *BF THE CONSUMER STATED THE STANDARD BRAKE SHOCS WERETO LARGE TO FIT. THE CONSUMER PURCHASED NEW ROTORS TO FIT THEM. UPDATED 05/10/2013 *JS

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. WHILE DRIVING APPROXIMATELY 55 MPH THE VEHICLE SUDDENLY ACCELERATED ABNORMALLY. THE RPM READINGS INCREASED WHILE DRIVING AT A LOW SPEEDS. THE CONTACT WAS ABLE TO DRIVE UNDER 40 MPH WITHOUT THE VEHICLE ACCELERATING. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTICS AND THE TECHNICIAN ADVISED THAT THE THROTTLE SENSOR WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

I WAS DRIVING AND THE VEHICLE WOULD NOT BRAKE, AND STEERED RIGHT WHILE DRIVING 40-50 MPH, HITTING THE CURB AND ALMOST COLLIDED WITH ANOTHER VEHICLE. DEFINITE DEFECT IN THE STEERING/FUEL/BRAKES/ELECTRONICSTABILITYCONTROL, AND OTHER MINOR MECHANICAL MALFUNCTIONS. *TR

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. WHILE DRIVING APPROXIMATELY 50 MPH THE ENGINE RPMS INCREASED EXCESSIVELY AND THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT PLACED THE VEHICLE IN NEUTRAL AND WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED AT DIFFERENT SPEEDS INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V212000 (FUEL SYSTEM, GASOLINE:STORAGE) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 21,000.

MY 2005 KIA SPORTAGE WAS HIT ON THE DRIVERS SIDE DURING AN AUTO ACCIDENT. NEITHER AIRBAG ON THE DRIVERS SIDE DEPLOYED. *TR

THE GLASS ON THE DRIVER'S SIDE DOOR SHATTERED WHEN ROLLING WINDOW DOWN. IT CRACKED HORIZONTALLY ALL ALONG THE EDGE OF THE DOOR. *TR

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE BRAKES ON THE PASSENGER SIDE WOULD ENGAGE. IN ORDER TO DISENGAGE THE BRAKES, THE CONTACT HAD TO MOMENTARILY APPLY PRESSURE TO THE BRAKE PEDAL. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC, WHO STATED THAT THE ESP COMPUTER NEEDED TO BE UPDATED. A DIAGNOSTIC TEST ALSO INDICATED THAT THE VEHICLE WAS MAKING A SHARP RIGHT TURN WHILE IT WAS PARKED. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 05V318000 (PARKING BRAKE). THE FAILURE MILEAGE WAS 85,000.

WHEN DRIVING, USUALLY ON FREEWAY, AS YOU BEGIN TO BRAKE AND EXIT THE FREEWAY, THE POWER STEERING ASSIST STOPS FUNCTIONING, AND STEERING BECOMS EXTREMELY DIFFICULT. THE PROBLEM LASTS MAYBE 2 TO 4 SECONDS, AND THEN EVERYTHING SEEMS FINE. NUMEROUS TRIPS TO DEALERSHIPS (THREE DIFFERENT DEALERS, FIVE REPAIR TRIPS) AND THEY CLAIM THEY CAN'T DUPLICATE THE PROBLEM, THEREFORE "THERE IS NO PROBLEM". PROBLEM HAS BEEN RECURRING FOR OVER 1 1/2 YEAR PERIOD. DATE OF INCIDENT USED HERE IS ONLY MOST RECENT. *TT

KUMHO TIRE RADIAL 798 RADIAL TUBLESS M+S P205/75R15 975 MADE IN KOREA TREAD STEEL 2+ POLYESTER. THE TIRE WAS A NEW TIRE USED AS SPIRE NEVER BEEN ON ROAD. EXPLODED ON MY BACK DOOR OF VEHICLE WHILE PARKED IN MY DRIVEWAY, VERY DAMAGES IF I HAD BEEN ON ROAD I WOULD HAVE BEEN INJURED. I HAVE PICTURES OF TIRE. *TR

