2005 Chevrolet Suburban Problems & Complaints

The vehicle was idle for about 4 months. I took it to a carwash to clean the dust off. Upon returning (abt a 2 mile trip) the brakes failed and steam was coming out from under the hood. I opened the hood and brake fluid was sprayed all over the driver's side of the engine and wheel well. A brake line had rusted through and burst. Fortunately, I made it home carefully because I had noticed the brakes were soft.

This vehicle has less than 84,000 miles on it, and the chassis or frame is rotted. The rear anti sway bar already rotted off it, and the front bar is hanging down on the passenger side. I have photos of this, but don't know how to download them. The body has a little rot here, and there, but that is repairable. I spent a lot of money in purchasing this vehicle, and I expected it to last a very long time. The interior is almost like new. I am thinking about putting a tort claim about this to GM. Please help me all you can. I forgot to write that I also spent extra money for it to be undercoated, and it is supposed to be a lifetime warranty. I called that company, and they said it was only for 10 years. When I buy a new vehicle, I expect it to last.

Air bag sensors went out making air bag inoperable.

Speedometer stops working intermittently. This is a safety hazard as the operator cannot tell the speed that the vehicle is operating. It seems to occur randomly.

This defect pertains to gear indicator on the instrument panel. During the daylight hours the light indicating the gear the car is in (park, neutral, drive, etc.) is impossible to read. At night you can just barely read the gear indicators. The dimness of the lights behind this gear indicator gauge is a safety hazard because you cannot tell what gear you are in during the day. It is an expensive repair because the instrument panel needs to be removed to fix the problem.

The contact owns a 2005 Chevrolet Suburban. The contact stated upon taking the vehicle to an independent mechanic for tire replacement, he was informed that the entire chassis was severely corroded. The dealer was notified of the failure and referred the contact to the manufacturer for assistance. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The vehicle was not diagnosed or repaired. The failure mileage was approximately 84,000.

Started with driver side heated seat randomly turning on and off. Going from high, medium, low. No way to turn it off just comes back on. Can hear clicking coming from under dash. Lift gate wiring that goes into body, ground wire burnt. (Replaced) but ground wire has power. (Wiring issue) so rear wiper doesn’t work. “Reading” Lamps only work when door is open. After replacing life gate connector, says lift gate open. Started the repair, which leads to more wiring issues! Needs a recall! Unsafe

The speedometer issue started 1 year ago, the speedometer shows needle stuck on 0 or all the way down to right side. Now issues with the gas gauge and oil gauge are happening also Mechanic has checked on this and stated that replacement needed.

Heated seats randomly turn on and off and goes thorugh the diffeent levels of heat and then off and then back on repeat for hours while driving and is very distracting as have to turn off every 10 sec and have almost crashed multiple times taking me eyes off the road but have to turn off as heat is too much in summer months, this is a known issue in almost ever suburban 01 to 05, how is this not a recall yet, there is massive amount of documentation of this issue online.

Gear status indicator does not display selected gear.

THE WIRING FOR THE LIGHTERS, POWER PORTS AND COMPUTER LINK MELTED. IT'S ALL PART OF THE UNDER-DASH WIRING HARNESS.

TRUCK DOOR IS NOT OPENING, FUEL GAS DEFECTIVE, REAR LIGHT SYSTEM HAS ELECTRICAL PROBLEM ALL THE TIMES, A/C SYSTEM ELECTRICAL PROBLEM.

OIL PUMP OIL RINGS TO LEAD TO OIL PICKUP TUBE FAILED CAUSING DROP IN OIL PRESSURE. THIS HAPPENS WHEN DRIVING VEHICLE 2 HOURS PLUS.

AIR CONDITIONING WILL RANDOMLY SWITCH TO HOT AIR WHILE DRIVING. IF YOU STOP AND RESTART THE CAR AIR CONDITIONING WILL WORK AGAIN.

FIRST THE TRANSMISSION FAILED RIGHT AFTER I PURCHASED THE VEHICLE 2 YEARS AGO. I HAD TO BUY A NEW TRANSMISSION THAT WASN'T CHEAP AROUND $3,500. THEN THE FRONT WHEEL BEARINGS STARTED WITH THE RIGHT SIDE LAST YEAR JUST HAD A TON OF PLAY IN IT MY MECHANIC FOUND IT WHEN LIFTING UP MY TRUCK FOR A TIRE ROTATION. THEN THE LEFT FRONT WHEEL BEARING JUST STARTED MAKING A LOAD ROARING NOISE BUT HAD NO PLAY IN IT AT ALL THAT I COULD FEEL WHEN CHECKING IT OUT. BOTH COST AROUND $250 A WHEEL TO REPLACE. NOW MY 5.3 LITER ENGINE IS HAVING A KNOCKING SOUND WHEN AT A STOP AFTER DRIVING ABOUT 30 MINUTES OR WHEN THE ENGINE IS HOT. ALSO I AM HEARING A SLIGHT TICKING SOUND FROM THE ENGINE COLD OR HOT. I HAVE 4 SMALL KIDS SO I NEED A VERY RELIABLE LARGE VEHICLE AND THIS IS SUBURBAN IS DRIVING ME AND MY WIFE CRAZY HAVING TO POOR MONEY IN THIS VEHICLE EVERY YEAR. I AM THE SOIL PROVIDER FOR MY FAMILY I CANT AFFORD PUTTING ALL MY MONEY INTO A VEHICLE LIKE THIS.

ON 4/11/2020, WHILE TRAVELING NORTHBOUND ON N. MAIN STREET, FAYETTEVILLE, NC AND ACCELERATING FROM THE STOPLIGHT AT THE INTERSECTION OF CAMDEN ROAD, I WAS REQUIRED TO APPLY THE BRAKES FORCEFULLY AND SUDDENLY DUE TO THE ACTIONS OF ANOTHER MOTORIST. ALMOST IMMEDIATELY AFTER APPLYING THE BRAKES, I LOST ALL BRAKING POWER AND RESORTED TO UTILIZING THE MANUAL PARKING BRAKE TO BRING THE VEHICLE UNDER CONTROL AND DRIVE IT CAREFULLY BACK TO MY RESIDENCE. AT THE MOMENT OF FAILURE, THE DASHBOARD BRAKE INDICATOR LIGHT (AKA, IDIOT LIGHT) ILLUMINATED AND A "SERVICE BRAKE SYSTEM" MESSAGE APPEARED ON THE INSTRUMENT CLUSTER. THE BRAKE INDICATOR LIGHT CONTINUED TO ILLUMINATE SPORADICALLY DURING THE TRIP BACK TO MY RESIDENCE WHEN TESTING THE BRAKE PEDAL FOR RESUMED FUNCTIONALITY. AFTER ARRIVING HOME, I PERFORMED A QUICK INSPECTION OF THE BRAKING SYSTEM AND FOUND THAT THE PORTION OF THE BRAKES LINES LOCATED ON THE OUTBOARD PORTION OF THE DRIVER'S SIDE FRAME RAIL HAD RUSTED AND PERFORATED NEAR THE ABS MODULE, CAUSING THE FAILURE ALONG WITH MASSIVE FLUID LOSS (SEE ATTACHED PICS). I PERFORMED A CURSORY INTERNET SEARCH AND DISCOVERED THAT THE NHTSA HAS ALREADY PERFORMED AN INVESTIGATION INTO THIS EXACT ISSUE AND THE INVESTIGATION WAS SUBSEQUENTLY CLOSED WITH NO RECALL ISSUED BY GM. OF NOTE, GM VEHICLES USE A MANUAL PRESSURE DIFFERENTIAL SWITCH LOCATED WITHIN THE BRAKE COMBINATION VALVE THAT ISOLATES THE DAMAGED CIRCUIT IN THE EVENT OF FAILURE AND ALSO ILLUMINATES THE DASHBOARD BRAKE LIGHT. THIS SYSTEM DID NOT OPERATE IN THIS INSTANCE AS EVIDENCED BY LOSING ALL BRAKING, AS OPPOSED TO REDUCED BRAKING, AS WELL AS THE BRAKE LIGHT NOT REMAINING ILLUMINATED. BASED ON THE APPEARANCE OF THE UNDERCARRIAGE AND INDICATION OF RUST IN SEVERAL SPOTS ON THE BODY (E.G, TAILGATE), I BELIEVE THIS TRUCK WAS OPERATED IN ONE OF THE RUST BELT STATES FOR A PERIOD OF TIME BY A PRIOR OWNER.

BRAKES GAVE OUT SUDDENLY WITHOUT WARNING.CHEVY DEALER SAID LINES ARE RUSTED AND NEED REPLACE AT COST OF $1600.ALSO JUST REPLACED STEERING GEAR BOX PITMAN ARM AND IDLER ARM AND WHEEL BEARING HUB AT A COST OF $2300 BECAUSE YOUR NUTS ON THE STEERING ASSEMBLY HAVE A TENDENCY TO COME OFF.

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. WHILE DRIVING 20 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE AND VEERED THE VEHICLE TO THE SHOULDER OF THE ROAD, WHICH ALLOWED THE VEHICLE TO COME TO A COMPLETE STOP. THE VEHICLE WAS TOWED BY ONSTAR TO DENOOYER CHEVROLET (127 WOLF RD, ALBANY, NY 12205, (518) 458-7700) WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 111,795.

I WAS DRIVING ON THE EXPRESSWAY WHEN I HAD TO APPLY A STRONG FORCE TO THE BRAKES IN ORDER TO AVOID HITTING A VEHICLE. SIMULTANEOUSLY, THE SURBURBAN BRAKES BECAME VERY STIFF AND I LOST POWER STEERING AT THE SAME TIME. AFTER APPLYING AN EXTREME EXCESSIVE AMOUNT OF FORCE I WAS ABLE TO STOP THE VEHICLE AND AVOID AN ACCIDENT. I HAD TO FIND THE NEAREST EXIT AND WHILE DOING SO IT WAS EXTREMELY HARD TO MAKE A 15 DEGREE TURN AND ALSO EXTREMELY HARD TO COME TO A COMPLETE STOP. IT WAS VERY DANGEROUS AND I WAS SCARED FOR MY LIFE. I TOLD A MECHANIC ABOUT THIS AND HE SAID IT SOUND LIKE A BAD HYDRO BOOSTER. I LOOKED IT UP ONLINE AND SAW THAT THERE WAS A RECALL ON IT. WHEN I LOOKED IT UP IT SAID 0 OPEN. THIS IS DEFINITELY A SAFETY ISSUE. PLEASE HELP!.

I NOTICED CORRODED AND WHAT I WOULD CALL CHARRED OR BURNT WIRING ON THE WIRING HARNESS FOR THE REAR LIFT GATE OF MY SUBURBAN. I NOTICED IT WHEN I OPENED THE LIFT GATE TO GAIN ACCESS TO THE REAR OF THE SUBURBAN. IT APPEARS THAT THE RUBBER GROMMET MATERIAL PROTECTING THE WIRING HARNESS, WAS BURNT OR MELTED AWAY. THE RUBBER HOSE THAT SUPPLIES WATER TO THE REAR WINDOW WASHER/WIPER HAD A HOLE IN IT, AND MAY HAVE BEEN LEAKING WINDSHIELD WASHER FLUID ONTO THE WIRES FOR A TIME. THE WIRES WERE BARE IN SOME SPOTS, SOME OF THE WIRE INSULATION LOOKED MELTED/BURNT AWAY, AND THEY LOOKED CORRODED/WITH A GREEN COLOR TO THEM. THE CONNECTOR THAT CONNECTS THE HARNESS, TO THE REST OF THE ELECTRICAL SYSTEM, LOOKED LIKE IT HAS SOME BLACK/ POSSIBLY BURNT RESIDUE ON IT. I CAN TAKE A GUESS AT BEST, THAT BECAUSE OF THE HOLE IN THE RUBBER HOSE, WATER MAY HAVE BEEN LEAKING ONTO THE ELECTRICAL WIRING/CONNECTIONS WHEN I USED THIS FEATURE TO CLEAR DIRT FROM THE LIFT GATE WINDOW, BUT I DON'T REALLY KNOW FOR SURE IF THAT IS HOW THE DAMAGE TO THE WIRING HARNESS HAS OCCURED! THANKS!

THE 2005 CHEVROLET SUBURBAN 2500 WAS TRAVELING ON A CITY STREET AND THE BRAKES BECAME SOFT INSTANTLY, A COLLISION WAS AVOIDED BY STEERING AWAY FROM THE CARS AT THE INTERSECTION AND THE EMERGENCY BRAKE WAS USED. THERE WAS NO WARNING ON THE SUDDEN FAILURE, OTHER THAN A INDICATOR ON THE DASH. A SHORT DRIVE TO THE HOME DRIVEWAY, THE REMAINING BRAKE FLUID HAS ALL LEAKED OUT UNDER THE DRIVERS DOOR LOCATION.

IN MOTION ON CITY AND HIGHWAY

DRIVER SIDE SEAT HEATER RANDOMLY COMES ON AND GOES OFF. MAJORITY OF THE TIME THE HEATER STAYS ON CONSTANTLY AND BECOMES UNCOMFORTABLE. THIS HAPPENS MORE ESPECIALLY IN WET CONDITIONS AND WHEN YOU ATTEMPT TO TURN THE HEATED SEAT OFF, THE CONTROLS WON'T WORK. THIS ISSUE HAPPENS WHEN THE SUV IS STARTED, CONTINUES WHILE IDLING AND WHILE DRIVING. SOME DAYS IT IS HOURS BEFORE IT WILL GO OFF. OTHER DAYS IT WILL NOT GO OFF. THE SCARY THING IS YOU CAN HEAR THE DASHBOARD CLICKING WHEN THE HEATER TURNS ON AND OFF, CONSTANTLY CYCLING THOUGH HIGH TO LOW, BACK OF SEAT TO BOTTOM OF THE SEAT. ADJUSTING THE SEAT IN ANY WAY DOES NOT HELP. I THINK THIS IS A CONCERN DUE TO THE FACT THAT IT TURNS OFF AND ON AND YOU CAN HEAR IT CYCLE THROUGH. IT'S ALSO A MAJOR CONCERN BECAUSE THE HEAT STAYS ON WITHOUT ANY WAY TO TURN IT OFF. THIS STARTED A WEEK AFTER I PURCHASED THIS VEHICLE AND HAS CONTINUED SINCE OCTOBER 2016.

THE FUEL LINE THAT IS ON TOP OF THE GAS TANK ROTTED THROUGH. THE BRAKE AND TRANSMISSION LINES ROTTED AND LEAKED. THE CHASSIS IS ROTTING IN DIFFERENT PLACES I HAVE LESS THAN 77,000 MILES ON IT SINCE I BOUGHT NEW. I HAVE A 1969 MALIBU THAT I'VE HAD SINCE IT WAS NEW AND I KEEP IT OUTSIDE IN ALL KINDS OF WEATHER AND NOT ONE PART OF THE CHASSIS IS ROTTED. I DON'T KNOW WHAT KIND OF STEEL THEY USE NOW TO BUILD THESE CARS AND TRUCKS, BUT IT SHOULD BE UNACCEPTABLE. I DON'T KNOW THE EXACT DATES THESE THINGS HAPPENED, BUT I DO HAVE ALL THE REPAIR BILLS FOR THEM. WHEN THE BRAKE LINE ROTTED THROUGH I WAS GOING TO THE STORE AND WHEN I CAME TO A YIELD SIGN THE BRAKE PEDAL WHET TO THE FLOOR. IT'S A GOOD THING IT HAPPENED THEN, BECAUSE I LIVE ON A MOUNTAIN AND WE HAVE A ROAD CALLED BREAKNECK AND IT IS A 25% GRADE. IT WAS RAINING THE DAY THAT THIS HAPPENED AND ALL I HAD WAS A LITTLE BIT OF FOOT BRAKE AND THE EMERGENCY BRAKE. I SURELY WOULD HAVE HAD A BAD ACCIDENT IF I MADE IT TO THAT HILL.

I HAD A RUSTED BRAKE LINE (DRIVER SIDE FRONT) FAIL JUNE 25TH, 2017. THIS TRUCK IS 12 YEARS OLD AND HAS LESS THAN 90,000 MILES. IMMEDIATELY ALL BRAKING WAS LOST AND THE PEDAL PUSHED TO THE FLOOR. REPEATED PRESSING THE BRAKE ONLY PUMPED OUT ALL THE BRAKE FLUID. THIS WAS A SUDDEN AND CATASTROPHIC LOSS OF BRAKING. THE WORST PART IS, BRAKING IS SUPPOSED TO BE SPLIT AND INDEPENDENT BETWEEN FRONT AND REAR BRAKES, SO IF YOU LOSE THE FRONT, THE REAR BRAKES STILL WORK, AND VICE VERSA. WELL I LOST ALL BRAKING, I HAD NO FRONT OR REAR BRAKING! THIS SHOULD BE A CLEAR SAFETY PROBLEM AND A MANDATORY RECALL! I CRASHED INTO THE CAR IN FRONT OF ME, BECAUSE OF COURSE MY EMERGENCY BRAKE DIDN'T WORK EITHER. DESPITE GM'S INSISTENCE THAT SOMEHOW THIS PREMATURE BRAKE LINE FAILURE IS NORMAL AND THE OWNER'S MAINTENANCE PROBLEM, IT SHOULD BE A VERY SIMPLE ISSUE FOR THE NHTSA TO SIMPLY OPEN A SINGLE BRAKE LINE AND TEST TO REALIZE THE AFFECTED VEHICLES DO IN FACT LOSE ALL BRAKING, NOT JUST FRONT OR REAR. I'VE ALREADY COMPLETELY LOST FAITH IN GM TO DO THE RIGHT THING, BUT I'D LIKE TO BELIEVE THE NHTSA WILL STILL DO THE RIGHT THING, AND NOT LET GM OFF WITH A CLEAR SAFETY PROBLEM WITH THEIR BRAKE DESIGN. THIS CRASH WAS PULLING UP TO THE STOPLIGHT IN PRESCOTT, WI, HEADING INTO TOWN ACROSS THE PRESCOTT BRIDGE. I WAS DRIVING MAYBE 30 MPH WHEN I REALIZED I HAD LOST ALL BRAKES.

FOR APPROXIMATELY THE LAST 4 YEARS THE AIRBAG LIGHT HAS BEEN ON INDICATING AN ISSUE WITH THE AIRBAG SYSTEM. GIVEN ALL THE AIRBAG PROBLEMS IN RECENT YEARS AND THE FACT THIS SEEMS TO BE A COMMON PROBLEM WITH 2005 GM SUVS AND GIVEN AIRBAGS ARE VITAL SAFETY EQUIPMENT GM NEEDS TO PROVIDE OWNERS WITH THESE PROBLEMS A FREE FIX OR BE FORCED TO RECALL THESE VEHICLES IMMEDIATELY FOR REPAIRS BEFORE ALOT OF PEOPLE GET HURT OR KILLED.

ONE MORNING CAME OUT TO START MY 2005 SUBURBAN AND THE SERVICE AIRBAG MESSAGE POPPED ON ALONG WITH THE AIRBAG LIGHT. TOOK IT TO MY SERVICE CENTER AND WAS TOLD IT WAS A FRONT IMPACT SENSOR. WAS ALSO TOLD THIS IS A COMMON PROBLEM ON THESE VEHICLES. AFTER DOING SOME RESEARCH ONLINE I HAVE FOUND THIS TO BE A VERY COMMON PROBLEM RENDERING THE AIRBAG SYSTEM INOP. I BELIEVE GM NEEDS TO STEP UP AND FIX THE ISSUE WITH THE SENSORS AS NOT EVERYONE HAS $400 TO FIX A FAULTY SENSOR. THE ODOMETER ON MY SUBURBAN IS 127,000 MILES, SO BY NO MEANS DRIVEN HARD.

