2023 Kia RIO Problems & Complaints

Paint peeling. Took a month to have the dealer /warranty repair the roof in July 2025. Then in Sept 2025 have 2 more areas doing the same thing. Reached back out to dealer end of Sept then mid Oct following up find out service person is gone, start over with new service person, follow up early Nov, again mid Nov and find out that service person is gone. Contact manager and he wants us to start over again with him. Need to send car out for quotes to give to warranty even though this has already been repaired once and we were told this is a known issue. Now trying to go through a Kia dealer that has a body shop on site to try and get warranty approval and repair done before vehicle hits 36K even though this should be covered regardless (and purchased extended warranty but also not covered)

I’ve been hearing this rattle noise mostly when I crank the vehicle. I took it to go get checked out and they heard it when I first brought it in for them to check. But when they got it to the back for mechanic to listen for it, of course it didn’t do it. They kept my car a whole day to try n find the issue/hear the noise and was unsuccessful. I’ve been told that it could possibly have something to do with the car timing or something with the engine. My car only has 34000 miles on it and it’s making this noise. They won’t approve me to trade it in or anything to help fix the problem or get me in something better.

The vehicle has difficulty following a center line, higher than normal steering wheel input is required. Feels like the vehicle is being driven in strong crosswinds at any speed above 55 MPH. The vehicle is very, very difficult to keep centered when crosswinds are present. The steering wheel input feels sticky and not smooth at any speed above 40 MPH. A 4-wheel alignment revealed a 0.3 degree of toe mis-adjustment on the RR wheel, no adjustment settings are present. Remaining wheels were within specs. No adjustment for the electronic steering assist. Additionally, the vehicle is equipped with the Highline TPMS, however, it is not displayed on the LCD. Dealer and Kia Corp. states it should display, however no fix is available.

The contact owns a 2023 Kia Rio. The contact stated that while driving 40 MPH, the vehicle lost motive power. There was no warning light illuminated. The contact pulled over to the side of the road and restarted the vehicle; however, the failure persisted. The vehicle restarted; however, the transmission failed to shift into gear. The vehicle was towed to the residence. The following day the contact was able to start the vehicle and the vehicle was taken to the dealer to be diagnosed. The dealer found no failure with the vehicle. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 100,900.

When I started my car, during the warm-up process, it dropped revs and turned off. After several tries, it turned on. While driving, when the vehicle was stopped, it began to jerk slightly. The safety risk is that the car, while I am driving, could turn off and cause an accident, in which people could be at risk, including me. I wouldn't want this to escalate because the dealer doesn't take action on the matter. The vehicle was taken to the dealer to evaluate the condition, they say that the technicians did not find anything, that the car did not emit any codes. And therefore they couldn't do anything. Note that I bought that car completely new, 0 miles, in March of last year. And in January the problem started. It is also worth noting that the car had to have a rack&pinion change in less than a year, due to a noise it made when the guide turned. All maintenance has been done with the official Auto Grupo Kia dealership on Kennedy, in Puerto Rico. I fear my safety and that of others behind the wheel, if the major fault in my car is not fixed.

Hi [XXX] I just collected my Kia Rio from service at LaFontaine. On driving in the freeway I noticed I had to make frequent adjustments to the steering when going straight and there was oversteering (minor tilt of the steering wheel result in exaggerated larger turn of the car). This does not happen when driving at lower speed outside of the freeway. I will monitor this as I am not sure if this was because I was switching between cars and/or that particular stretch of road is slippery. According to the technicians the alignment is back to spec so I will let you know if this issue persists as I drive the Rio more in the coming days. Hi Team The car veers to the left when driving with steering wheel straight. Tested in a clear non wet road. Please advise on next step. When driving on freeway there are over steering and understeering issues. Extremely dangerous. Yours sincerely [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Hi [XXX] My Kia Rio 2023 S vin number is [XXX] . Bought a couple months back new at Summit Place Kia Auburn Hills michigan. Once I drive off I realised the steering wheel alignment is off. The car does not drive straight when steering wheel is straight. I called my salesman and he asked me to bring it in for servicing at Summit Place. They did a wheel alignment there and found misalignment at factory condition. A few months later the same issue got worse and was noticeable again when driving. I called my salesman and he told me bringing it into service will incur a service charge as this issue is not under warranty. However, I believe this constant misalignment is from a manufacturing defect causing safety issue and you could access the servicing records that said the wheel alignment was already off at the first emergency servicing. I have also made sure all my tire pressures are topped up to the recommended pressures Kindly advise and rectify this road safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2023 Kia Rio. The contact stated that while driving at an undisclosed speed, he became aware that the vehicle failed to sound a seat belt warning chime to indicate that the passenger’s side seat belt was not buckled. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

I was driving normally and suddenly the transmission would not shift at all. The engine would just rev freely and the car did not accelerate at all. I was able to creep slowly to the dealership as I was near it. The dealership confirmed that the transmission had a problem a day after it was in the dealership.

I was driving around 10mph when I noticed that the transmission would not shift at all. The RPM would only increase but the car does not accelerate. Kia dealership confirmed that the transmission is dead.

While driving at 71 mph with cruise control and the doors locked, the drivers seat door unlocked and opened. The open door warning light came on on the dashboard. It is available for inspection. It has not been inspected yet at this time. My safety was put in danger as I had to close the door as wind was entering the vehicle. It has only happened once about two weeks ago.

I bought a new 2023 Kia Rio on Mar. 13. Within 30 hours of getting it home it was entered by thieves who wrecked the ignition system trying to steal it. The dealer did not inform me of the great danger of theft of Kia models like mine. They did not urge me to get an anti-theft device. I didn't know of this rampant Kia theft problem or would not have bought the car. Not only that, they say they cannot fix it (for perhaps 2 months). All the area Kia dealers are "overwhelmed" with Kias that have suffered theft or theft-related destruction. They can't get parts. They won't allow the car to be towed to them because they don't have space. I'm stuck with a brand new car that can't be driven and can't be fixed. I am a fixed income 80-year-old without much money. This is abuse of customers. Kia must make this good. You have posted an article about recalls of Kias and Hyundais for this problem, but I don't see a path for relief for me.