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. THE CONTACT STATED THAT THERE WAS AN ABNORMAL BURNING ODOR AND SHE OBSERVED SMOKE EMITTING FROM THE VEHICLE. THE CONTACT STATED THAT A WIRE INSIDE THE VEHICLE ON THE PASSENGER SIDE CAUGHT FIRE. THE CONTACT EXTINGUISHED THE FIRE WITH HER HANDS AND DISCONNECTED THE WIRE. THE VEHICLE WAS THEN TAKEN TO A LOCAL REPAIR SHOP WHERE SHE WAS ADVISED THAT THE BLOWER RESISTOR WAS THE CAUSE OF THE FAILURE AND HE SEPARATED THE WIRES TO REMEDY THE PROBLEM. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 54,000.

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT APPLIED THE BRAKES AND THE VEHICLE ACCELERATED ABNORMALLY. THE CONTACT STATED THAT THE FAILURE WOULD RECUR INTERMITTENTLY DURING INCLEMENT WEATHER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS CONTACTED AND STATED THE VEHICLE COULD BE TAKEN TO ANOTHER DEALER FOR DIAGNOSTICS BUT THE CONTACT WOULD HAVE TO COVER THE COST OF REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 32,000.

BROUGHT TO DEALER FOR LEAK. DEALER STATES TRANSMISSION PAN LEAKING DUE TO IMPROPER SEALING. SUPPOSED REPAIRED UNDER WARRANTY. BRING BACK DEALER SAY NOT LEAKING ANYMORE MUST BE RESIDUAL FLUID ON ENGINE. BROUGHT BACK AGAIN SAID NOW THE TRANSMISSION COOLER LEAKING. NOT COVERED PAID FOR NEW COOLER. BROUGHT HOME . NOTICED STILL HAVE A LEAK BROUGHT BACK TO DEALER. NOW THEY SAY IT IS A LEAK IN THE RADIATOR. WANT TO REPLACE THAT AT MY COST. *TR

WHEN ACCELERATING WITH LOAD ON ENGINE GOING UP HILL, JUST BEFORE THE TRANSMISSION SHIFTS INTO GEAR THE POWER STEERING WILL LOCK-UP. THE MOMENTARY LOSS OF STEERING WHILE ON MOUNTAINOUS ROADS MAKES FOR A VERY DANGEROUS JOURNEY HOME. *TR

TL*THE CONTACT OWNS A 2005 KIA SPORTAGE. THE CONTACT STATED THAT WHENEVER THE BRAKES WERE APPLIED, THE VEHICLE WOULD SUDDENLY SHUT OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT THE FAILURE COULD NOT BE DUPLICATED. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000. THE CURRENT MILEAGE WAS APPROXIMATELY 61,000.

TL* THE CONTACT OWNS A 2005 KIA SPORTAGE. WHILE DRIVING AT APPROXIMATELY 45 MPH, THE ELECTRONIC STABILITY PROGRAM INDICATOR WOULD ILLUMINATE INTERMITTENTLY WHICH SHE NOTICED SINCE JANUARY 2010. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE 92,047.