2005 CHEVROLET SUBURBAN 1500 4X4 FLEX FUEL, 5.3L. THIS VEHICLE'S INSTRUMENT CLUSTER DOES NOT WORK. TACHOMETER PEGS AND STICKS. THE SPEEDOMETER IS STUCK AT ZERO. THIS IS A VERY SERIOUS SAFETY CONCERN THAT GENERAL MOTORS/GM SHOULD DO A FREE RECALL FOR AS MANY OWNERS OF THIS VEHICLE HAVE THE SAME PROBLEMS. MY ABS SENSOR LIGHT COMES ON AND OFF NUMEROUS TIMES A DAY, AND CLUSTER STATES SERVICE AIR BAG. GENERAL MOTORS SHOULD ALSO FIX THIS FOR FREE UNDER A RECALL AS OTHERS HAVE THE SAME ISSUE WITH THIS VEHICLE. MY THIRD MAJOR COMPLAINT, IS THE VEHICLE STARTING PROBLEM/HARD START. IT TAKES TWO TURNS OF THE ENGINE FOR THE VEHICLE TO TURN ON AND STAY RUNNING. I HAVE RESEARCHED THIS ON VARIOUS SEARCH ENGINES, FORUMS, AND INCLUDING RECALL.GOV. GENERAL MOTORS SHOULD ADDRESS THIS ISSUES AS WELL UNDER A RECALL. GM INSTALLED FAULTY FUEL PUMPS OR FUEL PUMPS WITH FAULTY COMPONENTS IN THEM. A VEHICLE SHOULD START WITH ONE TRY. I SHOULD NOT HAVE TO GET THE FUEL PRESSURE GOING IN THE ON POSITION, OR CRANK IT TWICE FOR MY TRUCK TO START.

IT WOULDN'T LET ME PICK TIRES I HAVE A SET OF 4 BRIDGESTONE DEULER H/L AND THE TIRES HAVE 2 TIRES HAVE 6/32 OF TREAD AND THE OTHER 2 HAD 8/32 AND ON ALL 4 TIRES THE BELTS ARE SEPARATING !!! I USED TO HAVE A CDL LICENSE AND DRIVE TOW TRUCKS AND IF I GOT PULLED OVER BY THE STATE WHETHER IT BE BY D.O.T. OR STATE POLICE I WOULD RECEIVE TICKETS AND POSSIBLY BE STUCK AT WEIGH STATION WAITING FOR A TIRE REPAIR SERVICE TO SHOW UP !!

REAR BRAKE LINE FAILED. MY WIFE AND KIDS WERE IN THE 2005 SUBURBAN 1500, SHE MANAGED TO PRESS THE EBRAKE THEN TURN THE SUBURBAN INTO SOMEONE'S FRONT YARD WHERE IT EVENTUALLY CAME TO REST ON A HILL. SHE WAS HEADED DOWNHILL ON A RESIDENTIAL STREET AT THE TIME OF FAILURE. TOOK TO HUNDRU CHEV IN MANHEIM PA I WAS TOLD THE REPAIR WILL BE SOMEWHERE AROUND $2300.00

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. WHILE ATTEMPTING TO USE THE REAR HATCH OF THE VEHICLE, THE REAR HATCH FAILED TO OPEN. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 136,210.

I TURNED MY 2005 SUBURBAN ON AND THE AIR BAG LIGHT CAME ON. I TOOK IT IN TO THE CHEVY/GM DEALER WHO SAID, "THE RIGHT, FRONT, AIR BAG SENSOR WAS THE CAUSE." IT WOULD COST $375 TO FIX IT. I DID NOT GET IT FIXED AT THAT TIME. IT IS DANGEROUS BECAUSE THE AIR BAGS ARE INOPERABLE. THE PROBLEM OCCURRED AT ABOUT 150,000 MILES. FROM WHAT I HAVE SEEN THIS IS A HUGE PROBLEM THAT NEEDS TO BE ADDRESS BY THE COMPANY.

WHILE DRIVING THE DRIVER SIDE HEATED SEATS INGAUGE BY THEMSELVES AND COME ON EVERY TIME WE USE THE VEHICLE. WE HAVE TRIED TURNING THEM BACK OFF, BUT THEY COME RIGHT BACK ON AND WILL CYCLE UP AND DOWN A FEW TIMES THEN STAY IN THE HIGH POSITION. I THOUGHT AT FIRST THAT MY HUSBAND WAS ACCIDENTALLY TURNING THEM ON BUT HE WASN'T. IT DOES IT ALL THE TIME. THERE IS NO RYHME OR REASON TO IT. ITS VERY DISTRACTING TRYING TO TURN THEM OFF OVER & OVER AGAIN. I COULD SEE WHERE IT COULD BE A SAFETY ISSUE. I RESEARCH END ON THE INTERNET AND HAVE SEEN HUNDREDS OF POST ON THE SAME ISSUE. NONE OF THEM HELPED WITH A SOULOUTIN TO THE PROBLEM. I PUT MY VIN # IN TO SEE IF THEIR WERE ANY RECALLS ON THIS ISSUE. AND COULDN'T FIND ONE. MY QUESTION IS WHY? WITH AS MANY COMPLAINTS AS THERE ARE ONLINE. NOT SURE IF THEY WERE NOT COMPLAINING HERE ABOUT IT BUT NOW AT LEAST I HAVE. IT DOESN'T MATTER WHOSE DRIVING IT, WHEATER ISN'T A FACTOR EITHER. IN TOWN OR HIGHWAY MAKES NO DIFFERENCE HELP PLEASE

AS I WAS ABOUT TO EXIT A PARKING LOT ONTO A FOUR LANE ROADWAY, THE BRAKES ON MY 2005 CHEVROLET SUBURBAN FAILED. I LIVED APPROXIMATELY 1/2 MILE FROM THIS LOCATION AND PROCEEDED TO DRIVE HOME. IT WAS A LITTLE SCAREY WITHOUT ANY STOPPING POWER, EVEN THE EMERGENCY BAKE WOULD NOT HOLD. WHEN I GOT HOME, I USED A FLASHLIGHT TO TRY TO FIND THE SOURCE OF THE PROBLEM. FOUND A PATTERN OF BRAKE FLUID LEAKING. REMOVED THE SPARE TIRE TO GET A BETTER LOOK AND FOUND A BRAKE LINE BETWEEN THE ABS AND REAR OF THE VEHICLE HAD RUSTED OUT. FROM THE LOOKS OF THE LINE CONDITION, THEY NEED TO BE ALL REPLACED. NEVER IN MY 70 YEARS HAVE I SEEN BRAKE LINES ON A TEN YEAR OLD VEHICLE LOOK LIKE THEY DID, REALLY IN BAD SHAPE. LOOKED AT OTHER LINES, FUEL, TRANSMISSION, THEY ALL LOOKED LIKE THEY SHOULD BE REPLACED.

FIRST INCIDENT EASTERN PA: 05/19/2014 APROX 119000 MILES: AFTER HITTING THE BRAKES HARD TO AVOID A VEHICLE THAT PULLED IN FRONT OF ME, THE BRAKES FAILED (BRAKE PEDAL WOULD GO TO THE FLOOR WITH LITTLE BRAKING ACTION). MANAGED TO SAFELY STOP. FOUND BURST BRAKE LINE IN THE REAR END OF VEHICLE. TWO REAR CORRODED REAR BRAKE LINES REPLACED BY LOCAL REPAIR SHOP. SECOND INCIDENT MILFORD MA: 09/17/2015 127336 MILES: HIT BRAKES GOING DOWN DRIVEWAY. BRAKES WERE SOFT AND SANK TO FLOOR. BRAKE LINE GOING TO FRONT PASSENGER WHEEL WAS BURST. ALL THE BRAKE FLUID DRAINED QUICKLY OUT OF THE MASTER CYLINDER ONTO THE DRIVEWAY. ORDERED ACDELCO 22932592 GM ORIGINAL EQUIPMENT HYDRAULIC BRAKE PIPE KIT AND AM IN THE PROCESS OF REPLACING ALL BRAKE LINES AS ALL OF THEM OTHER THAN THE TWO REPLACED IN PA ARE VERY CORRODED. THE REPLACEMENT LINES ARE NOT REALLY OEM AS THEY HAVE A NYLON COATING FOR BETTER CORROSION PROTECTION

THE REAR LIFTGATE WILL NOT UNLOCK. THERE IS NO MANUAL RELEASE OR "KEY BYPASS" FOR THE REAR LIFTGATE LOCK. THIS PRESENTS A SERIOUS SAFETY ISSUE IN CASE OF FIRE OR CRASH.

AFTER RUNNING VEHICLE, GAS RUNS DOWN SIDES FROM TOP OF FUEL TANK, AND DRIPS UNDER VEHICLE. CONTINUES TO DRIP IF CAR IDLES. STOPS IF CAR IS SHUT OFF. STRONG SMELL OF FUEL AFTER DRIVING VEHICLE

AIR BAG SENSOR FAILURE RENDERING THE AIRBAGS INOPERABLE.

BEGAN HEARING A "WHINING" NOISE UNDER THE VEHICLE. NOISE WAS PROGRESSIVELY LOUDER AT ACCELERATED SPEEDS. LEFT VEHICLE AT LOCAL CHEVROLET DEALER (CA) WHO DID AN INSPECTION AND DIAGNOSED A MECHANICAL ISSUE POSSIBLY WITH THE DIFFERENTIAL [REF. CLAIM CHECK 175]. SERVICE WRITER STATED ESTIMATED REPAIR COST FOR AN OVERHAUL WAS $3,000 VS. HIGHER COSTS TO REPLACE WITH USED OR NEW DIFFERENTIAL. SERVICE WRITER FURTHER INDICATED CONTINUED DRIVING COULD CAUSE FURTHER DAMAGE AND ADDED COST IF AXLE WAS ALSO AFFECTED. DECIDED TO TAKE VEHICLE TO A RECOGNIZED POWERTRAIN REPAIR FACILITY WHO DETERMINED (ALSO WITH A DRIVE TEST) THAT THE DIFFERENTIAL WAS THE PROBLEM AND GAVE INITIAL $1,200 ESTIMATE. AUTHORIZED REPAIR. FINAL COST WAS $813 AND INCLUDES 1 YEAR FULL WARRANTY. NOW RUNS SMOOTH / QUIET WHEN DRIVING. TECHNICIAN INDICATED THAT ALTHOUGH FLUID LEVEL WAS GOOD (SEALED AT FACTORY), A RING INSIDE THE DIFFERENTIAL WAS BAD (HAD BECOME PITTED AND COULD HAVE CAUSED FURTHER ISSUES IF UNCHECKED. CHANGED OUT RING AND BEARINGS BUT ALL OTHER COMPONENTS INCLUDING CASING WERE FINE. TECHNICIAN STATED SUCH WEAR IS UNCOMMON FOR A VEHICLE WITH ONLY 126K MILES AND WITH NO TOWING ON FACTORY TOW PACKAGE. IS THIS AN ANNOMILY OR ARE THERE OTHER CASES OF BAD PARTS IN DIFFERENTIAL FOR THIS MAKE / MODEL? WOULD LIKE TO DISCUSS FURTHER WITH GM ZONE REP. BUT NO RESPONSE!!!

WHILE DRIVING AROUND TOWN I NOTICED MY BRAKES FEELING MUSHY AND THE PEDAL NEEDING TO BE PRESSED FURTHER INTO THE FLOORBOARD. MY "CHECK BRAKE SYSTEM" LIGHT CAME ON AND UPON INSPECTION NOTICED THAT I WAS LOW ON BRAKE FLUID. I FILLED THE BRAKE FLUID RESERVOIR TO THE MAX LINE. THE NEXT DAY THE SAME WARNING LIGHT CAME ON AND I FURTHER INSPECTED THE BRAKE LINES TO FIND THAT THE LINES FROM THE ABS BOX TO THE REAR HAD RUSTED OUT AND WERE LEAKING BADLY. *TR

THE SPEEDOMETER NEEDLE BEGAN "CATCHING," NOT MOVING SMOOTHLY. AFTER ABOUT 2 WEEKS IT WOULD NOT RESET TO 0 WHEN STOPPED THEN AFTER 1 MORE DAY IT QUIT REGISTERING COMPLETELY.

TACH AND SPEEDOMETER NOT WORKIN

WE BOUGHT OUR CHEVY SUBURBAN IN MAY OF 2014, 73,000 MILES, GARAGE KEPT VEHICLE. THE SUBURBAN IS IN BEAUTIFUL SHAPE, ENGINE COMPARTMENT SHOWS VERY LITTLE SIGNS OF RUST OR CORROSION, SAME GOES FOR THE UNDERSIDE OF THE VEHICLE, VERY CLEAN. THIS PAST WEEKEND WHILE TRAVELING DOWN A LARGE HILL, MY WIFE HAD OUR TWO BOYS WITH HER IN THE VEHICLE AGES 5 AND 7 WHEN ALL OF A SUDDEN THE BRAKES GAVE OUT COMPLETELY, NO BRAKING POWER AT ALL. IF IT WASN'T FOR THE EMERGENCY BRAKE THEY WOULD HAVE BEEN SERIOUSLY HURT OR WORSE. UPON INSPECTION OF THE VEHICLE WE FOUND THAT THE BRAKE LINES ARE COMPLETELY ROTTED, THE ONLY PART ON THE VEHICLE THAT LOOKS LIKE THIS. WE KNOW WHO OWNED THE VEHICLE BEFORE US, ONE OWNER, AND SHE DID NOT DRIVE THIS VEHICLE VERY OFTEN IN WINTER WEATHER. SHE WORKS FOR A SCHOOL DISTRICT AND HAS OFF WHEN IT SNOWS. SHE ALSO HAD AN OLDER CAR THAT SHE DROVE WHEN THE WEATHER AND ROADS WERE BAD. THESE BRAKE LINES ARE FAULTY. THERE IS NO WAY THESE BRAKE LINES SHOULD LOOK LIKE THIS AFTER 9 YEARS ON THE ROAD. MY NEIGHBOR HAS A 2005 YUKON AND HAS THE SAME PROBLEM. MY FRIEND [XXX] HAS A 2003 GMC PICKUP, SAME PROBLEM, HE ALMOST CRASHED INTO A LAKE WHEN HIS BRAKE LINES FAILED. SOMETHING NEEDS TO BE DONE ABOUT THIS AND FAST AS PEOPLE ARE GOING TO GET KILLED. I HAVE PICTURES I CAN SHARE WITH ANYONE WHO WANTS TO SEE THEM. YOU CAN ALSO CONTACT ME AT ANY TIME. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

HAD SERVICED THE TRANSFER CASE AND HAD TAKEN IT BACK TWICE NOW BESIDES A NOISE LIKE THAT OF A POWER STEERING PUMP GOING BAD ( WHINING ) , HAD A TURNING CLUNK NOISE COMING AND AT A STOP LIGHT I SAW SMOKE COMING FROM PASSENGER SIDE, GOT TO PARK IT AND SMELLED LIKE SOMETHING IS BURNING .BRING IT BACK TO SEE IF THE MECHANIC WILL WORK ON IT SINCE IT HASN'T BEEN 30 DAYS. PLEASE NOTIFY ME OF ANYTHING DO TO THE TRANSFER CASE. *TR

MY 2005 CHEVROLET SUBURBAN HAS RUSTED BRAKES LINES THAT WILL COST ME $2,000 TO REPAIR. INTERESTINGLY I SEE MANY NATIONAL ARTICLES ABOUT THE PROBLEM AND A SIGNIFICANT NUMBER OF COMPLAINTS FILED. GM HAS REFUSED TO ISSUE A RECALL TO COVER THIS DANGEROUS PROBLEM; OTHER AUTOMAKERS HAVE DONE SO. THE NHTSA HAS BEEN INVESTIGATING THIS FOR WELL OVER 3 YEARS AND DONE NOTHING ABOUT IT TO DATE. I DON'T HAVE $2,000 TO HAVE THE WORK DONE, HOWEVER I ALSO CAN'T RISK THE LIVES OF MY FAMILY AND THOSE OF OTHER DRIVERS AND PEDESTRIANS. THIS PROBLEM NEEDS IMMEDIATE ACTION AND GM SHOULD TAKE FULL RESPONSIBILITY FOR THE REPAIR. PRIOR TO THIS I WOULD CONSIDER BUYING ANOTHER SUBURBAN, HOWEVER, NO MORE GM FOR ME! ITS A DISGRACE THE GM DOES NOT VALUE ITS CUSTOMERS AND THEIR SAFETY AND THAT THE NHTSA HAS NOT STEPPED UP TO FORCE A RECALL. JUST HOW MANY PEOPLE HAVE TO BE SERIOUSLY INJURED OR DIE FOR ACTION TO OCCUR? *TR

FRONT BRAKE LINE FAILURE/BRAKE LINE RUPTURE. 6 MONTHS AGO IT WAS THE REAR BRAKE LINE FAILURE/RUPTURE. BRAKE FLUID CAUSED SMOKE AND SMALL FIRE ON THE EXHAUST HEADERS. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE GEAR SHIFTED INTO NEUTRAL INDEPENDENTLY. THE ENGINE WAS TURNED OFF AND RESTARTED. THE VEHICLE RESUMED IN THE FOUR WHEEL DRIVE MODE. THE FAILURE OCCURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TWICE WHERE THE SHIFT GEAR ACTUATOR WAS REPLACED. ON A SEPARATE OCCASION, THE PUSH BUTTON GEAR SELECTOR WAS ALSO REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 38,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE TWO WHEEL OR FOUR WHEEL DRIVE LIGHT FAILED TO ILLUMINATE. THE FAILURE PREVENTED THE CONTACT OF KNOWING WHICH GEAR THE VEHICLE WAS IN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. WHILE DRIVING IN REVERSE, THE CONTACT WAS UNABLE TO STOP THE VEHICLE BY DEPRESSING THE BRAKE PEDAL. THE CONTACT HAD TO DEPRESS THE BRAKE PEDAL TO THE FLOORBOARD IN ORDER TO STOP THE VEHICLE. THE MECHANIC STATED THAT THE BRAKE LINES WERE ROTTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

MY 2005 CHEVROLET SUBURBAN Z71 SWITCHES RANDOMLY AND WITHOUT SPECIFIC CAUSE INTO REDUCED ENGINE POWER WHICH NEARLY GO ME KILLED WHEN MERGING INTO A HIGH-SPEED INTERSTATE PULLING A TRAILER. THE ONLY WAY TO "FIX" IT (MAKE THE ENGINE RUN NORMAL AGAIN) IS TO PULL TO THE SIDE IF THE HIGHWAY (DANGEROUS!) AND SHUT THE TRUCK OFF FOR A FEW MINUTES. THIS HAPPEN RANDOMLY BUT AT LEAST THREE TIMES A DAY. I KNOW OTHERS HAVE THIS PROBLEM AND GM SAYS I HAVE TO BRING IT TO THEN WHEN THIS IS OCCURRING BUT I CAN'T DO THAT WHEN THE TRUCK IS BARELY LIMPING ALONG! THIS IS A SAFETY ISSUE AND IS WELL DOCUMENTED ON GM CHAT SITES ACROSS THE INTERNET. *TR

TL* THE CONTACT OWNS 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHEN TURNING THE VEHICLE OFF THE ENGINE FAN FAILED TO TURN OFF. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

AIR BAG SENSOR HAS FAILED CAUSING THE AIRBAGS TO BE RENDERED INOPERABLE. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE ABS LIGHT ILLUMINATED AND THERE WAS A RATTLING NOISE COMING FROM THE ENGINE COMPARTMENT. THE CONTACT MENTIONED THAT THE KEY WOULD NOT ALWAYS TURN THE VEHICLE ON. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE CONTACT REFUSED TO HAVE THE VEHICLE DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 118,000 AND THE CURRENT MILEAGE 118,500.