DURING ALL OF THE 5 INCIDENTS IN 2009 THE ENGINE MISFIRED VIOLENTLY. AT TIMES 35MPH WAS MAX SPEED. CRONIN KIA HAD MY VEHICLE OVER 30 DAYS IN 5 VISITS IN 2009. THEY HAVE REPLACED; TWO CAT. CONVERTERS, THE IGNITION COIL PACK AND SPARK PLUGS, A LEAKING FUEL INJECTOR AND ASSOCIATED WIRING. PLEASE NOTE THE ERROR CODES FOR VISITS 1 AND 5 (3/17/09 AND 7/14/09); P0300-P0303-P0305-P0273. VISIT NUMBER1 ALSO HAD CODES; P0420-P0430 AND P0170. THE DUPLICATE CODES INDICATE THE PROBLEM AFFECTS "BANK 1 ONLY. CODE P0170 SPELLS OUT THE PROBLEM; "FUEL TRIM MALFUNCTION-BANK 1".THE DESTROYED CATALYTIC CONVERTERS WERE THE RESULT OF THE FUEL TRIM PROBLEM. THE SAME FOR THE LEAKING FUEL INJECTOR. I BELIEVE IT IS ONLY A MATTER OF TIME BEFORE THE OTHER BANK 1 INJECTORS FAIL. THE FUEL TRIM MUST BE A FUNCTION OF THE VEHICLE'S COMPUTER. I BELIEVE THE "BANK 1 FUEL TRIM MALFUNCTION" AND/OR THE ELECTRONIC STABILIZATION PROGRAM (ESP) AND/OR THE VEHICLE'S COMPUTER ARE THE SOURCE OF THIS DANGEROUS PROBLEM. THERE IS A RECALL ON THE ESP; SC-044 - MARCH, 2005. "THE ESP SYSTEM MAY CAUSE THE ENGINE TO REDUCE POWER AND MAY CAUSE A BRAKING ACTION AT ONE OF THE WHEELS". "BRAKE APPLICATION CAUSED BY INADVERTENT ESP ACTIVATION MAY RESULT IN LOSS OF CONTROL AND A CRASH".THE FRONT BRAKE PADS ON MY VEHICLE WERE WORN OUT AT 41,000 MILES. I ASKED KIA CUSTOMER SERVICE IN AN INITIAL LETTER IF THIS WAS PREMATURE. OF COURSE, I RECEIVED NO ANSWER. AFTER THE NUMBER 5 INCIDENT(JULY, 2009) THE ENGINE WOULD STALL EVEN AFTER A LEAKING FUEL INJECTOR AND ASSOCIATED WIRING WERE REPLACED. IT STALLED LESS THAN A MILE FROM CRONIN AND THREE TIMES THE NEXT DAY. DURING THE NUMBER 5 INCIDENT THE ESP SHUT ITSELF OFF; "ESP OFF" APPEARED IN THE INSTRUMENT PANEL. I PASSED THIS INFORMATION TO JEFF WYLER KIA SERVICE DEPARTMENT. THIS WAS IGNORED. THE FINAL (NUMBER 6) ATTEMPT TO REPAIR THE PROBLEM CONSISTED OF A JOY RIDE AFTER WHICH THEY DECLARED; "ALL OPERATIONS ARE NORMAL" THEY CONSIDER THIS PROBLEM AMUSING. THEY REFUSED TO CONTACT KIA! *TR

2005 KIA SPORTAGE T-BONE CRASH AND THE SIDE SEAT AND CURTAIN AIRBAGS FAILED TO DEPLOY CAUSING SEVERE HEAD CONCUSSION AND NECK BACK INJURIES. PRODUCT LIABILITY/DEFECTIVE KIA SRS SYSTEM. *TR

2005 KIA EX CARE ACCIDENT MOTHER HIT BY DRUNK DRIVER ON DRIVER SIDE DOOR CAUSING HEAD INJURY CONCUSSION. SIDE AIRBAG AND CURTAIN DID NOT DEPLOY. THIS CAN CAUSE LONG TERM EFFECTS AND SHE IS CURRENTLY UNABLE TO WORK. *TR

TL*THE CONTACT OWNS A 2005 KIA SPORTAGE. THE CONTACT STATED THAT THE VEHICLE WOULD NOT HOLD FUEL. ON A SEPARATE OCCASION, WHILE ADDING FUEL TO THE VEHICLE, GASOLINE SPEWED BACK OUT FROM THE GAS TANK. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V212000 (FUEL SYSTEM, GASOLINE:STORAGE). THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 72,000. 4/01/09 *NJ UPDATED 04/06/09. *JB

ON 10/16/08 AT APPROX. 7:20A I WAS T-BONED IN THE DRIVERS SIDE DOOR AND BACK PASSENGER DOOR BY A FORD F250 RED PICKUP TRUCK AS I WAS TRAVELING UP THE STREET DOING ABOUT 35-40 MPH. HE WAS PULLING OUT OF HIS SUBDIVISION ONTO THE STREET AND HIS PASSENGER SIDE WINDOW WAS FOGGED UP SO HE DID NOT SEE ME COMING. *TR

I HAVE A 2005 KIA SPORTAGE. THE HEADLINER AND SUN VISORS AND THE BACK ARE A CLOTH MATERIAL - THE REST IS LEATHER. THE PROBLEM IS LITTLE TINY BLACK FIBERS ARE COMING THROUGH THE TAN COLORED HEADLINER ETC. THERE FIBERS ARE COMING THROUGH IN ABUNDANCE, LAYING ON THE DASH BOARD AND CONSOLE. IT CAN BE CLEANED ONE DAY AND THE FIBERS ARE THERE AGAIN THE NEXT. THESE FIBERS ARE VERY VERY SMALL. THEY ARE ALSO GETTING ON MY SKIN - THEY ITCH AND STICK TO MY SKIN. THE PRIMARY CONCERN IS THAT THESE FIBERS ARE SO SMALL, AND I KNOW THAT I AM BREATHING THEM IN. HAVE YOU HAD OTHER COMPLAINTS ABOUT THIS. I HAVE CONSULTED THE DEALER AND THEY ARE WAITING FOR THE MAIN WARRANTY DEPT TO GET BACK TO THEM - IN THE MEAN TIME I AM CONCERNED ABOUT MY HEALTH - PLEASE ADVISE. *TR

IT STARTED IN JANUARY 2007 WHILE TRYING TO MAKE A LEFT HAND TURN THE CAR JUST DIED WITHOUT ANY NOTICE. ALTHOUGH YOU CAN PUT IT IN NEUTRAL AND RE-START IT, IT CAN TURN RIGHT AROUND AS YOU MAKE YOUR TURN AND DIE AGAIN. AS COMING TO A STOP LIGHT OR STOP SIGN IT WILL DIE WITHOUT EVEN COMING TO A COMPLETE STOP. JUST SLOWING DOWN IT WILL DIE. THE RPM'S WILL REV UP WHEN YOU LET UP OFF THE GAS OR SOMETIMES WHEN YOU PRESS THE BRAKES THE RPM'S WILL REV UP. WHEN SITTING AT AN IDLE THE RPM'S WILL DROP WAY DOWN TO 500 AND BOUNCE UP AND DOWN. HAVE HAD IT IN THE SHOP 4 TIMES AND THEY SAY " IT DIDN'T DIE ON US" OR " WE COULDN'T FIND ANYTHING WRONG". IT IS AT THE SHOP RIGHT NOW JUNE 2008. THIS IS AN OFTEN OCCURRENCE. *TR

FRONT SUSPENSION PROBLEM; A LOT OF NOISE, KIA DEALER HAS REPLACED A LOT OF PART OF THE FRONT SUSPENSION, IS PRACTICALLY NEW. BUT THEY HAVE NOT FOUND THE PROBLEM YET, SINCE I BOUGHT IT ON MAY, 2005. THIS CAUSING A LOT OF BIG VIBRATIONS WHEN DRIVING ON HIGHWAY MAKE IT UNSAFE BECAUSE INSTABILITY. *JB