THE DRIVER SIDE SEAT HEATER RANDOMLY TURNS ITSELF ON. WHEN YOU TURN IT OFF IT COMES BACK ON AGAIN AND RANDOMLY CYCLES THROUGH THE VARIOUS SETTINGS. IT'S ALMOST A CONSTANT BATTLE TRYING TO KEEP IT TURNED OFF WHICH CREATES A HAZARDOUS SITUATION EQUAL TO, OR WORSE, THEN TEXTING WHILE DRIVING AS YOU HAVE TO KEEP LOOKING DOWN TO PUSH THE BUTTON, ESPECIALLY HERE IN FLORIDA WHERE YOU DON'T NEED (OR WANT) SEAT HEAT IN THE SUMMER. I'VE FOUGHT THIS TO THE POINT THAT I'VE WORN THE PAINT OFF THE SWITCH. IF YOU SEARCH THE INTERNET THIS IS A VERY PREVALENT PROBLEM WITH GM VEHICLES DURING THESE MODEL YEARS. I ALSO HAVE A 2006 GMC SIERRA THAT DOES THE EXACT SAME THING. I'VE BEEN TO AT LEAST 5 DIFFERENT DEALERSHIPS AND EITHER THEY CAN'T FIX IT OR THEY CLAIM THEY'VE NEVER HEARD OF THE PROBLEM. THAT CAN'T BE TRUE SINCE GM ISSUED A TSB FOR THIS PROBLEM BUT THE RECOMMENDED FIX (REPROGRAMMING THE DRIVER DOOR SWITCH) ACTUALLY DOES NOT FIX THE PROBLEM. IN FACT, WHEN THE DEALER REPROGRAMMED MY GMC IT ACTUALLY MADE IT WORSE TO WHERE IT HAPPENS MUCH MORE FREQUENTLY. I CONTACTED GM AND EVEN THOUGH I TOOK IT TO A DEALER 4-5 MONTHS AGO WHERE THEY COULDN'T FIX IT, GM SAYS I HAVE TO TAKE IT BACK TO THE DEALER (PAY ANOTHER $100 DIAGNOSTIC FEE) TO MEET THEIR POLICY THAT THEY WILL ONLY ADDRESS THE ISSUE IF YOU'VE BEEN TO A DEALER WITHIN THE LAST 30 DAYS. SOME REPORTS ARE THE SEAT HEATER ELEMENTS ARE SHORTING OUT. EITHER WAY THIS CREATES A VERY UNSAFE SITUATION FOR DRIVERS. GM SAYS I CAN PULL THE FUSE FOR THE SEAT HEATERS. HOWEVER, WHEN YOU REMOVE THE FUSE LABELED "SEAT HEATER" IT ACTUALLY DOES NOTHING. THE SEATS ARE STILL POWERED AND THE PROBLEM PERSISTS. THIS CLEARLY INDICATES AN ELECTRICAL PROBLEM AND DESIGN FLAW. THE ONLY SURE CURE IS TO REMOVE THE 30 AMP BREAKER UNDER THE DASH RENDERING YOUR DRIVER/PASSENGER INOPERATIVE. GM MUST FIX THIS PROBLEM BEFORE SOMEONE GETS KILLED FROM BEING DISTRACTED. *TR

HAD TO REPLACE SECOND FAULTY IMPACT SENSOR FOR AIR BAG ON MY VEHICLE. THIS IS LOCATED IN FRONT OF VEHICLE. THE FIRST REPLACEMENT OF THE OTHER SENSOR WAS JULY 26, 2013. THIS VEHICLE WAS NEVER IN A CRASH AND HAD NOT DAMAGE TO THE FRONT OF THE VEHICLE. WHEN THE AIR BAG COMES ON THEY TELL ME MY AIR BAGS NO LONGER WORK. MY FAMILY HAS A 2000 CHEVROLET TAHOE THAT HAS NEVER HAD THIS PROBLEM. I AM SURE THERE IS A LOT OF PEOPLE WHO WOULD NOT HAVE THIS ITEM FIXED. *TR

THE FRONT AIRBAG SENSOR HAS FAILED AND THE AIRBAGS ARE NO LONGER OPERABLE. THIS APPEARS TO BE AN ISSUE WITH THE YEAR AND MODEL OF CHEVY TRUCK. THIS SHOULD BE A RECALL ITEM DUE TO ITS IMPACT ON SAFETY. GIVEN THE LOW MILEAGE THERE IS NO LEGITIMATE REASON FOR THIS PART TO FAIL. *TR

2005 CHEVROLET SUBURBAN. CONSUMER WRITES IN REGARDS TO VEHICLE ODOMETER PROBLEMS. *SMD THE CONSUMER BEGAN HAVING PROBLEMS WITH THE SPEEDOMETER APPROXIMATELY 2 YEARS AGO. INTERMITTENTLY, THE NEEDLE ON THE ODOMETER WOULD CLIMB ABOVE THE ACTUAL SPEED HE WAS TRAVELING, THEN MOVE UP AND DOWN TENS OF MILES ABOVE THE ACTUAL SPEED, AT TIMES, IT WOULD RISE TO 120 AND REMAIN THERE. WHEN HE TURNED THE VEHICLE OFF AND ON AGAIN, IT WORKED FINE, UNTIL THE NEXT TIME. *JP

UNDER ANY CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT CLUSTER DOES NOT ILLUMINATE. WHICH DOES NOT ALLOW THE DRIVER TO KNOW WHICH GEAR THE VEHICLE IS IN. WHICH INCREASES THE DRIVERS CHANCES OF CRASHING. *TR

SPEEDOMETER STAYED AT SPEED I WAS DRIVING WHEN I STOPPED THE CAR. WHEN I RESTARTED THE CAR IT DID NOT RETURN TO ZERO BUT STARTED AT LAST SPEED I WAS DRIVING, THEN INCREASE FROM THERE. SPEEDOMETER FINALLY STAYED AT 100 MPH, IT DID NOT RETURN TO ZERO AND I WAS UNABLE TO DETERMINE SPEED OF CAR WHEN DRIVING. RPM ALSO MALFUNCTION, IT STAYED AT 1.5 WHEN DRIVING AND DIDN'T VARY WHEN I INCREASED OR DECREASED MY SPEED. HAD TO HAVE IT REPLACED AS I COULD NOT DETERMINE SPEED I WAS DRIVING. NO OFFICIAL RECALL, ONLY A CLASS ACTION SUIT. MY MAKE/MODEL/YEAR WAS PART OF THE CARS AFFECTED IN THE SUIT, ONLY I DIDN'T QUALIFY FOR REIMBURSEMENT OF REPAIR BECAUSE THE PROBLEM OCCURRED OUTSIDE OF THE 7 YEAR 80,000 MILE PARAMETER GM SET UP FOR REIMBURSEMENT. *TR

I NOTICED A GASOLINE LEAK IN MY DRIVEWAY COMING FROM UNDER FROM UNDER THE 2005 SUBURBAN. THE LEAK WAS ALMOST IN THE CENTER OF THE VEHICLE. I DROVE THE VEHICLE TO THE DEALERSHIP TO GET THE GASOLINE LEAK REPAIRED. I WAS BILLED $2,230 TO REPAIR THE GASOLINE LEAK. I WAS GIVEN THE FOLLOWING DESCRIPTION ON THE INVOICE. "TESTED FOR FUEL LEAK FOUND SENDING UNIT & ALL FUEL LINES LEAKING ...". I WAS TOLD THAT THE ENTIRE FUEL LINE SYSTEM HAD TO BE REPLACED DUE TO CORROSION ON THE UNDERSIDE OF THE VEHICLE. I GOOGLED THE CORROSION PROBLEM FOR CHEVROLET SUBURBAN'S AND READ SEVERAL INSTANCES OF BRAKES FAILING ON GM VEHICLES DUE TO CORROSION. THE BRAKE FAILURES THAT I READ ABOUT WERE THE RESULT OF CORRODED BRAKE LINES. TO ME THE CORROSION PROBLEM IS A VERY SERIOUS SAFETY ISSUE, ESPECIALLY WHEN YOU COMBINE THE FUEL LINES AND BRAKE LINES INTO THE PROBLEM. I ASKED THE SERVICE TECH ABOUT HOW LONG THE NEW FUEL LINES WOULD LAST. HE TOLD ME ABOUT SIX OR SEVEN YEARS. I ASKED IF THEY USED STAINLESS STEEL FUEL LINES, AND WAS TOLD "NO". SINCE THIS APPEARS TO BE A DESIGN FLAW, I FEEL THAT GENERAL MOTORS SHOULD PUT OUT A NOTICE TO THEIR CUSTOMERS, OR AT THE VERY LEAST HELP WITH THE COST OF THE REPAIRS. HOW CAN I LET MY FAMILY, OR ANYONE ELSE, RIDE IN MY 2005 SUBURBAN WITH ONLY 125,000 MILES AND A CORROSION PROBLEM? WHILE DRIVING ALL I WOULD BE THINKING ABOUT IS THAT THE BRAKES COULD FAIL AT ANY MOMENT, OR SOMETHING WOULD FALL OFF THE VEHICLE DUE TO THE CORROSION PROBLEM. IT'S TIME FOR GENERAL MOTORS TO STEP UP AND TAKE RESPONSIBILITY FOR THE CORROSION PROBLEM. *TR

CATASTROPHIC BRAKE FAILURE, WITHOUT ANY WARNING , CAUSED BY COMPLETE CORROSION OF ENTIRE BRAKE LINE! RAN CAR OFF ROAD TO AVOID CARS AT STOP. EMERGENCY BRAKE ALSO FAILED DUE TO CORROSION. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET K1500 SUBURBAN. THE CONTACT STATED THAT THE SPARE TIRE CARRIER ON THE VEHICLE WOULD NOT LATCH OR DETACH PROPERLY. THE VEHICLE WAS NOT INSPECTED, DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 91,175.

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN EQUIPPED WITH FEDERAL COURGIA M/T 33 TIRES (N/A), SIZE:12.50/R20. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE TREAD BECAME SEPARATED FROM THE REAR DRIVER'S SIDE TIRE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO A TIRE SHOP WHERE THE TECHNICIAN REPLACED ALL FOUR TIRES. THE CONTACT EMAILED THE MANUFACTURER BUT HAD NOT RECEIVED A RESPONSE. THE FAILURE MILEAGE OF THE TIRE WAS 7,800. THE VEHICLE FAILURE MILEAGE WAS 139,000. THE DOT NUMBER WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE AIR BAG WARNING LAMP ILLUMINATED. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND THE AIR BAG SENSOR WAS REPLACED HOWEVER, THE FAILURE LATER RECURRED. THE VEHICLE WAS NOT FURTHER REPAIRED AND MANUFACTURER WAS NOT MADE AWARD OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 75000.

LIFT GATE WILL NOT OPEN. DANGER OF ACCIDENT AND NOT BEING ABLE TO ESCAPE FROM THE REAR OF THE VEHICLE AND CANNOT MANUALLY OPEN. *TR

UNIROYAL LIBERATOR . THE TREAD SEPARATION OCCURRED ABOUT 11AM ON SATURDAY JULY 15, 2013 ON EAST BOUND I-10 JUST EAST OF OZONA, TEXAS. SPEED WAS ~79 MPH AS PART OF A BOY SCOUT CONVOY RETURNING FROM A HIGH ADVENTURE OUTING. VEHICLE WAS A 2005 K2500 SUBURBAN, LIGHTLY LOADED WITH MYSELF, 4 SCOUTS AND TWO BACK PACKS. WEATHER WAS OVERCAST AND 76 DEGREES F. NOT TOWING. TIRE PRESSURE WAS CHECKED AT 80 PSI BEFORE THE TRIP STARTED AND THE TIRE CASING WAS STILL INFLATED WHEN REMOVED TO PUT ON THE SPARE. *TR

WHEN YOU APPLY THE BRAKES SOMETIMES THEY SEEM TO LOCK UP THEN SOME TIMES THE BROKE PEDDLE FAILS TO BE JUMPY SOUND LIKE A AIR BOOSTER FROM UNDER THE DASH BOARD THE CAR HAS NEW BRAKE DISC AND ROTORS. *TR

BRAKE LINES HAVE CORRODED AND YESTERDAY ONE OF THE LINES BELOW THE DRIVER'S SIDE DOOR RUPTURED RESULTING IN A COMPLETE LOSS OF BRAKING. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE GLASS WINDOW DETACHED FROM THE REAR LIFT GATE HYDRAULIC HINGES CAUSING IT TO HANG LOOSELY. THE CONTACT MENTIONED THAT HE HAD TO COMPLETELY REMOVE THE GLASS FROM THE REAR LIFT GATE TO PREVENT IT FROM BREAKING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN VERIFIED THE FAILURE AND STATED THAT THE GLASS NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 94,000.

TOTAL BRAKE FAILURE DUE TO STEEL LINE CORROSION OR RUST. *TR

HAD TO REPLACE THE SENSOR FOR THE AIR BAG. THIS SHOULD HAVE BEEN COVERED BY GENERAL MOTORS. I KNOW THAT A LOT OF PEOPLE WOULD NOT HAVE THIS PROBLEM FIXED DUE TO THE COST. WHEN THE SERVICE AIR BAG LIGHT COMES ON IT DEACTIVATES THE AIR BAGS. THIS IS A MAJOR SAFETY ISSUE. WE HAVE A 2000 CHEVROLET TAHOE IN OUT FAMILY THAT HAS NOT HAD THIS PROBLEM. I FEEL THERE NEEDS TO BE A RECALL. *TR

LOSS OF BRAKES DUE TO SUDDEN LOSS OF BRAKE FLUID FROM RUSTED MAIN LINE OFF OF MASTER CYLINDER. *TR

AT APPROXIMATELY 4 YEARS AND 45,000 MILES AFTER PURCHASE OF MY 2005 SUBURBAN, THE TACHOMETER BEGAN FAILING WITH INTERMITTENT LOW READINGS OR NO READING. SINCE THE VEHICLE WAS OUT OF WARRANTY AND THE TACHOMETER ISN'T REALLY VERY USEFUL FOR AN AUTOMATIC TRANSMISSION VEHICLE, I WAS NOT OVERLY CONCERNED AND I DID NOT BRING THE VEHICLE IN FOR REPAIR DUE TO THE ANTICIPATED HIGH EXPENSE. SHORTLY AFTER THE TACHOMETER FAILURE (ABOUT 55,000 MILES) THE GAS GAUGE BEGAN FAILING WITH ERRATIC READINGS. ULTIMATELY THE BEHAVIOR DEGRADED TO A PEGGED COUNTER CLOCKWISE CONDITION WHERE THE READING NOW STAYS AT ALL TIMES. ALTHOUGH INCONVENIENT, THE 'MILES TO EMPTY' INFORMATION DISPLAY SEEMED TO CONTINUE TO WORK NORMALLY AND I DECIDED I COULD USE THAT METHOD INSTEAD OF HAVING A REPAIR PERFORMED. I'VE BEEN USING THAT METHOD EVER SINCE WITHOUT ANY ISSUES, BUT I TEND TO BE CONSERVATIVE AND FILL UP BEFORE I COME CLOSE TO BEING EMPTY. WITHIN THE NEXT SIX MONTHS AFTER THE GAS GAUGE FAILED (ABOUT 60,000 MILES), THE VOLT METER BEGAN GIVING ERRONEOUSLY HIGH READINGS OF ABOUT 20 VOLTS. IT WAS A PRETTY RARE EVENT. WHEN IT SHOWED THIS OVER VOLTAGE CONDITION, I CHECKED THE CHARGING VOLTAGE AT SEVERAL LOCATIONS AND FOUND THE VOLTAGE TO BE NORMAL. WHEN I DETERMINED THAT THERE WASN'T AN ACTUAL OVER-VOLTAGE CONDITION, I WASN'T TOO CONCERNED ABOUT THIS INFREQUENT ISSUE. SEVERAL MONTHS AFTER THE GAS GAUGE FAILURE, THE SPEEDOMETER BEGAN FAILING WITH LOW OR NO READINGS. IT STARTED OUT TO BE A VERY RARE OCCURRENCE. THE ISSUE NOW SEEMS TO BE OCCURRING WITH GREATER FREQUENCY. THE INCREASED FAILURE RATE CONCERNS ME SINCE IT CAN RESULT IN A SAFETY HAZARD AS WELL AS COULD RESULT IN A COSTLY SPEEDING TICKET. I WAS NOT NOTIFIED OF ANY OF THE GM CAMPAIGNS FOR THIS ISSUE ON THE SAME MODEL VEHICLE ON DIFFERENT VINS. GM'S POSITION IS ANY REPAIR WILL BE AT MY FULL EXPENSE (APPROX $600). *TR

BRAKE AND FUEL LINES ARE CORRODED. I LEARNED YESTERDAY FROM WIN KELLY CHEVROLET IN CLARKSVILLE, MD THAT MY BRAKE LINES ARE SO CORRODED I SHOULD REPLACE THEM IMMEDIATELY. ALSO OBSERVED WERE RUSTY FUEL LINES. I, AND MANY OTHER SUBURBAN/SILVERADO OWNERS APPARENTLY AGREE, THAT THIS IS DESIGN FLAW AND SHOULD BE RESOLVED BY A MANUFACTURE RECALL. THIS WAS MY FIRST GM PRODUCT; ALL OTHERS WERE DODGE. I NEVER HAD THIS ISSUE WITH ANY OF THE 17 OTHER VEHICLES I'VE OWNED OVER THE PAST 34 YEARS. IF THE CORROSION IS THAT BAD I'D LIKE TO KNOW WHY IT WASN'T NOTED IN PREVIOUS "BUMPER TO BUMPER COURTESY INSPECTIONS". *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE LIFTGATE DOOR ACTUATOR FAILED AND THE CONTACT WAS UNABLE TO RELEASE THE DOOR IN AN OPEN POSITION. IN ADDITION, THE VEHICLE WAS NOT DESIGNED WITH A MANUAL LOCK TO ACCESS THE REAR LIFTGATE. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 49,000.