WHILE FINDING A PARKING SPOT MY VEHICLE LOST POWER AND SUDDENLY QUIT. AFTER RESTARTING IT, I FOUND A PARKING SPOT AND JUST BEFORE THE VEHICLE WAS PUT IN PARK, IT STALLED AGAIN. APON LEAVING TO GO HOME, A 10 MILE TRIP,EACH TIME I CAME TO A STOP THE VEHICLE STALLED ON ME AN ADDITIONAL 5 TIMES. THIS IS NOT THE FIRST INTANCE OF THIS PROBLEM. WE HAVE HAD THIS VEHICLE IN THE SHOP PREVIOUSLY FOUR OTHER TIMES. EACH TIME SAYING THAT IT WAS DUE TO A LOOSE AIR INTAKE VALVE. I ACTUALLY ALMOST HAVE PANIC ATTACKS NOW WHEN COMING TO A STOP ON A BUSY INTERSECTION FOR FEAR MY VEHICLE IS GOING TO STALL AND I AM GOING TO BE INVOLVED IN AN ACCIDENT. I WILL BE TAKING THE VEHICLE INTO KIA, YET AGAIN, TOMORROW TO HAVE THIS PROBLEM REPAIRED.

VEHICLE STARTED TO SHIFT IMPROPERLY AND THE ENGINE "REVVED" ITSELF WHILE IN PARK WITH THE AIR CONDITIONING ON. A WEEK OR SO LATER, CAR LOST POWER WHILE TRYING TO PARK WITHOUT WARNING. TAKEN TO THE DEALERSHIP WHO FOUND NOTHING WRONG USING THE COMPUTER. CAR CONTINUED TO DO THIS FOR OVER A MONTH, WITH NO PATTERN, TAKEN BACK TO THE DEALERSHIP WHO ONCE AGAIN GAVE THE VEHICLE BACK AND SAID THERE IS NOTHING WRONG. I FIND THIS TO BE A SERIOUS PROBLEM SINCE IT TURNS OFF WHILE STOPPING AND OR TURNING. *JB

TL*THE CONTACT OWNS A 2005 KIA SPORTAGE. THE VEHICLE WAS REPAIRED UNDER RECALL # 05V120000 (SUSPENSION:AUTOMATIC STABILITY CONTROL (ASC)). THE CONTACT STATED THAT THE RIGHT REAR BRAKES ARE NOW SQUEALING AND THAT THE BRAKES SHOULD HAVE BEEN INSPECTED WHEN THE REPAIR WAS PERFORMED. THE DEALER STATED THAT THE ROTOR HAS GLAZED OVER. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 33,000.

DT*: THE CONTACT STATED THE HORN ON THE VEHICLE WORKED INTERMITTENTLY. THE PROBLEM HAD BEEN ONGOING SINCE THE VEHICLE WAS PURCHASED IN MAY OF 2005. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO WAS UNABLE TO DETERMINE THE PROBLEM. THE MANUFACTURER WAS ALSO NOTIFIED.

DT*: THE CONTACT STATED WHILE TRAVELING 30 MPH, A PASSERBY ALERTED THE CONTACT THE REAR OF THE VEHICLE WAS ON FIRE. THE VEHICLE WAS PULLED OVER, THE DRIVER SIDE TAILLIGHT WAS REMOVED, AND THE CONTACT EXTINGUISHED THE FIRE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHO DETERMINED THE POWER CONVERTER SHORTED, CAUSING THE FIRE. THIS WAS A HIDDEN HITCH POWER CONVERTER, PART NUMBER 31828.

DT*: THE CONTACT STATED THE VEHICLE INTERMITTENTLY STALLED AT VARIOUS SPEEDS WITHOUT WARNING. AFTER EACH INCIDENT, THE VEHICLE RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY WERE UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. THE COMPUTER WAS REPROGRAMMED, BUT THE PROBLEM PERSISTED. *AK

I WAS INVOLVED IN 2 LOW IMPACT CRASHES WITH THIS KIA SPORTAGE 2005 MODEL. ONE WAS A REAR END COLLISION AT 20 MPH AND THE OTHER I WAS HIT FROM THE SIDE IN A PARKING LOT. BOTH TIMES THE OTHER DRIVER DROVE AWAY WITHOUT DAMAGE. I SUFFERED 3500 DOLLARS WORTH OF DAMAGE FROM THE FIRST INCIDENT AND 7500 FROM THE SECOND. THE VEHICLE WAS NOT DRIVABLE BOTH TIMES. AIRBAGS NEVER DEPLOYED. I AM VERY CONCERNED AS ARE OTHER INDIVIDUALS WHO WITNESSED THE INCIDENTS THAT IF THE SPEED HAD BEEN ANY GREATER THE PERSONAL INJURY WOULD HAVE BEEN GREAT. I HAVE NEVER HAD A VEHICLE SUSTAIN SO MUCH DAMAGE FROM WHAT SHOULD HAVE BEEN FENDER BENDERS. *JB

DT*: THE CONTACT STATED THE CHECK ENGINE LIGHT ILLUMINATED. THE DEALERSHIP INSPECTED THE VEHICLE A TOTAL OF EIGHT TIMES. EACH TIME THE ENGINE LIGHT HAS BEEN RESET HOWEVER, THE LIGHT ILLUMINATED AGAIN. THE DEALERSHIP HAS BEEN UNABLE TO DETERMINE WHY THE ENGINE LIGHT CONTINUES TO ILLUMINATE.

I TOOK MY 2005 KIA SPORTAGE EX INTO THE DEALERSHIP IN JANUARY TO BE CHECKED DUE TO A SQUEAKING SOUND COMING FROM THE REAR END. THE PARTS CLERK ORDERED A REAR PASSENGER SPINDLE. ITS BEEN FOUR MONTHS AND THE PART IS SUPPOSEDLY ON BACK ORDER, THEY HAVE DENIED IT BEING A RECALL AND ADVISED ME THAT IT WAS NOT A SAFETY ISSUE. I HAVE A SUSPICION THAT IT IS A RECALL DUE TO IT TAKING SO LONG TO GET THE PART AND THE FACT THAT THEY ARE UNABLE TO GIVE ME A DATE AS TO WHEN THE PART WILL BE AVAILABLE. I'M CONCERNED FOR MY SAFETY AS WELL AS OTHER MOTORISTS. *NM

KIA MOTORS USA, 2005 KIA SPORTAGE LX V6 4WD- [XXX] PURCHASED NEW IN MAY 05. VEHICLE MILES 61 AT PURCHASE. ON 10/27/05 TURNED ON WINDSHIELD WIPERS. THE PASSENGER SIDE WIPER ARM MADE AN UNUSUAL NOISE. WIPERARM WAS FLAPPING AND LOOKS LIKE IT ROTATED 360 DEGREES. PASSENGER SIDE WIPER ARM ALSO MADE A 7 INCH SEMI CIRCLE SCRATCH IN THE CORNER OF THE HOOD. PASSENGER SIDE WIPERARM METAL IS TWISTED IN A SPIRAL SHAPE. VEHICLE CHECKED BY BILL DORATY KIA IN MEDINA,OHIO ON 10/28/05 INVOICE#[XXX]. DEALER STATES LOOKS LIKE WIPER ARM WAS TWISTED BY OTHER MEANS. THEY WILL NOT WARRANTY THE DAMAGE. KIA MOTORS CONSUMER AFFAIRS ANALYST CENTRAL REGION,WITHOUT INSPECTING THE VEHICLE SIDES WITH THE DEALERS OPINION. THEY ARE WRONG! THE DAMAGE SHOWS IT WAS A MECHANICAL PROBLEM AND NEEDS TO BE PROPERLY INVESTIGATED BEFORE THIS OCCURS TO SOMEONE OPERATING THE VEHICLE ON THE HIGHWAY DURING A STORM. THE VEHICLE HAS NOT BEEN REPAIRED. THANK YOU. [XXX]. *NM UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