THE AUTO TRANSMISSION 3 AND 4TH GEAR CLUTCH FAILED IN THIS UNIT WHICH RESEARCH SHOWS IS A COMMON FAILURE. WHEN THE TRANSMISSION WAS OPENED FOR THE REPAIR THERE WERE TWO PARTS THAT SHOWED A LOT OF RUST WHICH INDICATED AN EXPOSURE TO WATER. I WOULD NOT BE WRITING THIS IF THE TRANSMISSION SHOP HAD NOT SHOWN ME A CHEVY AVALANCHE TRANSMISSION THEY HAD JUST CAME IN WITH THE SAME PARTS SHOWING THE RUST PATTERN. BOTH TRANSMISSIONS WERE MADE IN THE RAMOS, MEXICO GM FACTORY IN WITHIN A SHORT TIME FRAME. THIS IS MAJOR CONCERN IF THE TRANSMISSION HAD FAILED ON AN INTERSTATE AND THE LOSS OF SPEED COULD HAVE BEEN CATASTROPHIC LIKE AN ACCIDENT LOCALLY IN LOWNDES COUNTY, MS WHERE A CROWN VICTORIA WAS HIT FROM BEHIND WHEN SOMETHING FAILED IN THAT CAR AND SLOWED DOWN. TWO PEOPLE LOST THEIR LIFE. *TR

ATTEMPTED TO LOCK THE VEHICLE USING THE KEY FOB - ALL FOUR DOORS LOCKED - THE REAR HATCH DID NOT - TRIED THE KEY FOB SEVERAL MORE TIMES WITH THE SAME RESULT - OPENED THE DRIVER'S DOOR AND USED THE MANUAL LOCK BUTTON - GOT THE SAME RESULT, THE FOUR DOORS LOCKED BUT NOT THE REAR HATCH - FOR MY 2005 MODEL, AND FOR SEVERAL MODEL YEARS OTHER THAN MY 2005, I READ MANY COMPLAINTS ABOUT THE SAME PROBLEM ON THIS WEBSITE PRIOR TO SENDING THIS - AND MANY COMPLAINTS ABOUT THE OPPOSITE PROBLEM, NAMELY, THE REAR HATCH DOOR LOCKS AND CANNOT BE OPENED - THERE IS NO KEY HOLE IN THE DOOR, ONLY THE KEY FOB OPERATES LOCKING AND UNLOCKING THE DOOR - OBVIOUSLY A DESIGN PROBLEM THAT YOU OUGHT TO ISSUE A RECALL ON - AND, READ MANY, MANY COMPLAINTS ABOUT THE INSTRUMENT CLUSTER OVER MANY MODEL YEARS - AGAIN, OBVIOUSLY A DESIGN PROBLEM - WHY DON'T YOU FOLKS MAKE GM FIX THESE FAULTS ? - THEY ARE NOT FEW IN NUMBER - THEY ARE NOT ISOLATED - THEY CERTAINLY ARE NOT OWNER GENERATED - MAKE GM FIX THEM - ISN'T THAT YOUR JOB? THANKS FOR YOUR HELP AND GOOD LUCK, WAITING TO SEE IN ALABAMA *TR

STARTED ENGINE, DEPRESSED BRAKE PEDAL TO SHIFT INTO REVERSE. BRAKE PEDAL GOES TO FLOOR WITH NO PRESSURE, BRAKE AND STABILITY WARNING LIGHT GO ON. I BACK UP, THEN GO INTO DRIVE, TRAVEL ABOUT 50 FEET, APPLY PRESSURE ON BRAKE PEDAL AND AGAIN NO PRESSURE ON PEDAL, SUBURBAN SLOWLY STOPS FORWARD MOVEMENT ON LEVEL SURFACE. I RETURN SUBURBAN TO PARKING AREA AND TURN OFF ENGINE, CALL SERVICE SHOP AND MAKE APPOINTMENT FOR REPAIR. NEXT WEEK, 4/22 SLOWLY DRIVE SUBURBAN 1 MILE TO REPAIR FACILITY FOR SERVICE. 4/23 REPAIR MANAGER CALLS TO TELL ME THAT ALL THE BRAKE LINES ARE EXCESSIVELY RUSTED. *TR

THE REAR WINDOW IN THE REAR LIFT DOOR HAS DELAMINATED AND CRACKED AT THE PASSENGER SIDE OF THE WINDOW CAUSING THE WINDOW SHIFT. I CALLED GENERAL MOTORS ON 3/26/13 AT 4PM AND TALKED TO A PHONE REP. THE CASE #[XXX]WAS GIVEN TO ME BY REP. [XXX]@ 866-790-5600 EXT.[XXX]. I WAS ADVISED TO GO TO THE CHRONIC CHEV. DEALER IN GRIFFIN GA. WHERE I PURCHASED THE VEHICLE SO THEY COULD SEE THE SITUATION. THE AREA DIST. MANAGER WAS CALLED. BOTTOM LINE, I WAS TOLD THAT THEY COULD DO NOTHING AS IT WAS DUE TO "AGE, WEAR AND TEAR". THE DEALER SAID IT WOULD COST $862.00 & $200.00 TO INSTALL. THEY ALSO SUGGESTED I COULD CALL SAFELITE AUTO AND THEY WOULD INSTALL AN AFTER MARKET GLASS FOR $462.90, PARTS & LABOR. I HAVE SEEN MANY COMPLAINTS ONLINE REGARDING THIS ISSUE AND GENERAL MOTORS WILL DO NOTHING. I DID SEE THE NEW SUBURBAN AND SEEN CHANGES IN THE WAY THE WINDOW IS MOUNTED. SOMETHING NEED TO BE DONE! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

GAS SMELL WHEN IDLING....TOOK TO DEALER AND THEY FOUND THE (FLEXIBLE) FUEL LINE LEAKING. THEY SHOWED ME THE PROBLEM AND IT SURE LOOKED LIKE THE LINES WERE CROSSED WHEN THEY WERE INSTALLED, EVEN THE MECHANIC SAID SOMETHING TO THAT NATURE, BUT I WILL GUARANTEE YOU HE WOULD NEVER ADMIT THAT......IT IS GOING TO COST ME $651.00 TO HAVE JUST ONE LINE REPLACED............THE LINE WORE A HOLE THRU IT WHERE THE LINES WERE CROSSED AND RUBBING ON EACH OTHER. *TR

I WAS DRIVING ON A TRIP TO FLORIDA WHEN AT 65 MPH MY SPEEDOMETER KEPT INCREASING AND PEGGED OUT AT THE 120 MPH MARK. I PULLED OVER TO TRY AND RESOLVE THE ISSUE BUT TO NO AVAIL IT STAYED STUCK AT THE 120 MPH MARK. WHEN I RESTARTED THE VEHICLE ALL MY CLUSTER GAUGES WERE PEGGED OUT: OIL, BATTERY, TEMP, AND EVEN GAS GAUGE. I ALSO STARTED GETTING INFO THAT MY AIRBAG SYSTEM NEEDED ATTENTION. FOUR WHEEL DRIVE LIGHT CAME ON JUST A DIFFERENT ARRAY OF MALFUNCTIONS CAME FLYING ACROSS MY DISPLAY. TO THIS DATE MY BATTERY GAUGE IS STILL PEGGED OUT MY AIRBAG LIGHT IS ON, SERVICE FOUR WHEEL DRIVE LIGHT STILL FLASHES INADVERTENTLY AND NOW MY DRIVERS SIDE HEATER AND CONTROLS ARE NOT WORKING CORRECTLY. BROUGHT IN TO REPAIR SHOP & THEY SAID NO RECALL HAS BEEN ISSUED SO MY COST WOULD RUN WELL OVER $1500.00. RIDICULOUS. OWN UP CHEVY FIX THIS. *TR

MY SPEEDOMETER RECENTLY STARTED MALFUNCTIONING. IT READ 20MPH WHEN I WAS DRIVING AT LEAST 50MPH, THEN IT READ 90+MPH WHEN I WAS ACTUALLY DRIVING 30MPH. FINALLY, MY SPEEDOMETER GAVE OUT AND IS "STUCK" IN THE 120+MPH POSITION. THANKFULLY, I HAVE A GPS NAVIGATION SYSTEM THAT HAS A GAUGE ON IT SO I KNOW MY RATE OF SPEED. I CONTACTED GM AND THEY REFUSED TO REMEDY THIS "WIDESPREAD" PROBLEM. THEY SAID THAT MY "SPECIAL COVERAGE" HAS ENDED (REFERRING TO THE 2008 CLASS ACTION SUIT THAT PROMPTED IT). I AM VERY UPSET! I HAVE READ MANY, MANY FORUMS AND FOUND THAT THIS IS A VERY COMMON ISSUE. MY MECHANIC SAYS THEY REPLACE THEM "ALL THE TIME" AND CHARGES $700-$1,000 TO FIX IT. IN MY OPINION, THERE SHOULD BE A RECALL ON THE INSTRUMENT CLUSTER PANEL. I JUST DON'T UNDERSTAND WHY GM WON'T STEP UP AND FIX IT FREE OF CHARGE. *TR

THE DRIVER WAS SITTING AT THE STOP LIGHT FOR APPROXIMATELY ONE MINUTE. BOTH THE DRIVER AND PASSENGER HEARD A REVVING NOISE. THE DRIVER'S RIGHT FOOT REMAINED ON THE BRAKE. SHE NEVER PUT HER FOOT ON THE GAS PEDAL, YET THE VEHICLE ACCELERATED FORWARD INTO THE INTERSECTION. THE SUBURBAN WAS STRUCK ON THE DRIVER'S SIDE BY A TRUCK, SPUN AND WAS HIT AGAIN ON THE FRONT OF THE VEHICLE. THE DRIVER SITTING AT THE LIGHT BEHIND OUR SUBURBAN AGREED THAT OUR CAR WAS AT A COMPLETE STOP WHEN IT SUDDENLY WENT INTO THE INTERSECTION. THE SUBURBAN WAS DEEMED TOTALED BY OUR INSURANCE COMPANY. *TR

OUR SPEEDOMETER JUST ALL OF A SUDDEN STOPPED WORKING,FROM TIME TO TIME IT LOOKS LIKE IT IS WORKING BUT IT IS NOT GOING THE SPEED THAT IT SAYS. SINCE THIS STARTED OUR OIL GAUGE,AND NOW FUEL GAUGE HAS STOPPED WORKING. *TR

ELECTRICAL CLUSTER SPEEDOMETER WENT HAYWIRE THEN QUIT ODOMETER DID THE SAME. *TR

ON AUGUST 3RD, 2012 MY 2005 CHEVROLET SUBURBAN 1500 FIRST SHOWED SIGNS OF THE INSTRUMENT PANEL CLUSTER FAILING. THE TACHOMETER SHOWED A READING OF 5,000 RPMS WITH THE ENGINE IDLING. THIS CONTINUED FOR A FEW DAYS AND THEN SEEMED TO GO BACK TO NORMAL. ABOUT A WEEK LATER THE SPEEDOMETER BEGAN TO INDICATE INCORRECT READINGS. BY SEPTEMBER 6TH, 2012 I HAD NOTICED IT WOULD SOMETIMES SHOW A SPEED OF 120 MPH WHILE GOING AN ACTUAL SPEED 50 MPH OR SOMETIMES SHOW 29 MPH WHILE GOING 50 MPH. FOR A WHILE IT WAS MOVING THE NEEDLE BELOW 0MPH. I CAN NO LONGER RELY ON THE GAUGES OF THIS VEHICLE WITH ONLY 65,000 MILES ON IT. *TR

SPEEDOMETER VERY ERRATIC, SHOWS EXCESSIVE SPEEDS (120MPH) OR DOESN'T REGISTER CORRECT SPEED AT ALL. CALLED DEALER NUMEROUS TIMES ABOUT PROBLEM AND NEVER TOLD ABOUT THE TSB ONLY THAT IT WOULD BE OVER $600 TO FIX. DID RESEARCH ONLINE AND FOUND TSB AND CALLED AGAIN. THIS IS A HUGE SAFETY HAZARD AND ONE THAT CHEVROLET SHOULD ADDRESS ACROSS THE BOARD WITH THE VEHICLES AFFECTED BY THIS. THEN WAS TOLD CAN'T FIX IT BECAUSE OF MILEAGE UNLESS I PAY OUT OF POCKET. NOW NEEDLE IS STUCK AT ZERO AND UNFORTUNATELY BEING MILITARY WE DON'T GET PAID ENOUGH TO JUST SHELL OUT $600+ ON A WHIM. SOMEONE NEEDS TO MAKE CHEVROLET TAKE CARE OF THEIR FAULTY PRODUCTS, IF YOU PAY FOR A PREMIUM PRODUCT YOU SHOULD GET ONE. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 2500. THE CONTACT INSPECTED THE VEHICLE AND DETECTED A SHORTAGE WITHIN THE CIRCUITS UNDER THE DRIVER'S SIDE DASHBOARD, WHICH RESULTED IN THE WIRES BECOMING MELTED. THE MANUFACTURER WAS NOTIFIED AND RECOMMENDED THE VEHICLE BE TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 107,000.

MY VEHICLE WAS MANUFACTURED WITH A DEFECTIVE FUEL PUMP. I HAVE HAD NOTHING BUT PROBLEMS WITH THE FUEL GAUGE AND DELAYED STARTS. I CHANGED THE PUMP AND NOTICED THE ORIGINAL PUMP WAS MISSING A SPRING ON ONE OF THE PUSH RODS. THE WEAR AND TEAR MADE THE PUMP HANG. I HAVE THE PUMP AND PHOTOS TO DELIVER. THIS PUMP IS A FLEX FUEL PUMP. THERE ARE SO MANY POSTS ON THIS DELAYED START ISSUE. I HAVE RECENTLY POSTED THE CAUSE OF MY ISSUE. I NOTICED THE DEFECT IMMEDIATELY BECAUSE I PERFORMED THE REPAIR AND NOT THE DEALER. THEY WERE QUICK TO OFFER ME A QUOTE FOR OVER A THOUSAND DOLLARS TO REPLACE A DEFECTIVE PART. *TR

WENT TO MOVE VEHICLE TO ATTACH LANDSCAPE TRAILER. BRAKES WENT DOWN TO THE FLOOR. UPON INVESTIGATION, FOUND BRAKE FLUID ON GROUND FROM DRIVER SIDE RIGHT FRONT. HAD VEHICLE TOWED TO REPAIR STATION AND ASKED MECHANIC TO REPLACE BRAKE LINE AND CHECK ALL OTHER BRAKE LINES. MECHANIC ENDED UP REPLACING 80% OF LINES DUE TO CORROSION. THIS COULD HAVE ENDED UP RESULTING IN AN ACCIDENT IF THE VEHICLE WAS MOVING WITH THE TRAILER ATTACHED CARRYING ATV'S. IN ADDITION, THE CABLE HOLDING THE SPARE TIRE HAD TO BE CUT IN ORDER TO GET ACCESS TO REAR BRAKE LINES. THE CABLE WAS RUSTED MEANING THAT A TIRE COULD NOT BE CHANGED IN THE EVENT OF A FLAT. *TR

EXHAUST MANIFOLD BOLTS BROKEN, TWO AT BACK LEFT, DRIVER'S SIDE CLOSEST TO FIREWALL. CAUSING AUDIBLE EXHAUST LEAK. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE SOCKET AND WIRES FOR THE REAR BRAKE LIGHT WERE MELTED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE CONTACT NOTIFIED A PARTS STORE AND THEY STATED THAT THE PART WAS ON BACK ORDER. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THERE WERE NO RECALLS AND ADVISED THE CONTACT TO CONTINUE LOOKING FOR THE PART. THE FAILURE MILEAGE WAS 190,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE LIFTGATE FAILED. THE CONTACT MENTIONED THAT SHE WAS UNABLE TO OPEN THE LIFTGATE FROM THE INSIDE OR THE OUTSIDE OF THE VEHICLE SINCE IT DID NOT HAVE A KEY ENTRY. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 126,000.

SMELLED GAS IN GARAGE AND MOVED VEHICLE OUTSIDE GARAGE TO INVESTIGATE. FOUND PUDDLE OF GAS ON GARAGE FLOOR WHERE VEHICLE HAD BEEN PARKED. CRAWLED UNDER VEHICLE AND FOUND TWO BRAIDED FUEL LINES CROSSING EACH OTHER AND RESTING ON ONE ANOTHER. THEY HAD WORN A HOLE IN THE BRAIDED FUEL LINE AND WAS LEAKING A SUBSTANTIAL AMOUNT OF FUEL. TOOK TO LOCAL REPAIR SHOP FOR REPAIR. MECHANIC HAD TO CUSTOM REBUILD FUEL LINE TO AVOID CRISS-CROSS ROUTE ORIGINALLY INSTALLED. MECHANIC VERY CONCERNED WITH EXISTING DESIGN - PRESSURIZED BRAIDED FUEL LINE WAS SPEWING FUEL BENEATH VEHICLE. THIS APPEARS TO BE A COMMON PROBLEM AS A QUICK SEARCH ON HTTP://WWW.ABOUTAUTOMOBILE.COM/ UNDER "CONSUMER COMPLAINTS" FINDS QUITE A FEW RELATED INSTANCES WITH BOTH THE 2005 AVALANCHES AND SUBURBANS. REFERENCE COMPLAINT NUMBERS: 10465537, 10402272, 10384217, 10275857, 10417685, 10373464, 10401501. I DIDN'T SEARCH OTHER MODEL YEARS. *TR

HEATING, VENTILATION, AND AIR CONDITIONING BLOWER NOT FULLY FUNCTIONAL ON ALL BLOWER SPEEDS, RUNS CONTINUOUSLY WITH THE IGNITION OFF. DISCHARGES BATTERY WITH IGNITION KEYS REMOVED, AND HAS A BURNING SMELL. *TR

A/C SYSTEM WOULD RANDOMLY BLOW HOT AIR; THEN FAN WOULD RUN WITH IGNITION OFF; THEN FAN SPEEDS WOULD QUIT WORKING; FINALLY BLOWER QUIT ALTOGETHER. GM HAS 2 SERVICE BULLETINS OUT WITH EXACT PROBLEM DESCRIPTION, BUT THEY CLAIM MY VEHICLE NOT COVERED. *JS

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, SHE CRASHED INTO THE REAR OF A TRASH TRUCK. UPON IMPACT, THE AIR BAGS DID NOT DEPLOY. THE DRIVER SUSTAINED INJURIES TO THE LEFT ARM AND LEFT LEG. THE POLICE WERE CONTACTED AND A REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THEY DEEMED THE VEHICLE AS BEING DESTROYED. THE MANUFACTURER WAS CONTACTED AND AFTER DIAGNOSING THE VEHICLE, THEY ADVISED HER THAT THE VEHICLE WAS NOT TRAVELING FAST ENOUGH AT THE TIME OF IMPACT FOR THE AIRBAGS TO DEPLOY. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

CHECK AIR BAG LIGHT IS ON. THIS HAS HAPPENED BEFORE AND AFTER A FEW WEEKS THE LIGHT MAY GO OFF. DEALER COULD NOT FIND A PROBLEM. THERE NEEDS TO BE A RECALL ON THIS. THOUSANDS OF PEOPLE HAVING THE SAME PROBLEM. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING AT HIGHWAY SPEEDS, THE HODO LATCH FAILED AND THE HOOD OPENED, BLOCKING THE VIEW OF THE HIGHWAY. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ASSISTANCE WITH REPAIRS OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 125,000.