GAS TANK WAS OVERFILLED WHILE TRAVELING OUT-OF-TOWN. THIS RESULTED IN HAVING TO TOW THE VEHICLE TO A DEALER AND HAVING THE GAS TANK DROPPED, AND REPLACING THE EVAPORATION CANISTER ASSEMBLY. THE COST TO ME WAS $284 BECAUSE IT WAS A 'SELF-INDUCED' PROBLEM. THE MANUALS SAY NOTHING ABOUT OVERFILLING CAUSING PART DAMAGE THAT THE CUSTOMER IS LIABLE FOR. REPAIRS TOOK FIVE DAYS DUE TO THE SERVICE DEALER LACKING THE PROPER DIAGNOSTIC EQUIPMENT AND ADAPTERS FOR THE SPORTAGE. CURRENTLY WORKING WITH KIA OF AMERICA TO TRY TO GET REIMBURSED FOR THE EXPENSE. *JB

DT: CONTACT STATED EXTERIOR REAR VIEW MIRRORS AND THE INSIDE REAR VIEW MIRROR WERE DARK THAT THE CONSUMER HAS DIFFICULTY SEEING WHILE DRIVING AT NIGHT OR ON CLOUDY DAYS. THE SERVICE DEALER STATED THEY DID NOT BUILD THE VEHICLE AND PROVIDED THE CONSUMER WITH THE KIA MANUFACTURER'S NUMBER. THEY TOLD THE CONSUMER SINCE THE VEHICLE WAS PURCHASED FROM A FORD DEALERSHIP IT WAS A PREVIOUSLY OWNED VEHICLE, THE CONSUMER COULD NOT MAKE THE MANUFACTURER UNDERSTAND THAT THE VEHICLE WAS PURCHASED NEW FROM THE FORD DEALERSHIP. *AK

DT: THE CALLER HAD A RECALL BUT NO REPAIRS COULD BE DONE BECAUSE THE PARTS WERE ON BACK ORDER. IT HAS BEEN TWO WEEKS, AND HE CAN'T GET ANYTHING DONE. DEALER AND MANUFACTURER TOLD HIM HE HAS TO WAIT UNTIL THEY GET THE PARTS IN. CALLER HAS TAKEN THE VEHICLE TO DEALER TWICE. THE CALLED DID NOT KNOW RECALL NUMBER. *AK

RECEIVED RECALL NOTICE FOR FUEL LEAK ON 2005 KIA SPORTAGE. LETTER SAID REPAIR TAKES TWO HOURS. TOOK VEHICLE IN AND AFTER 5 HOURS, WAS TOLD THEY NEED TO ORDER PARTS AND KEEP VEHICLE. 2 DAYS LATER WAS GIVEN A RENTAL CAR AND TOLD IT WOULD BE A WEEK TO GET THE PARTS. 9 DAYS AFTER TAKING THE VEHICLE IN, WAS INFORMED THAT IT WOULD BE 4 WEEKS TO GET PARTS BUT THE VEHICLE WAS DRIVABLE AND TO COME GET IT. CALLED MANUFACTURER AND WAS TOLD THE SAME THING. UNACCEPTABLE THAT THE 2 HOUR REPAIR SHOUDL TAKE OVER 5 WEEKS!

CONTINOUS FAILURES IN THE ELECTRONIC STABILITY PROGRAM (EPS) THAT CAUSES PERIODIC BRAKING DURING NORMAL DRIVING CONDITIONS. FAILURE CAUSES CAR TO PULL IN THE DIRECTION OF BRAKING WHEEL, OFTEN CAUSING THE CAR TO ENTER OTHER LANES OF TRAFFIC. AT THIS POINT, ONLY THE ELECTRONIC SENSOR HAS BEEN REPLACED, WHICH HAS NOT CORRECTED PROBLEM.

WHEN GAS TANK IS FILLED, GAS LEAKS OUT OF PIPE LEADING TO GAS TANK. WHICH IN MY OPINION COULD CAUSE A FIRE AND/OR EXPLOSION. CAR IS CURRENTLY AT THE DEALER TO CORRECT THE PROBLEM. *JB