I WENT TO WASHINGTON AUTO SHOW TODAY 2/4/2012 AND ONE OF YOUR REP GAVE ME A CARD ABOUT YOUR SERVICE. I CAME HOME AND CHECK OUT YOUR WEBSITE AND FOUND OUT YOU HAVE BEEN RECEIVING COMPLAINTS ABOUT INSTRUMENT PANEL OF CHEVY SUBURBAN. I BOUGHT A 2005 CHEVY SUBURBAN IN MARCH 2005 FROM WIN KELLY CHEVORLET IN CLARKSVILLE, MD. ABOUT MIDDLE OF LAST YEAR I NOTICED THAT MY SPEEDOMETER IS ALWAYS STUCK, RUNNING HIGH THAN THE SPEED I AM DRIVING AND JUST EXACTLY AS BEING DESCRIBED BY OTHER OWNERS OF THESE VEHICLES. WHAT IS THE DEPARTMENT DOING TO HELP WITH THIS MANUFACTURER'S DEFECT AND HAVE IT CORRECTED RATHER THAN WE CONSUMERS BEING SADDLED WITH UNEXPECTED REPAIR COST? *KB

I HAVE A CHEVY SUBURBAN 2005 MY SPEEDOMETER HAS STOPPED WORKING. I ALSO HAVE A 2005 DURAMAX THAT THIS HAS HAPPENED TO. I WOULD LIKE TO SEE A FULL BLOWN RECALL PLACED ON ALL GMC/CHEVY VEHICLES. APPARENTLY THESE ARE HUNDREDS OF THOUSANDS PEOPLE WITH THIS ISSUE ACROSS THE U.S./ WORLD ACCORDING TO FORUMS I HAVE BEEN ON. WHILE THERE IS A CLASS ACTION LAWSUIT OUT THERE FOR A VERY LIMITED GROUP OF GMC VEHICLES, MAKING LAWYERS RICH. INSTEAD OF TAKING CARE OF THE PEOPLE WHOM MAKE THIS WORLD ACTUALLY RUN. THIS ISSUE NEEDS TO SERIOUSLY LOOKED INTO. MY NEXT STEP IS TO GET THE MEDIA INVOLVED SHOWING HOW AGAIN THE AVERAGE CONSUMER CAN GET SCREWED BY THE BIG COMPANIES. I AM NOT KEEPING MY MOUTH SHUT ABOUT THIS. THANK YOU *TR

THE HINGE ON THE REAR HATCH GLASS CAME UNBONDED FROM THE GLASS. THIS CAN PROBABLY CAUSE GLASS MOVEMENT AND SHATTERING AT HIGHWAY SPEEDS. *TT

THE SPEEDOMETER READS ERRONEOUSLY HIGH AND OFTEN EXCEEDS 100 MPH READINGS WHILE MY GPS READS AT 70MPH. THERE IS NO TIME AT WHICH INDICATED SPEED READINGS CAN BE TRUSTED. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN.THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH AND NOTICED THE SPEEDOMETER, FUEL AND OIL GAUGES FAILED TO OPERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 69,000.

THE LIFT GATE LOCK ACTUATOR ON MY 2005 CHEVROLET SUBURBAN HAS FAILED. IT HAS NO MEANS OF MANUAL OPERATION CREATING A SAFETY ISSUE CONCERNING EMERGENCY EXITING OF THE VEHICLE FROM THE REAR, SUCH AS FRONTAL IMPACT OR FIRE. *TT

GAS LEAKED FROM FUEL LINES WHICH WERE CROSSED WHEN VEHICLE WAS BUILT AS RESULT RUBBING OCCURRED AND LINES RUPTURED CAUSING FUEL TO LEAK OUT. WENT TO DEALER FIRST TIME THIS HAPPENED AND WOULDN'T ADMIT THIS IS WHY THE LEAK HAPPENED ORIGINALLY. HUSBAND HAS PATCHED A FEW TIMES NOW WHILE WE WAIT FOR NEW GAS LINES TO COME FROM GM BECAUS WE REFUSE TO GO TO DEALER AND USE OUR OWN GARAGE. HOPE NEW LAW GOES INTO EFFECT REGARDING THAT AS WELL. VERY DISSATISFIED AND IT LOOKS LIKE THERE WAS ANOTHER COMPLAINT ABOUT THIS. WILL NOT BUY CHEVY EVER AGAIN. TT

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THE REAR LIFTGATE POWER LOCK MECHANISM BECAME INOPERABLE AND PREVENTED AN OCCUPANT FROM ENTERING OR EXITING FROM THE REAR. THE VEHICLE WAS NOT DESIGNED WITH A MANUAL KEY LOCK FEATURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 70,000. THE VIN WAS UNAVAILABLE.

INSTRUMENT PANEL - CLUSTER DEVICE -- PANEL/ SPEEDOMETER WENT DEAD. GM SERVICE DEALER TOLD US, " THE ENTIRE TRUCK COULD DIE AND STOP WORKING AS A RESULT. " *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. WHILE THE CONTACT WAS DRIVING SHE SMELLED FUEL. WHEN SHE REACHED HER DESTINATION, SHE NOTICED THAT FUEL WAS SPILLING OUTSIDE THE VEHICLE ONTO THE GROUND. THIRTY SECONDS AFTER TURNING THE VEHICLE OFF, THE FUEL STOPPED LEAKING. THE VEHICLE WAS TAKEN TO TWO REPAIRS SHOPS WHERE THE CONTACT WAS INFORMED THAT THE FUEL PRESSURE LINE FROM THE TANK TO THE CROSSOVER AND THE MOTOR HAD RUBBED TOGETHER WHICH CAUSED THE FAILURE TO OCCUR. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED HER TO REPORT THE PROBLEM TO NHTSA. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 140,000.

1. THE REAR LIFTGATE WAS PERIODICALLY STICKING IN THE LOCKED POSITION EVEN WHEN UNLOCKING THE CAR WITH THE KEY FOB OR THE LOCK/UNLOCK BUTTONS. 2. THE REAR LIFTGATE IS NOW STUCK PERMANENTLY IN THE LOCKED POSITION MAKING IT DIFFICULT TO LOAD/UNLOAD THE REAR AREA OF THE CAR. THIS IS ALSO A SAFETY ISSUE AS REAR PASSENGERS MAY BECOME TRAPPED IN THE EVENT OF AN ACCIDENT, SINCE THERE IS NO MANUAL UNLOCKING MECHANISM FOR THE REAR LIFT GATE. 3. NO CORRECTIVE ACTION HAS BEEN TAKEN YET. *TR

AS HAS BEEN REPORTED BY MANY OTHERS, IT APPEARS THAT CHEVROLET'S PROBLEMS REGARDING THE INSTRUMENT CLUSTER IN THEIR LIGHT TRUCKS EXTEND BEYOND THE 2003 AND 2004 MODEL YEARS FOR WHICH THEY WERE "OFFERING" TO EXTEND THE WARRANTY TO 70,000 MILES. THE SPEEDOMETER IN OUR SUBURBAN ALSO BEGAN READING ERRATICALLY ABOUT A MONTH AGO AND HAS NOW PEGGED ITSELF AND IS STUCK AT 120 MPH. FORTUNATELY WE DID NOT HAVE ANY INCIDENTS WHEN THE SPEEDOMETER FAILED. HOWEVER, I BELIEVE CHEVROLET MAY HAVE A CONTINUING PROBLEM AND MORE SHOULD BE DONE TO CORRECT THIS VERY IMPORTANT SAFETY COMPONENT. ADDITIONALLY, I WOULD ALSO LIKE TO MENTION THAT WHILE I WAS SEARCHING FOR OTHER INCIDENT REPORTS ON THIS MATTER, I DISCOVERED THAT THE SCOPE OF THIS PROBLEM MAY BE MASKED BY THE FACT THAT IT IS APPLICABLE TO NUMEROUS DIFFERENT MODELS AND YEARS. IT MIGHT BE HELPFUL FOR YOU TO COMPILE THE REPORTS FOR ALL MODELS OF THE SUBURBAN, YUKON AND SILVERADO TRUCKS AND THEIR GMC CLONES FOR THE 2003 TO 2005 OR 2006 MODEL YEARS. I BELIEVE THAT IF YOU COMBINE THESE DIFFERENT MODELS, YOU WILL SEE THAT THE SCOPE OF THIS PROBLEM IS QUITE LARGER THAN IT MIGHT APPEAR FOR EACH OF THESE MODELS SEPARATELY.

2005 CHEVY SUBURBAN ODOMETER IS FAULTY. IT STOP WORKING PROPERLY ON MY CHEVY TRUCK. IT OVERSHOOT THE SPEED ALL THE WAY TO MORE THAN 120MILES/HR WHEN I DO NOT GO OVER 30MILES/HR. GM NEEDS TO TAKE OWNERSHIP OF IT. NEEDS TO HAVE RECALL. IT IS SAFETY OF GENERAL PUBLIC. PLEASE FORCE THEM TO RECALL FOR THE ODOMETER. *TR

2005 CHEVROLET SUBURBAN. FAILURE OF THE ABS / TRACTION CONTROL COMPUTER (GM PART NO.15234605). FAILURE OCCURRED AT 62,000 MILES DUE TO CORROSION INSIDE THE MODULE. *TR

2005 CHEVROLET SUBURBAN STEERING GEAR FAILURE X5. THE STEERING GEAR AND INTERMEDIATE DRIVE SHAFT HAS FAILED 5 TIMES SINCE 2006. VEHICLE HAS 85K MILES ON IT. *LN

EXHAUST MANIFOLD BOLT HEAD BROKE OFF. 1ST BOLT INITIALLY THEN SECOND BOLT NEXT TO IT BROKE AS WELL. NO WORK HAS BEEN DONE TO MOTOR OR AFTERMARKET PARTS ADDED THAT WOULD AFFECT THIS PART AND CREATE FAILURE. EXHAUST GAS ENTERS THE UNDERHOOD AREA . THE EXHAUST MAKES A BLACK PLUME UP SIDE OF MOTOR. CONCERNED THAT THE LEAK COULD WORSEN LEADING TO EXHAUST FUMES ENTERING PASSENGER COMPARTMENT. I DO NOT KNOW IF THE ESCAPING HOT EXHAUST GAS COULD LEAD TO FIRE. IN ADDITION, I WOULD THINK THE EPA WOULD BE CONCERNED ABOUT EFFECTS ON VEHICLE EMISSIONS. THE LEAKING EXHAUST GAS IS NOT PASSED THROUGH THE CATALYTIC CONVERTER. THE LEAKING GAS IS ALSO NOT SAMPLED BY THE OXYGEN SENSOR AND COULD EFFECT THE SENSORS INPUT TO THE VEHICLE COMPUTER. I SEE BY DOING SIMPLE INTERNET SEARCHES ON THIS TOPIC THAT THE BOLT FAILURE AND LEAKING EXHAUST MANIFOLD PROBLEM IS WIDESPREAD. I HAVE NOT REPAIRED THE BROKEN BOLTS YET. *TR

2005 CHEVY SURBURBAN SPEEDOMETER (55,549 MILES) IS NOT WORKING PROPERLY. SPEED VARIES WHEN CAR IS IN USE MAKING IT UNSAFE TO DRIVE. I DON'T KNOW WHAT THE ACTUAL SPEED IS AT TIMES/AND SOMETIMES THE SPEED DROPS TO ZERO AND STAYS IN THIS SETTING. *LN

SPEEDOMETER STOPPED WORKING ON OUR 2005 CHEVY SUBURBAN. STARTED OUT GOING FROM 20 TO 100 AND NOT REGISTERING THE PROPER SPEED. NOW IS STUCK AT 120 MPH. COST RANGES FROM 300 TO 1000 DOLLARS TO FIX. HAVING TO USE GPS FOR SPEED WHICH IS A DISTRACTION AND SAFETY CONCERN. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHEN SHE WALKED AROUND THE VEHICLE HE SMELLED GASOLINE AND COULDN'T TELL WHERE IT WAS COMING FROM, BUT NOTICED THAT THERE WAS A LEAK UNDERNEATH THE VEHICLE. THE VEHICLE WAS INSPECTED BY A DEALER WHO INFORMED THE CONTACT THAT THE ODOR CAME FROM A FRACTURE IN THE FUEL LINES. THE MECHANIC ADVISED THE CONTACT TO LEAVE HIS VEHICLE BECAUSE DRIVING THE VEHICLE WAS CAUSING THE FUEL LINES TO RUB TOGETHER. THE FUEL LINES WERE REPAIRED FROM THE FRONT AND REAR OF THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. UPDATED 5/2/11 *CN UPDATED 05/16/11

MY 2005 CHEVROLET SUBURBAN HAS 79,985 MILES AND THIS WEEK WHILE DRIVING ROUTE 95 (70 MPH HIGHWAY IN THE SOUTH) FROM NEW JERSEY TO SOUTH CAROLINA MY SPEEDOMETER STARTED SHOWING A MUCH HIGHER SPEED THEN I WAS TRAVELING. I WAS USING MY GPS AT THE TIME AND IT SAID I WAS DOING 69 MPH WHILE MY GAUGE SHOWED A CONSTANT CLIMB TILL IT REACHED 120 MPH AND FLAT LINED BEYOND THAT POINT. THIS WAS A 1600 MILE ROUND TRIP AND IF I HAD NOT HAD MY GPS WITH ME I WOULD NOT KNOW HOW FAST OR SLOW I WAS GOING. I WAS WAITING FOR SOMETHING ELSE TO GO WRONG. WHILE IN SOUTH CAROLINA I WENT TO RECALLS ON THE INTERNET WITH 2005 GM SUV'S AND FOUND A WHOLE BUNCH OF SIMILAR COMPLAINTS, YET GM (CHEVROLET) HAS NOT DONE ANYTHING THAT I COULD FIND. I RETURNED HOME TODAY AND CALLED MY LOCAL CHEVROLET DEALER AND EXPLAINED TO THE SERVICE DEPARTMENT WHAT HAD HAPPENED AND THEY SAID THEY NEVER HEARD OF THIS AND GAVE ME AN APPOINTMENT FOR NEXT MONDAY 1/3/2011 TO BRING IN THE SUV. SINCE THIS CAR IS OUT OF SERVICE I AM HOLDING MY BREATH AS TO WHAT THE BILL COULD BE. THIS IS A VERY DANGEROUS THING, I COULD BE NOT LOOKING AT THE GAUGE AND BE RUNNING RIGHT INTO A HIGH SPEED ERROR AND PUTTING MY FAMILY IN HARMS WAY. CAN ANYONE HELP? *TR

AT 99K MILES THE SPEEDOMETER STARTED ACTING ERRATIC. THERE ARE TIMES IT IS CORRECT AND TIMES WHEN IT READS 5 TO 25 MILES MORE THAN MY TRAVELING SPEED. IT IS DEFINITELY HIT OR MISS AS TO WHEN THIS WILL OCCUR. NOW THE OIL PRESSURE GAUGE AND THE RPM GAUGE ARE ACTING FAULTY AS WELL. I HAVE NOT TAKEN ANY MEASURES TO CORRECT THE SPEEDOMETER BUT IT WILL RESET ITSELF AFTER SEVERAL TIMES OF TURNING THE CAR ON AN OFF. THIS IS DEFINITELY A SAFETY HAZARD WHEN THE SPEEDOMETER READS ERRANTLY WHILE DRIVING ON THE INTERSTATE. *TR

SPEEDOMETER ON OUR 2005 SURBURBAN HAS BEEN MALFUNCTIONING LIKE ALL OTHERS REPORTED ON THIS SITE - OURS FOR WELL OVER TWO YEARS: SOMETIMES READS ZERO WHEN DRIVING AT HIGHWAY SPEEDS, OTHER TIMES IS TACKED AT OVER 120 MPH. WE CAN BE AT A STOP AND IT READS 90. AFRAID TO USE CRUISE CONTROL - WHO KNOWS WHAT WILL HAPPEN! WAITING FOR NHTSA TO DEMAND A RECALL THESE VEHICLES: WHAT WILL IT TAKE? SOMEONE DYING BECAUSE THEY HYDROPLANE, OR ROLL, OR REAR END SOMEONE BECAUSE THEY HAVE NO CLUE HOW FAST THEY ARE GOING? *TR

WHILE DRIVING THE SPEEDOMETER JUMPED TO 20 MPH AND NEVER DROPPED BACK DOWN. *TR

WE OWN A 2005 CHEVY SUBURBAN, AND THE SPEEDOMETER BEGAN TO JUMP AROUND AND ACT ERRATICALLY. IT NOW SHOWS ABOUT 60 MPH, EVEN THOUGH THE VEHICLE IS AT A STOP. GOES UP ABOVE 120 MPH WHILE DRIVING THROUGH TOWN. WE CALLED THE DEALERSHIP, AND JUST LIKE OTHERS REPORTED, WAS TOLD WE WERE GOING TO BE TAKEN FOR OVER $600 FOR A REPAIR THAT IS OCCURRING IN VIRTUALLY EVERY 2005 GM TRUCK (ALONG WITH OTHER YEARS). WE CAN NO LONGER TELL WHAT SPEED WE ARE DRIVING, WHICH IS A SERIOUS SAFETY HAZARD, ESPECIALLY FOR MY TEENAGE DRIVERS THAT DRIVE THIS VEHICLE. *TR

2005 CHEVY SUBURBAN THE SPEEDOMETER JUST WENT OUT @ 42,600K MILES. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THERE WAS NO KEY SLOT FOR THE REAR HATCH AND NOW THE SWITCH, WHICH WAS ON THE DRIVERS SIDE WILL NOT OPEN THE VEHICLE. THE CONTACT WAS UNABLE TO OPEN THE WINDOW ON THE REAR HATCH AS WELL. THE DEALER STATED IT WAS NOT UNDER WARRANTY, BUT THE MODULE THAT CONTROLS THE REAR HATCH AND WINDOW HAD FAILED. THE FAILURE MILEAGE WAS 60000 AND THE CURRENT MILEAGE WAS 61000.

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. THE CONTACT STATED HE NOTICED WHILE DRIVING 30 TO 40 MPH THAT THE SPEEDOMETER READ 120 MPH, AND WHEN DRIVING 70MPH THE SPEEDOMETER READ 0 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED. THE DEALER ADVISED THE CONTACT THAT THE INSTRUMENTAL CLUSTER PANEL FAILED. THE MANUFACTURER ADVISED THAT BECAUSE THE VEHICLE WAS OVER THE EXTENDED WARRANTY COVERAGE, THEY WOULD NOT ASSIST WITH THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 68,000 AND THE CURRENT MILEAGE WAS 69,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH WHEN THE BRAKES LOCKED AND THE VEHICLE WOULD ONLY ACCELERATE AT A VERY LOW SPEED. THE CONTACT CONTINUED TO DRIVE AT A LOW SPEED UNTIL SHE HEARD A LOUD BANG AND THE VEHICLE SUDDENLY BEGAN TO PICK UP SPEED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT REPAIRED NOR WAS THE VEHICLE INSPECTED FOR THE FAILURE. ON A LATER DATE WHILE DRIVING 45 MPH, SHE APPLIED PRESSURE TO THE BRAKE PEDAL AND THE PEDAL ABNORMALLY DEPRESSED INTO THE FLOORBOARD. THE BRAKES DID NOT RESPOND AND THE CONTACT SHIFTED THE VEHICLE INTO NEUTRAL AND COASTED TO A STOP. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE BRAKE DISCS HAD FAILED. THE VEHICLE WAS REPAIRED. SHE ALSO STATED THAT THE SPEEDOMETER WAS INOPERABLE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS UNKNOWN.

ONE WEEK AGO I WAS DRIVING TO MY BACK ABOUT 6 TO 7 MILES AND MY BRAKES WENT OUT. I WAS SO SCARED I ALMOST DIED IT WAS A HEAVY TRAFFIC AREA. THIS TIME IT WAS MY FRONT ROTOR CRACKED RIGHT IN HALF. I SEE A BIG PROBLEM WITH THIS ESPECIALLY WHEN THE CAR IS ONLY 5 YEARS OLD. I HAVE ASKED AROUND AND NOBODY HAS EVER SEEN OR HEARD OF SUCH A THING. THIS IS CRAZY AND I TAKE MY KIDS IN THIS CAR. *TR

I WAS DRIVING WITH MY TWO YOUNG CHILDREN IN THE CAR AND MY CAR MADE A CLICKING SOUND AND THEN BEGIN TO SHAKE AND VIBRATE. THEN ALL OF A SUDDEN IT MADE A REALLY LOUD NOISE THAT SOUNDED LIKE THE BOTTOM OF THE CAR FELL ONTO THE ROAD AND WAS BEING DRAGGED ALONG AND THE IT WOULD NOT GO ANYMORE. I TRIED PUTTING IT IN PARK AND IT WOULD NOT STOP, IT ROLLED BACKWARDS UNTIL I PUT THE EMERGENCY BRAKE ON AND TURNED IT OFF. I HAD IT TOWED TO MECHANIC WHO INFORMED ME THE DRIVE SHAFT BROKE IN TWO. IT WAS A VERY SCARY INCIDENT WITH MY TWO SMALL CHILDREN IN THE CAR. THEY WERE CRYING INCONSOLABLY AND SCARED. I WOULD LIKE TO KNOW WHY THIS HAPPENED AND IF THERE IS SOME KIND OF DEFECT IN THE 2005 CHEVY SUBURBAN THAT CAUSED THIS. *TR

SPEEDOMETER NOT WORKING PROPERLY, EVEN WHEN THE CAR IS STOP IT SHOW 70 MPH. *TR

SPEEDOMETER FOR CHEVROLET SUBURBAN 2005 NO WORKING PROPERLY, EVEN WHEN THE CAR IS STOP THE SPEEDOMETER SHOW 70 MPH. *TR

2005 CHEVY SUBURBAN SPEEDOMETER FAILURE. WHILE DRIVING HIGHWAY SPEED SPEEDOMETER STOPPED INDICATING CORRECT SPEED, INDICATED 120 MILES PER HOUR. SPEEDOMETER IS NOT WORKING AT ALL. *TR

THIS IS A PREVENTATIVE COMPLAINT ABOUT A 2005 CHEVY SUBURBAN REAR GLASS HINGE. SINCE FINDING OURS BROKEN FOR NO APPARENT REASON, WE HAVE FOUND MANY OTHER OWNERS OF SUBURBANS AND TAHOES WITH THE SAME ISSUE, SOME EVEN STATING THE GLASS FLEW OFF INTO THE ROAD. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE REAR LIFT GATE LOCK MECHANISM WOULD NOT OPERATE. THE VEHICLE WAS NEITHER TAKEN TO THE DEALER FOR INSPECTION NOR WAS THE MANUFACTURER CONTACTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 100,000.

I OWN A 2005 CHEVROLET SUBURBAN, THE REAR LIFT GATE HAS A WINDOW THAT IS INCORPORATED INTO THE LIFT GATE AND CAN BE OPENED INDEPENDENTLY THERE ARE PLASTIC HINGES ATTACHING THE GLASS TO THE LIFT GATE AND ONE OF THE TWO HINGES FAILED AND IS BROKEN. I HAVE SEARCHED THE FORUMS ON THIS ISSUE AND IT APPEARS TO BE WIDESPREAD AND CHEVROLET WANTS $1000.00 TO REPLACE THE GLASS WITH THE DEFECTIVE HINGE. *TR

REAR HATCH OF MY 2005 CHEVROLET SUBURBAN FAILED TO OPEN. THERE IS NO DEVICE INSIDE THE VEHICLE TO EFFECT ESCAPE, IF INVOLVED IN A CRASH THAT WOULD AFFECT OPENING OF ANY OF THE FOUR SIDE DOORS, AND QUICK EXIT MANDATORY. I AM A RETIRED JERSEY CITY FIREFIGHTER, AND DID NOT REALIZE THE SAFETY ISSUE. *TR

LIFTGATE DOES NOT HAVE A KEY LOCK ENTRY AND WILL NOT UNLOCK USING THE DRIVER SIDE LOCK/UNLOCK DOOR PANEL OR THE HAND HELD KEY REMOTE THEREFORE I CANNOT OPEN IT AT ALL. IT IS EXTREMELY FRUSTRATING SINCE WE GOT THE SUBURBAN FOR THE SPACE BUT, BESIDES THAT - IN CASE OF AN EMERGENCY THIS COULD BE EXTREMELY DANGEROUS. THERE IS NO MANUAL RELEASE. IF THE FRONT END OF THE CAR WERE DAMAGED AND THE SIDE DOORS WERE UNABLE TO BE OPENED THERE IS NO WAY OF OPENING THE REAR DOOR. I HAVE TWO SMALL CHILDREN AND THIS IS OF GREAT CONCERN TO ME. I GET FLASHES OF A CAR ACCIDENT AND A FIRE WITH MY KIDS TRAPPED INSIDE WITHOUT BEING ABLE TO OPEN THE REAR DOOR FROM OUTSIDE OR INSIDE! I CANNOT BELIEVE THERE IS NO MANUAL SAFETY LEVER! I HAVE SEEN NUMEROUS COMPLAINTS ABOUT THIS ISSUE WITH THE LIFTGATE NOT OPENING ON SEVERAL BLOGS AND WEBSITES. ALL YOU HAVE TO DO IS TYPE IN SUBURBAN REAR LIFTGATE WON'T UNLOCK. PLEASE REVIEW AS I DO FEEL THIS SHOULD BE A RECALL ISSUE BEFORE IT AFFECTS THE SAFETY OF CONSUMERS. *TR

2005 CHEVROLET SUBURBAN. CONSUMER STATES DEFECTIVE SPEEDOMETER. *TGW CONSUMER SENT IN DUPLICATE LETTER ON 3/25/2010. *KB THE CONSUMER STATED THE SPEEDOMETER WAS STUCK AT 120 MPH. THE CONSUMER WAS INFORMED HER VEHICLE WAS NOT A PART OF THE RECALL, AS HER VEHICLE IDENTIFICATION DID NOT FALL WITHIN THE RANGE. THE SECOND PROBLEM WITH THE VEHICLE WAS THE TRANSMISSION. THE CONSUMER STATED THE VEHICLE HAD TO BE TOWED TO THE DEALER, DUE TO THE INTERAL FAILURE OF THE TRANSMISSION. *JB UPDATED 04/12/10.*JB

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. WHILE DRIVING APPROXIMATELY BETWEEN 55-60 MPH, THE SPEEDOMETER DISPLAYED INACCURATE READINGS. WHILE TRAVELING AT ANY GIVEN SPEED THE FAILURE OCCURRED WITHOUT WARNING. THE AUTHORIZED DEALER STATED THAT THE INSTRUMENT CLUSTER REQUIRED REPLACEMENT. THE VEHICLE HAS NOT BEEN REPAIRED AT THIS TIME. THE FAILURE MILEAGE WAS 55,000. THE VIN WAS NOT AVAILABLE. THE CURRENT MILEAGE WAS 56,000. UPDATED 11/16/10. *LJ

ON A HIGHWAY TRIP HOME, THE SPEEDOMETER GOT STUCK AT 73MPH AND STEADILY INCREASED IN SPEED UNTIL IT JUST POINTS DIRECTLY DOWNWARD. IT STAYS FACING DOWNWARD AND DOESN'T MOVE AT ALL NO. THE CHEVY DEALERS ALSO SAY THAT THERE IS A RECALL BUT OUR CARS VIN NUMBER DOESN'T MEET THE RECALL. THEY AGREE CHEVY SHOULD REPAIR THE VEHICLE. WHEN I CONTACTED CHEVY, THEY TOLD ME THE WOULD OFFER NO ASSISTANCE AND TO STOP CONTACTING THEM REGARDING THE PROBLEM. *TR

MY 2005 SUBURBAN CHEV. HAS 46,000 AND THE TRANSMISSION WILL NOT SHIFT BETWEEN 3RD AND 4TH GEAR. THE DEALER SAID THIS IS FAIRLY NORMAL TO HAPPEN. IT IS NOT INCLUDED IN THE POWER TRAIN WARRANTY. THE COST TO REPAIR IS $3000.00 TO $4000.00. THE CAR STARTED MAKING AN AWFUL NOISE, THE INSTRUMENT PANEL SAID TRANSMISSION HOT. WHEN I PUSHED ON THE ACCELERATOR THE CAR WOULD NOT GO IT JUST MADE AN AWFUL NOISE. THANK GOD I WAS ON A ROAD I COULD PULL OVER ON. THE CAR HAD TO BE TOWED IN TO THE DEALER.I HAVE A $50,000 CAR THAT CAN'T BE DRIVEN. IS THIS A COMMON PROBLEM TO 2005 SUBURBAN? *TR

IN ,MAY 2009 MY SPEEDO WAS OUT OF WHACK SAYS IM DRIVING 100MPH DOWN STREET, BURIED AT 120MPH ON HIGHWAY. CAME BACK TO LIFE LATER BUT NOW ITS HIT OR MISS IF IT WORKS. I HAVE TO USE MY MAGELLAN FOR SPEEDO NOW AND CHEVY DEALER SAID IF I WAS UNDER 70K THEY COULD FIX IT FOR FREE BUT SINCE IM AT 85K AND THEY SAY I HAVE TO PAY IN FULL (APPROX $750.00) AND CHEVY NEVER TOLD ME ABOUT THIS I LEARNED OF THE PROBLEM FROM A FRIEND. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE ABS BRAKES AND THE STABILITRAK WERE OUT OF ORDER UNTIL THE ABS CONTROL MODULE PART BECOMES AVAILABLE. PART#15234605 HAS BEEN ON BACK ORDER FOR OVER THREE WEEKS AND EACH WEEK THE DEALER ADDED TWO ADDITIONAL WEEKS AS THE AVAILABILITY DATE. THE GM MANUFACTURER WAS CONTACTED AND STATED THAT THERE WAS NOTHING THEY COULD DO. THE CONTACT FILED A CLAIM WITH THE MANUFACTURER. THE FAILURE MILEAGE WAS 88,000.

I HAVE A 2005 CHEVROLET SUBURBAN Z71 WITH 59,799 MILES. THE SPEEDOMETER ON IT RECENTLY STOPPED WORKING CORRECTLY. THE DAY THE SPEEDOMETER STOPPED WORKING CORRECTLY I WAS ON AN HOUR LONG TRIP ON THE HIGHWAY. DURING THE TRIP I NOTICED THE SPEEDOMETER SHOWED I WAS GOING 95 MPH. THE SPEEDOMETER CONTINUED TO INCREASE EVEN WHEN I SLOWED DOWN, UNTIL IT PASSED 120 MPH WHERE IT WAS STUCK FOR SEVERAL DAYS. IT STARTED TO SLOWLY GO BACK DOWN. SINCE THAT DAY THEN THE SPEEDOMETER CONTINUES TO SHOW THE INCORRECT SPEED OF THE VEHICLE. THE SPEEDOMETER SOMETIMES READS AS HIGH AS 120 MPH WHEN THE VEHICLE IS NOT MOVING, AND AT OTHER TIMES DISPLAYS THE VEHICLE GOING 10 MPH WHEN THE VEHICLE IS NOT MOVING, AND OTHER TIMES SHOWS CORRECTLY AT 0 MPH. THE PROBLEM SEEMS TO GET WORSE WHEN I DRIVE THE VEHICLE ON LONGER TRIPS. I HAVE CONTACTED THE LOCAL DEALERSHIP AND WAS TOLD THERE IS A RECALL TO CORRECT THIS PROBLEM BUT THAT MY VIN NUMBER IS NOT INCLUDED IN THE RECALL. *JB *TR

SPEEDOMETER DOES NOT WORK ON MY 2005 CHEVROLET SUBURBAN 1500. STOPPED WORKING AT ABOUT 60,000 MILES - THERE SHOULD BE A RECALL AS THIS IS A COMMON PROBLEM ON THIS VEHICLE AND IT COSTS APPROX. $500 TO FIX AND IT IS A SAFETY HAZARD. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE BLOWER MOTOR OF THE AIR CONDITIONER INTERMITTENTLY FAILS. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN REPLACED THE BLOWER RESISTOR, BECAUSE IT MELTED IN SIDE OF THE INSTRUMENT CONTROL PANEL. THE MANUFACTURER WAS NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE 55,000.

MY 2005 SUBURBAN THE DRIVE SHAFT WAS BROKEN AT ONLY ABOUT 40 MPH. IF IT HAPPENED ON HIGHWAY, PROBALLY WILL CAUSE AN ACCIDENT BECAUSE I HAS LOST THE CONTROL TOTALLY. *TR

WE BOUGHT A 2005 CHEVROLET SUBURBAN IN EARLY 2006. IN EARLY 2008 THE SPEEDOMETER STARTED TO ACT UP (BOUNCING, STEADILY DECREASING UNTIL ZERO) WE HAVE JUST COMPLETED A LONG TRIP AND THE SPEEDOMETER WAS NOT WORKING FOR 4 HOURS. *TR

JUST GOT INTO MY 2005 CHEVY SUBURBAN 1500. THE SPEEDOMETER STOP WORKING. REGISTERING 100MPH WHILE I WAS AT A STOP LIGHT, NOT WORKING AT ALL WHILE I DROVE BACK TO THE HOUSE. THERE IS A LAWSUIT FOR 2004 MODELS AND ONLY UP TO 70,000MILES. THIS IS A CLUSTER FAILURE AFFECTING THOUSANDS OF SUBURBAN,TAHOE, AND SIMILAR MODEL OWNERS. THE DEALERSHIPS ARE CHARGING AN AVERAGE OF $450.00 TO REPAIR THIS DEFECT THAT, JUDGING FROM THE LAWSUIT IS A COMMON PROBLEM. IT AFFECTS MY MONITORING OF MY SPEED AND ENDANGERS THE PUBLIC AND ALSO PUTS DRIVERS IN A BAD POSITION WITH LAW ENFORCEMENT. GM IS OBLIGATED TO REPAIR A PROBLEM THAT THEY HAD KNOWLEDGE OF. THERE ARE TOO MANY OF THESE VEHICLES ON THE ROAD TO ALLOW THIS DEFECT AND POTENTIAL SAFETY ISSUE TO GO UNCHECKED. *TR

WE HAVE A 2005 CHEVROLET SUBURBAN WITH 50,000 MILES. OUR INSTRUMENT CLUSTER IS NOT WORKING PROPERLY. SPEEDOMETER IS STUCK, OTHER GAUGES (I.E. FUEL, OIL, TEMP) WORK INTERMITTENTLY. I BELIEVE THIS IS A HUGE SAFETY ISSUE FOR OBVIOUS REASONS! THE COST TO FIX THIS IS $650 AND AFTER MUCH RESEARCH I SEE MANY COMPLAINTS OF THE SAME NATURE! CHEVROLET HAS EVEN RECALLED THE 2003/2004 MODELS FOR THIS REASON! WHY NOT 2005? *TR

I HAVE A 2005 CHEVROLET SURBURBAN. THE BACK HATCH WINDOW HAS PLASTIC OR RUBBER HINGES TO HOLD IT TO THE FRAME. THE WINDOW ALSO HAS A BOLT TO HOLD THE PISTON CYLINDERS SO THE WINDOW COULD CLOSE AND OPEN. THE WINDOW FRAME WHERE IT HOLDS THE HINGE BROKE OFF AND NOW THE HINGE OR BOLT THAT HOLDS THE CYLINDERS FOR THE WINDOW IS COMING LOOSE. I HAVE CANNOT OPEN THE WINDOW HATCH IN THE REAR OR IT WILL NOT CLOSE. I BOUGHT THE SUBURBAN BRAND NEW AND I DON'T THING THIS SHOULD BE HAPPENING IN FOUR YEARS. *TR

ERRATIC SPEEDOMETER...OFTEN THE NEEDLE STICKS AT 120 MPH WHEN ONLY GOING ABOUT 30...SOMETIMES AT 40 WHEN ACTUALLY NOT MOVING AT A STOPLIGHT. IT READS ERRATICALLY ALL OF THE TIME. STARTED ABOUT 2 YEARS AGO (75,000 MILES). VERY COSTLY TO REPAIR, SO I KEEP MY PORTABLE GPS RUNNING TO GET ACTUAL SPEED. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. WHENEVER THE CONTACT ATTEMPTS TO OPEN THE REAR HATCH, IT FAILS TO OPEN FROM BOTH INSIDE AND OUTSIDE THE VEHICLE. PRIOR TO THE FAILURE, THE CONTACT NOTICED THAT THE REAR HATCH WOULD NOT LOCK PROPERLY AND WOULD TRIGGER THE VEHICLE'S ALARM SYSTEM. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 51,400.

AS I HAVE READ THIS IS A RECURRING PROBLEM. MY SPEEDOMETER ON OUR 2005 CHEVROLET SUBURBAN 67,000 MILES QUIT WORKING. ON A LONG TRIP IT WOULD ONLY SHOW 45-60 MPH. I KNOW I WAS GOING ALOT FASTER. WHEN I ACCELERATED IT WOULD SLOWLY JUMP UP TO SPEED. SEVERAL TIMES THE OIL PRESSURE GAUGE WAS AFFECTED ALSO. WE HAD THE CLUSTER REPLACED AT THE DEALERSHIP. LUCKILY WE HAD AN EXTENDED WARRANTY. IN MY OPINION THIS IS A SAFETY CONCERN FROM DEC 08 UNTIL MAY OF 09 IT HAPPENED 10 TIMES. *TR

ERRATIC SPEEDOMETER... SAYS THE VEHICLE IS MOVING 120 MPH WHEN IN A VILLAGE AND 30 ON THE HIGHWAY... IT READS ERRATICALLY ALL OF THE TIME. STARTED ABOUT 2 MONTHS AGO (78,000 MILES) THIS IS A HUGE SAFETY ISSUE. IS CHEVROLET GOING TO FIX THIS PROBLEM? I HAVE READ NUMEROUS SIMILAR COMPLAINTS. *TR

I HAVE A 2005 1500 CHEVY SUBURBAN THAT THE SPEEDOMETER READS ERRATIC. IT GOES 120+ WHILE AT A RED LIGHT OR 25 CRUISING DOWN THE INTERSTATE. THIS HAS BEEN GOING ON FOR ABOUT 5 MONTHS NOW. I TALK TO THE DEALERS AND THEY SAY THERE IS NOTHING THEY CAN DO THAT I WILL HAVE TO PAY THE 600-900 DOLLARS FOR THE REPAIRS. NOT KNOWING HOW FAST OR SLOW YOU ARE GOING ONLY GUESTAMATING IS VERY DANGEROUS FOR MYSELF ALONG WITH EVERYONE ELSE I SHARE THE ROAD WITH. *TR

SPEEDOMETER SHOWS 110 MPH WHEN CARS ARE PASSING ME. I BELIEVE AM GOING ABOUT 55 OR 60 MPH. I UNDERSTAND THE PROBLEM IS WITH THE INSTRUMENT CLUSTER IN THE DASHBOARD. *TR

MY OIL PRESSURE GAUGE STARTED READING "0" IN NOVEMBER 2008 BUT THERE IS NOTHING WRONG WITH MY OIL. (MILEAGE APPROX. 49,000) I CHECK IT OFTEN AND HAVE THE OIL CHANGED REGULARLY. IN FEBRUARY 2009 MY SPEEDOMETER STARTED REGISTERING INACCURATELY. FIRST, IT WOULD SAY I WAS GOING 40 MPH AT A DEAD STOP. CURRENTLY, IT IS PAST THE 120 MPH MARK AND HOLDING. (MILEAGE 52,000) I TOOK IT TO A CHEVY DEALER FOR DIAGNOSTIC EVALUATION. I WAS TOLD IT WAS THE DASHBOARD CIRCUIT BOARD AND THAT IT WOULD BE $500 TO REPLACE IT. THE SERVICE MANAGER TOLD ME THAT THIS PART HAD BEEN RECALLED ON THE 2003-2004 MODELS BUT NOT THE 2005. THAT I COULD PAY FOR THE REPAIR AND IF IT WAS RECALLED I COULD BE REIMBURSED. THIS IS A HUGE SAFETY CONCERN ESPECIALLY WITH YOUNG TEENAGE DRIVERS. IT SEEMS OBVIOUS TO ME READING THROUGH ALL THE COMPLAINTS FOR THE 2005 MODEL AND THE RECALLS OF PREVIOUS YEARS THAT THE 2005 MODEL SHOULD BE RECALLED AS WELL. *TR

I PURCHASED MY VEHICLE LAST YEAR AND I AM HAVING PROBLEMS WITH MY SPEEDOMETER AND MY RPM GAGE. I WAS DRIVING AND MY SPEEDOMETER JUST KEPT MOVING UP AND FINALLY IT JUST GOT STUCK AT 120. IT DOESN'T MOVE FROM THERE AND IT IS A VERY BIG SAFETY ISSUE. MY WIFE USES THE VEHICLE MOSTLY AND IS ON THE FREEWAY QUITE A BIT AND ITS A CONCERN BECAUSE YOU HAVE NO IDEA WHAT YOUR SPEED. WE ARE BASICALLY GUESSING AND THAT ISN'T SAFE FOR ME OR MY KIDS. WE HAVE CONTACT OUR DEALER WERE WE PURCHASED IT AND I WOULD HAVE TO PAY $100.00 FOR THE DEDUCTIBLE. I HAVE LOOKED IN SEVERAL DIFFERENT WEBSITES (EDMUNDS.COM) REGARDING THIS ISSUE AN WAS VERY SURPRISED TO SEE THAT THERE ARE MANY PEOPLE WITH THE SAME PROBLEM AND FRUSTRATED THAT CHEVY WON'T FIX THE PROBLEM. THERE IS AN OBVIOUS MALFUNCTION AND IT SHOULD BE REPLACED AT THERE COST NOT THE CONSUMERS. MY VEHICLE HAS ONLY 57000 MILES AND THIS SHOULD NOT BE OCCURRING. I ALSO HAVE A 1994 CHEVY TRUCK AND IT HAS NEVER EXPERIENCED PROBLEM LIKE THIS. I REALLY HOPE SOMEONE CAN HELP WITH THIS PROBLEM. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. UPON PURCHASING THE VEHICLE IN OCTOBER OF 2008, THE AIR BAG WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER FAILED TO REPAIR THE AIR BAGS AT THE TIME OF PURCHASE. THE CONTACT COULD NOT HAVE THE VEHICLE REGISTERED IN THE STATE OF TEXAS WITH THE WARNING INDICATOR ILLUMINATED. THE DEALER DENIED ALL LIABILITY FOR THE REPAIRS TO THE AIR BAG. THE FAILURE MILEAGE WAS 80,000 AND CURRENT MILEAGE WAS 85,000. UPDATED 05/18/09. *LJ UPDATED 05/20/09.*JB

IN NOVEMBER, MY SPEEDOMETER ON MY 2005 SUBURBAN 1500 STARTED FLUCTUATING ALL OVER THE PLACE. SOMETIMES IT DOESN'T EVEN READ ON THE NUMBERS. CALLED DEALER AND THEY SAID THEIR WAS A RECALL ONLY UP TO 2004. I READ ON LINE THAT ALOT OF PEOPLE WERE HAVING TROUBLE WITH THE CLUSTER. NOW IN BEGINNING OF FEBRUARY MY GAS GAGE IS READING WRONG. THINGS ON THE INSTRUMENT PANEL ARE NOT WORKING RIGHT. THIS ALL STARTED HAPPENING UNDER 50,000 MILES. MY HUSBAND IS LAID OFF AND WE JUST DON'T HAVE THE MONEY TO FIX IT. PLEASE HELP!! *TR

THE SPEEDOMETER IN MY 2005 CHEVROLET SUBURBAN JUST STOPPED WORKING. THE NEEDLE IS INDICATING 30MPH ALL THE TIME. THIS INITIALLY LEAD TO ME THINKING I WAS GOING SLOWER THAN I REALLY WAS UNTIL I FIGURED OUT THAT IT WASN'T WORKING PROPERLY. *TR

SPEEDOMETER STOPPED WORKING. IT IS STUCK ON 30MPH. THERE IS NO WAY TO TELL WHAT SPEED YOU ARE TRAVELING AT. *TR

I HAVE A 2005 CHEVY SUBURBAN WITH ABOUT 55,000 MILES ON IT. FOR THE PAST 6-8 MONTHS, MY SPEEDOMETER AND OTHER GAUGES (OIL, ETC.) WILL STICK CAUSING INACCURATE READINGS. AT TIMES MY SPEEDOMETER IS ABOUT 30 MPH OFF FROM THE REAL SPEED, AND FOR THE MONTHS THE OIL GAUGE HAS READ OFF THE CHARTS. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE SPEEDOMETER DISPLAYS INACCURATE READINGS ON THE INSTRUMENT PANEL. HE CANNOT DETERMINE THE APPROPRIATE SPEED, WHICH IS A SAFETY ISSUE. THE DEALER STATED THAT THE INSTRUMENT CONTROL CLUSTER NEEDED TO BE REPLACED AT THE COST OF $600. THE MANUFACTURER STATED THAT BECAUSE A CLASS ACTION LAWSUIT DOES NOT INCLUDE THE CONTACT'S VEHICLE YEAR, THEY WOULD NOT ASSUME ANY RESPONSIBILITY FOR THE REPAIR. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 54,000 AND THE CURRENT MILEAGE WAS UNKNOWN. UPDATED 5/26/09 *CN THE SPEEDOMETER IS BROKEN AND THE ELECTRICAL COMMUNICATION MAKES A BUZZING SOUND. UPDATED 05/28/09.*JB

2005 CHEVROLET SUBURBAN APPROX. 64,000 MILES I HAVE A FAULTY READING SPEEDOMETER, WHICH I FEEL IS A SAFETY HAZARD. I NEVER KNOW HOW FAST I AM GOING. THANKFULLY I HAVE NOT HAD A ACCIDENT OR GOTTEN A SPEEDING TICKET YET. I TOOK IT IN TO MY MECHANIC, WHO TRIED REPLACING THE SPEED SENSOR IN THE TRANSMISSION, TO NO AVAIL. I KNOW THERE IS A RECALL FOR 2003 & 2004 MODELS. I TRIED CALLING THE GM HOTLINE AND WAS TOLD THERE ARE NO RECALLS FOR 2005. I CALLED A LOCAL DEALER WHO TOLD ME THE SAME THING. I DON'T KNOW WHERE TO GO FROM HERE. I WOULD LIKE TO GET IT FIXED BEFORE IT REACHES 70,000 MILES. THE DEALER DID ASK IF I WAS THE ORIGINAL OWNER. I ASSUME THEY WOULD SAY IF I WASN'T, THEY WOULD NOT FIX IT. I DON'T KNOW WHAT THAT SHOULD HAVE TO DO WITH ANYTHING. WHAT OR WHERE DO I GO FROM HERE? *TR

DEFECTIVE SPEEDOMETER, HAVE CONTACTED CHEVY ON SEVERAL OCCASIONS AND THEY REFUSE TO PAY FOR COST. GM RECALLED SAME DEFECT ON OTHER MODELS EXCEPT MINE WHICH IS A 2005 CHEVY SUBURBAN. CHEVY TOLD ME MY CAR EXCEEDED ALL WARRANTY DUE TO MILEAGE WHICH IS IN THE 80K RANGE. THIS IS A DEFECTIVE PART AND SHOULD BE REPLACED NO MATTER WHAT MILES I HAVE ON THE CAR. CURRENTLY THIS PROBLEM IS INTERMITTENT SO I'M NEVER SURE IF SPEEDOMETER IS RIGHT OR WRONG. MY TEENAGER DRIVES MY CAR AND IS UNABLE TO KNOW WHAT ACTUAL SPEED HE'S DRIVING. THIS IS POTENTIALLY DANGEROUS AND I CANNOT AFFORD TO REPAIR MYSELF. *TR

I WAS DRIVING ON THE HIGHWAY AND LOOKED DOWN AND THE SPEEDOMETER SAID 100! CARS WERE PASSING ME AND I KNEW THERE WAS NO WAY I WAS DRIVING 100. ONCE I GOT TO MY DESTINATION, SITTING STILL THE SPEEDOMETER WAS AT EITHER 50 OR 60. WHEN IN MOTION IT USUALLY READS ABOUT 105-115 WHEN GOING BETWEEN 60-70 MPH. (I THINK, I REALLY HAVE NO IDEA SINCE MY SPEEDOMETER IS BROKEN!!!) I HAVE JUST OVER 75,000 MILES ON A 2005 SUBURBAN 1500. *TR

I HAVE A 2005 CHEVROLET SUBURBAN. THE SPEEDOMETER HAS BEEN GOING OUT FOR SOME TIME. IT WILL EITHER NOT REGISTER OR REGISTER OFF SO THAT THE PERSON DRIVING HAS NO IDEA OF SPEED. I HAVE CONTACTED CHEVY AND MY DEALER AND HAVE BEEN INFORMED THAT CHEVY KNOWS OF THE ISSUE BUT WILL ONLY COVER REPLACEMENT THROUGH MODEL YEAR 2004. THERE IS A CLASS ACTION SUIT TO TRY TO FORCE COVERAGE OF ADDITIONAL YEARS. *TR

THE SPEEDOMETER ON MY 2005 CHEVROLET SUBURBAN STOPS WORKING AT RANDOM TIMES. IT STARTED APPROX. ONE WEEK AGO AT 73000 MILES. SINCE IT IS OUT OF WARRANTY, CHEVROLET WILL NOT PAY. THERE IS A CLASS ACTION LAWSUIT FILED FOR MY VEHICLE. *TR

MY DAUGHTER WAS DRIVING DOWN THE ROAD AND SPEEDOMETER BEGAN ACTING ERRATICALLY. AT A STOP LIGHT SPEEDOMETER READS 25 MPH. IGNITION WAS TURNED ON/OFF WITH NO RESULTS. *TR

MY 2005 K1500 SUBURBAN SUSTAINED A CRACKED HEAD WITH 73,000 ON THE ENGINE. THE SERVICE DEPARTMENT AT MY DEALERSHIP HAS NO INFORMATION THAT A MANUFACTURING PROBLEM EXISTS. THE REPAIR COST OVER $2,000. THIS IS NOT A NORMAL OCCURRENCE OR EXPECTED VEHICLE WEAR. *TR

I HAVE A COMPLAINT ABOUT THERE NOT BEING A RECALL ON MY 2005 CHEVY SUBURBAN ON THE INSTRUMENT PANEL AND ELECTRICAL COMPONENTS. SOMETIME EARLIER THIS YEAR MY SPEEDOMETER STARTED JUMPING TO HIGHER SPEEDS AS I WAS DRIVING AND THEN GOT TO THE POINT IT WAS GOING ALL THE WAY PAST 120MPH. SOMETIMES IT WOULD RESET TO 0 AFTER THE VEHICLE WAS TURNED OFF. MOST RECENTLY IT HAS GONE PAST 120 AND WILL NOT RETURN TO THE NORMAL FUNCTIONS IT SHOULD HAVE. IT IS VERY DANGEROUS NOT TO KNOW HOW FAST YOU ARE GOING, HOWEVER, LIKE EVERYONE ELSE I CANNOT AFFORD THE $400-$600 TO PAY FOR SOMETHING THAT IS A MANUFACTURES DEFECT OBVIOUSLY! WITH SO MANY COMPLAINTS LISTED EXACTLY THE SAME ON THIS SITE, IT HAS TO BE A MANUFACTURES DEFECT. BESIDES THE SPEEDOMETER NOT WORKING PROPERLY, ALL THE INSTRUMENT LIGHTS ARE STARTING TO GO OUT OR NOT WORK. SUCH AS THE RADIO ON/OFF SWITCH NO LONGER LIGHTS UP. SOME OF THE OTHER RADIO LIGHTS DO NOT LIGHT UP. ON THE STEERING WHEEL, SOME OF THE CONTROLS DO NOT LIGHT UP. I CANNOT BELIEVE THAT I HAVE RECEIVED A LETTER LETTING ME KNOW OTHERS ARE ALSO EXPERIENCING PROBLEMS WITH THEIR CHEVY VEHICLES AND THEY HAVE STARTED A LAW SUITE. MY VEHICLE IS A 2005 MODEL, BUT SINCE I BOUGHT IT IN MARCH 2005, SO IT MUST HAVE BEEN MANUFACTURED BEFORE JAN 2005. THE LETTER SAYS IT COVERS UP TO 2004 MODELS AND MAY LATER INCLUDE THE 2005 MODELS. AS I SEE IT MINE IS DOING EXACTLY THE SAME AS EVERYONE ELSE AND NOTHING IS BEING DONE. COULD SOMEONE EXPLAIN WHAT HAPPENS NEXT? AND WHEN WILL CHEVY BE RESPONSIBLE FOR ALL THESE COMPLAINTS? *TR

THE SPEEDOMETER IN MY 2005 CHEVROLET SUBURBAN HAS DEVELOPED A TICKING NOISE IN THE PAST FEW DAYS. THE VEHICLE HAS 83, 300 MILES. IT STARTED AS A LOW CLICKING NOISE AND HAS CONTINUED TO BECOME LOUDER. I HAVE CONTACTED THE LOCAL CHEVROLET DEALERSHIP, WHICH GAVE ME NO SATISFACTION FOR REPAIRS. *TR

TRANSMISSION FAILURE. AS I BEGAN ACCELERATING FROM A STOP, IN ORDER TO MAKE A LEFT TURN ACROSS OPPOSING TRAFFIC LANES, I HAD A COMPLETE FAILURE OF FORWARD MOMENTUM. THE VEHICLE BEHIND ME NARROWLY MISSED A REAR END ACCIDENT AND OPPOSING TRAFFIC WAS FORCED TO QUICKLY STOP AS I WAS LEFT BLOCKING THEIR TRAFFIC LANE. VEHICLE STILL UNDER WARRANTY WITH 25,122 MILES. DEALER REPAIRED TRANSMISSION AND IDENTIFIED "SPRAG GEAR FOUND DAMAGED ... CLUTCHES ALSO BURNT REPLACED AS NEEDED...". POSSIBLE TSBS 08-07-30-027. *TR

ROLLOVER ACCIDENT OF 2005 CHEVY SUBURBAN. RIGHT REAR TIRE SEPARATED TREAD AT HIGHWAY SPEED. TIRES WERE BIG O PATHMAX LT245/75R16. TIRES HAD 10,465 MILES OF USE AT TIME OF ACCIDENT. THE TREAD ON REMAINING INFLATED TIRES SHOWED BELTS BETWEEN TREAD EVEN THOUGH THE TREAD ITSELF LOOKED OK. DRIVER WAS INJURED, VEHICLE WAS TOTALED. *TR

TRANSMISSION NEEDED TO BE REPLACED WITH A REBUILT TRANSMISSION @ 51,100 MILES. CHILDREN AND OTHER PASSENGERS WERE STRANDED IN PA @ 12:00 AM. *TR

INSTRUMENT CLUSTER FAILURE. GAUGES NOT ACCURATE. I WAS TOLD INSTRUMENT CLUSTER WOULD NEED TO BE REPLACED AT MY COST. *TR

THE TRACTION CONTROL ACTIVATES ITSELF ON MY VEHICLE EVEN WHEN ON DRY PAVEMENT WITH VERY CONSERVATIVE DRIVING. WHEN TURNING OR ENTERING OUT INTO TRAFFIC SUDDENLY THE SYSTEM WILL ENGAGE AND POWER DOWN THE VEHICLE TO A CREEP. IT THEN RE-SETS ITSELF AFTER 2-5 SECONDS. HOWEVER, WHILE ENGAGED I AM RENDERED HELPLESS AND A SITTING DUCK TO THE UPCOMING TRAFFIC. I HAVE BEEN TOLD THAT WHEN IT BECOMES MORE FREQUENT (HOPEFULLY MY FAMILY AND I WON'T BE KILLED BEFORE THEN) THAT IT MIGHT SHOW A CODE SO THAT THEY WILL KNOW WHAT TO DO. IN THE MEAN TIME I AM TOLD THEY HAVE NO IDEA. (2005 SUBURBAN 1500 LT AUTORIDE). *TR

I RECEIVED A LETTER STATING THAT THE SPEEDOMETER OF MY MODEL VEHICLE HAD A RECALL (2005 SUBURBAN). I MISPLACED THE LETTER BUT DECIDED TO TAKE MY VEHICLE IN TO THE DEALERSHIP BUT WAS TOLD THAT I HAD TO PAY $100 DEDUCTIBLE. I'M NOT UNDERSTANDING WHY THE SPEEDOMETER CAN NOT BE REPLACED WITHOUT PRESENTING THE LETTER. *TR

2005 CHEVROLET SUBURBAN 48,500 MILES SPEEDOMETER QUIT WORKING FROM WHAT I HAVE READ ONLINE THIS IS A PROBLEM WITH MANY 2005 CHEVY VEHICLES. *TR

THE TRANSMISSION BEGAN SLIPPING; THE CAR WOULD NOT MOVE FROM 2ND TO 3RD GEAR; THE TRANSMISSION HAD TO BE REBUILT OR REPLACED ON 2/06/2008, WE HAD IT REBUILT. THE VEHICLE ONLY HAD 69710 MILES. WE WERE IN A RURAL AREA AT THE TIME RATHER THAN RUSH HOUR TRAFFIC. THANK GOODNESS. *TR

THE AIRBAG SYSTEM HAS STOPPED WORKING 6 TIMES SINCE I BOUGHT MY BRAND NEW SUBURBAN. THE SERVICE AIR BAG LIGHT COMES ON WHICH MEANS THE SYSTEM WILL NOT WORK IF IN AN ACCIDENT. THE HAVE ATTEMPTED TO FIX IT SIX TIMES. NOW GM STATED THAT THEY WILL NOT DO ANYTHING FURTHER AND THEIR SOLUTION IS FOR ME TO BUY A NEW CAR WHEN MY CAR IS ONLY 2.5 YEARS OLD AND ONLY HAS 36,000 MILES ON IT.

I HAVE A 2005 CHEVY SUBURBAN. AT A LITTLE OVER 49,000 MILES MY SPEEDOMETER NEEDLE BEGAN TO REPORT INACCURATE READINGS WHILE THE TRUCK WAS IN MOTION. AFTER A COUPLE OF DAYS THE NEEDLE FELL ALL THE WAY TO THE RIGHT OF THE PANEL AND WOULDN'T MOVE. AFTER GETTING QUOTE FROM THE DEALERSHIP TO REPLACE NEW AND CHECKING WITH SOME AREA JUNK YARDS I LEARNED THERE WERE POSSIBLE RECALLS ON OTHER CHEVY TRUCKS AND SUV'S. ONCE I CHECK ON THE INTERNET AND FOUND NUMEROUS PEOPLE EXPERIENCING THE SAME PROBLEM. ON TONIGHT I CALLED AND LEARNED THAT THE 2004 SUBURBAN HAS A RECALL BUT NOT THE 2005 SO I OPENED A CASE WITH CHEVEROLET CONSUMER ASSISTANCE TO SEE ABOUT GETTING MY TRUCK FIXED AS I CAN'T AFFORD $500 TO FIX A MECHANICAL DEFECT WHICH SHOULD BE COVERED CHEVROLET EXPENSE AND NOT THE CONSUMER. I'M NOW DRIVING AROUND NOT KNOWING WHAT SPEED I'M DRIVING AND RISKING GETTING A SPEEDING TICKET WHICH IS ANOTHER EXPENSE. I'M A SINGLE MOTHER WITH 2 KIDS AND THIS IS MY ONLY MEANS OF TRANSPORTATION.

THE SPEEDOMETER ON MY 2005 CHEVROLET SUBURBAN AT 50K MILES WITHOUT WARNING STARTED TO INDICATE INCORRECT SPEEDS. THE SPEED READINGS INITIALLY WERE SLOWER THAN MY ACTUAL SPEED AND LATER AS THE PROBLEM PROGRESSED MUCH HIGHER. THE INITIAL INCORRECT SPEEDS WERE ONLY NOTICED AFTER FRIENDS FOLLOWING ME QUESTIONED MY HIGH RATE OF SPEED. MY WIFE DRIVES MY 4 CHILDREN AROUND IN THIS VEHICLE. *TR

MY SPEEDOMETER ON MY 2005 CHEVY SUBURBAN WENT OUT AND THE DEALER SAY IT WOULD CAUSE $500 DOLLARS TO REPLACE IT I THOUGHT THAT WAS RIDICULOUS I WENT ON LINE AND SEEN THAT OTHER PEOPLE WAS HAVING THE SAME PROBLEM WITH THEIR GMC VEHICLES THERE ALL TO BE A RECALL ON THE SPEEDOMETER GMC IS GETTING A BAD REPUTATION. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. WHILE DRIVING 35 MPH, THE CONTACT RELEASED THE ACCELERATOR PEDAL AND THE RPM'S DECREASED TO 1,000. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE WOULD CLUNK FORWARD. THE VEHICLE HAS BEEN DIAGNOSED BY THE DEALER, BUT THE FAILURE REMAINS. THE CURRENT MILEAGE WAS 13,000 AND FAILURE MILEAGE WAS 11,638.

INSTRUMENT PANEL FAILURE. SPEEDOMETER STUCK BELOW 0 (ZERO). TIRE PRESSURE READINGS KEEP CHANGING IN MINUTES RANGING 20-46. SCHEDULE FOR REPLACEMENT OF THE INSTRUMENT PANEL CLUSTER AND WILL COST $450-600. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. THE DRIVER SIDE SHOULDER SEAT BELT IN THE CENTER ROW WILL NOT RETRACT AND APPEARS TO BE JAMMED. THE FAILURE OCCURRED 100 MILES AFTER THE WARRANTY EXPIRED. THE DEALER HAS NOT BEEN NOTIFIED. NHTSA CAMPAIGN ID NUMBER 05V163000 (SEAT BELTS:REAR) WAS REFERENCED. THE CURRENT MILEAGE WAS 42,000 AND FAILURE MILEAGE WAS 35,900.

WHILE DRIVING THE SPEEDOMETER BEGAN TO GIVE ERRATIC READINGS, THE NEEDLE BOUNCED AROUND AND GAVE INACCURATE INFORMATION. THIS INITIAL PROBLEM SEEMED TO RESOLVE ITSELF WHEN I STOPPED AND TURNED THE VEHICLE OFF AND THEN RESTARTED IT. SINCE THE INITIAL INCIDENT THE PROBLEM HAS BEEN SPORADIC BUT BECOMING MORE FREQUENT. THE VEHICLE IS CURRENTLY SCHEDULED FOR SERVICE. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE INSTRUMENTAL PANEL CLUSTERS DO NOT OPERATE PROPERLY. WHILE IDLING AT A STOP LIGHT, THE SPEEDOMETER GAUGE DISPLAYED 10-20 MPH. THE MANUFACTURER ISSUED A TSB FOR THE 2001-2003 MODELS, BUT NOT THE 2005. THE MANUFACTURER AND DEALER WOULD NOT REPAIR THE VEHICLE UNDER THE TSB. THE INSTRUMENTAL PANEL WAS REPLACED IN JANUARY OF 2008 AND THE CONTACT PAID FOR THE REPAIR. HE WOULD LIKE TO BE REIMBURSED BY THE MANUFACTURER. THE CURRENT MILEAGE WAS 53,296 AND FAILURE MILEAGE WAS 53,250.UPDATED 04/16/08.*LJ

SMELLED FUEL LOOKED UNDER VEHICLE AND FUEL WAS SPRAYING OUT OF FUEL HOSE. IMMEDIATELY DROVE TO DEALER SERVICE DEPARTMENT TO BE LOOKED AT. ON THE WAY THE VEHICLE LOST ALMOST ALL REMAINING FUEL. DEALER IS REPLACING PARTS AT A GREAT EXPENSE. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. WHILE THE VEHICLE WAS BEING SERVICED, THE MECHANIC DISCOVERED THAT THE TWO FRONT TIRES WERE WORN ON THE INSIDE. THE CONTACT PURCHASED FIVE SETS OF TIRES. THE CURRENT MILEAGE WAS 55,223 AND FAILURE MILEAGE WAS 13,000. UPDATED 04/03/08. *LJ

SPEEDOMETER WOULD GO UP WHEN I INCREASED SPEED BUT WOULD NOT GO BACK DOWN WHEN THE VEHICLE SLOWED DOWN. I WAS ABLE TO GET THE SPEEDOMETER TO RESET TO ZERO BY REPEATEDLY STARTING AND TURNING OFF THE VEHICLE. OVER THE COURSE OF THE NEXT MONTH THE NEEDLE WOULD DO THE SAME THING. I COULD RESET IT THE SAME WAY. AS OF NOW ITS PEGGED AT THE BOTTOM AND I CANNOT RESET IT. *TR

SPEEDOMETER STICK AT 65MPH, NEXT TIME I START MOVING IT MOVES UP TO 120 MPS. OTHER TIMES IT STUCK AT VARIOUS SPEEDS. I DEPEND ON MY SPEEDOMETER TO KEEP ME SAFE. THE FIRST TIME IT HAPPENED I ALMOST CRASHED. SINCE THEN I HAVE HAD A COUPLE OF CLOSE CALLS. IF YOU CAN'T RELY ON YOUR SPEEDOMETER IT IS VERY STRESSFUL AND DANGEROUS! " PLEASE HELP US FIX THIS DANGEROUS PROBLEM". THANK YOU, MICHAEL J. SANFILIPPO *TR

I HAVE A 2005 CHEVY SUBURBAN 4X4 AND WITHIN THE FIRST 14,000 MILES IT HAS STARTED TO ENGAGE INTO 4W LO WHILE DRIVING ON THE FREEWAY, IN REVERSE, GOING 25 MPH IN RESIDENTIAL NEIGHBORHOOD(THIS IS A GEAR THAT YOU CANNOT DRIVE OVER 15MPH IN). NEEDLESS TO SAY THAT SHELLWORTH CHEVROLET LOCATED IN VACAVILLE, CA HAS BEEN TRYING TO FIX THE PROBLEM FOR OVER 25,000 MILES AND OVER 6 TIMES IN THE SHOP. THEY HAVE BEEN UNSUCCESSFUL WITH THE LAST TIME IT WAS IN THE SHOP UNWILLING TO DO ANYTHING FOR ME. IT HAS EVEN BEEN TOWED INTO THEIR SHOP ON ONE OCCASION. THEY NO LONGER WANT TO PROVIDE ME WITH SERVICE, TOLD ME TO FILE A COMPLAINT WITH GM FOR A BUYBACK PURCHASE AND SHOED ME OFF. GM SAYS IT IS NOT ELIGIBLE FOR THE BUYBACK PROGRAM PROBABLY BECAUSE OF ALL THE FALSE AND INACCURATE INFORMATION THE SERVICE WRITERS HAVE DOCUMENTED ON THE WORK ORDERS. I HAVE ASKED TO SPEAK TO GM DISTRICT MANAGER WHO HAS MADE THIS DECISION AND HE HAS DECLINED TO SPEAK TO ME, AS WELL AS THE SERVICE MANAGER AT SHELLWORTH HAS NOT RETURNED MY LAST 2 PHONE CALLS. THE LAW STATES THAT THEY EITHER FIX MY VEHICLE TO A WORKING ORDER OR GIVE ME A REPLACEMENT VEHICLE. THEY ARE NOT DOING EITHER. ON OCT. 31 AFTER ARGUING WITH THEM BECAUSE THEY DIDN'T WANT TO HANDLE THE ISSUE THAT TIME EITHER THEY DECIDED TO GO LOOK AT A DIFFERENT BULLETIN AND FOUND SOMETHING, SO THEY REPLACED SOME PARTS AND RELEASED THE VEHICLE TO ME. SINCE THEN THE LIGHT HAS CAME ON 2 TIMES WHICH IS THE START OF THE PROCESS IN WHICH IT THEN ENGAGES TO 4W LO ALL BY ITSELF. *TR

ISSUE WITH INSTRUMENT PANEL (INCLUDING STEREO, LIGHTS ON PANEL, INSTRUMENT GAUGES), POWER WINDOWS/LOCKS & SECURITY SYSTEM - RANDOMLY SHUTS OFF. SOMETIMES THE ODOMETER WORKS AND OTHER TIMES IT DOES NOT. THE INSTRUMENT PANEL GAUGES ALL MOVE TO THE LEFT WITH THE GAS LIGHT COMING ON. THE TIRE PRESSURE MONITOR IS ACTIVATED. PANEL INDICATORS COME ON (ENGINE LIGHT, SECURITY SYSTEM, SEAT BELTS, ETC.). STEREO SYSTEM IS COMPLETELY OFF WITH NO LIGHTS ON THE PANEL. THE HEATER/AC SYSTEM SOMETIMES GOES OFF ALSO. THE POWER WINDOWS AND LOCKS DO NOT WORK DURING THESE TIMES. *TR

2005 CHEVY SUBURBAN SPEEDOMETER DOES NOT SHOW THE RIGHT SPEED. FIRST IS WAS UP BY 30MPH EVENTUALLY IT SETTLED DOWN TO 10 MPH AND THAT IS WHERE ITS STUCK, IT DOES NOT SHOW MY PROPER SPEED ANY MORE. *TR

THE SPEEDOMETER ON MY 2005 CHEVY TAHOE HAS BEEN ACTING ERRATICALLY. SOMETIMES IT WILL WORK NORMALLY. OTHER TIMES, IT WILL NOT REGISTER AT ALL. ADDITIONALLY TIME IT WILL READ ERRONEOUSLY WHEN DRIVING TRAFFIC SPEEDS. THE SELECTION PROCESS DID NOT ALLOW ME TO REGISTER A TAHOE, ONLY A SUBURBAN, WHICH IS WHY THE VEHICLE INFORMATION LOOKS AS IT DOES. *TR

SPEEDOMETER OPERATES ERRATICALLY, STICKS WHEN CHANGING SPEEDS, OR READS ERRONEOUSLY (E.G. 5 MPH ON THE FREEWAY DOING 70 OR 100 MPH WHEN PARKED). *TR

THE EVENTS LEADING UP TO THE FAILURE WAS NORMAL VEHICLE OPERATION FOR APPROXIMATELY ONE YEAR. THE FAILURE TO THE VEHICLE WAS A VIBRATION IN THE STEERING SHAFT. CONSEQUENCES COULD HAVE RESULTED IN A LOSS OF STEERING. CHEVROLET SERVICE LUBED THE STEERING SHAFT PER A GM SERVICE BULLETIN. THIS REPAIR WAS COVERED UNDER WARRANTY. APPROXIMATELY ONE YEAR LATER, THE SAME FAILURE OCCURRED. CHEVROLET SERVICE STATED THAT GM HAS DEVELOPED A NEW STEERING SHAFT TO ELIMINATE THIS PROBLEM. I WILL BE TAKING MY VEHICLE IN FOR REPAIR 3 DAYS FROM THIS WRITING. CHEVROLET SUGGESTED THIS COMPLAINT AS A METHOD OF OBTAINING A RECALL AND SUBSEQUENTLY A REIMBURSEMENT FOR THE REPAIR. *TR

TRANSMISSION HOT LIGHT CAME ON AS TRAVELING THE INTERSTATE. PULLED OVER UNTIL LIGHT WENT OUT. LEFT THE INTERSTATE, LIGHT CAME ON AGAIN. AS TRYING TO PULL OFF ROAD, TRUCK STOPPED (ENGINE ON, BUT WOULD NOT ADVANCE FORWARD). HAD TO REPLACE WITH ANOTHER TRANSMISSION. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE VEHICLE HAS TWO COOPER TEMPRA TRAIL CUTTERS, SIZE LT26570R17 TIRES (NA). WHILE DRIVING 70 MPH, THE CONTACT FELT A STRONG VIBRATION COMING FROM THE TIRES. THE REAR PASSENGER SIDE TIRE TREAD SEPARATED, CAUSING THE TIRE TO EXPLODE. THE FAILURE DAMAGED THE REAR FENDER, BUMPER, AND TAILPIPE. TRIPLE A ARRIVED AND REPLACED THE TIRE. THE VEHICLE IS CURRENTLY AT THE BODY SHOP AND ALL FOUR TIRES WILL BE REPLACED BECAUSE THE REAR DRIVER SIDE TIRE ALSO SHOWS TREAD SEPARATION AND BLISTERS. THE DOT NUMBER AND DEALER INFORMATION WERE UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 85,000. UPDATED 12/12/2007 *BF UPDATED 12/12/07 *TR

THE SPEEDOMETER NEEDLE BEGAN READING HIGHER AND HIGHER SPEEDS EVEN THOUGH THERE WAS NO ACCELERATION. WHEN SITTING STILL, THE SPEEDOMETER READ 70 MPH. THE NEEDLE WILL NOT RETURN TO ZERO, EVEN WHEN THE VEHICLE IS PARKED.I HAVE CONTACTED THE DEALER AND WAS TOLD IT WOULD COST $400.00 TO $500.00 TO REPAIR. I CANNOT DRIVE THE VEHICLE, NOT KNOWING HOW FAST I AM GOING. *JB

SPEEDOMETER WAS TICKING UP AND DOWN RATHER THAN SMOOTHLY INCREASING AND DECREASING. WE USED CRUISE CONTROL WHEN ON A TRIP AND THEN THE SPEEDOMETER STARTED MALFUNCTIONING. SINCE THIS OCCURRED, THE SPEEDOMETER HAS BEEN STUCK PAST 120 MPH ON MULTIPLE OCCASIONS WHEN WE WERE GOING ABOUT 30. THIS IS CERTAINLY A SAFETY HAZARD FOR WHICH A RECALL SHOULD BE ISSUED. THIS COULD CAUSE AN ACCIDENT IF IT MALFUNCTIONS WHILE YOU ARE DRIVING AND YOU ARE UNABLE TO DETERMINE HOW FAST YOU ARE GOING. YOU WOULD TEND TO DRIVE SLOWER AND YOU COULD BE REAR-ENDED BY SOMEONE ELSE WHO WAS EITHER SPEEDING OR DOING THE CORRECT SPEED LIMIT. I WAS SURPRISED TO SEE THE NUMBER OF COMPLAINTS ABOUT THIS PROBLEM AND CHEVROLET HAS NOT STEPPED UP TO THE PLATE AND ACKNOWLEDGED THAT IT IS A MANUFACTURER DEFECT. I FOUND OUT ACCIDENTALLY THAT WHEN YOU START THE VEHICLE, THE SPEEDOMETER RESETS BY 5MPH. I WOULD HAVE TO START THE VEHICLE REPEATEDLY TO GET IT BACK TO ZERO. ALTHOUGH THIS IS NOT GOOD FOR THE STARTER, THIS WAS MY ONLY OPTION AT THE TIME. I JUST SAW SOMETHING ON THE INTERNET THAT SAID TO PUT THE VEHICLE IN REVERSE AND THEN TRY TO START IT. BY DOING THIS IT WOULD RESET THE SPEEDOMETER BY 5MPH EVERY TIME WITHOUT ENGAGING THE STARTER. THIS DID WORK, BUT WHEN I DROVE THE VEHICLE THE NEXT TIME, THE SPEEDOMETER DID NOT WORK AT ALL. I TRIED RESETTING THE SPEEDOMETER AGAIN BY PUTTING IT IN PARK AND STARTING, BUT TO NO AVAIL. AFTER TRYING MANY MORE TIMES TO RESET BY STARTING THE VEHICLE, THE SPEEDOMETER STARTED TO WORK. THIS IS UNACCEPTABLE AT EVERY LEVEL. THE CONSUMER SHOULD NOT HAVE TO BEG AND PLEAD TO GET A MANUFACTURER DEFECT FIXED. WHAT WILL IT TAKE TO CAUSE CHEVROLET TO FIX THIS DEFECT, ACCIDENTS OR FATALITIES? IF YOU LOOK AT THE WEBSITE HTTP://WWW.TOPIX.COM/FORUM/AUTOS/CHEVROLET-TAHOE/T2BGKBGI55EKNU77C/P3 YOU WILL SEE THIS IS A COMMON OCCURRENCE. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT NOTICED THAT THE CRUISE CONTROL TOOK AN EXTREMELY LONG TIME TO ACTIVATE. WHEN THE CRUISE CONTROL FINALLY ACTIVATED, THE VEHICLE JERKED AND MADE A LOUD REVVING NOISE. HE THEN NOTICED THAT THE RPM INCREASED FROM 1,800 TO APPROXIMATELY 4,300. HE TOOK THE VEHICLE TO THE DEALER AND THEY ACKNOWLEDGED THE FAILURE, BUT COULD NOT DETERMINE THE CAUSE. THE MANUFACTURER WAS UNABLE TO PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS 8,000 AND CURRENT MILEAGE WAS 49,000.

LAST WEEK, I FILLED UP MY GAS TANK AS USUAL. WHEN I WENT TO PULL OFF, THE GAS LIGHT FAILED TO GO OFF, THE GAS NEEDLE DID NOT MOVE AND THE BELL TO INDICATE THAT THE TANK WAS EMPTY WENT OFF. THE DEALER STATED THAT IT'S MY FUEL SENDING UNIT AND THAT HE'S SEEN SEVERAL OF THESE DEFECT LATELY...AND THAT I SHOULD CHECK FOR A RECALL. SINCE, I'VE HAD TO MONITOR WHEN I GAS UP AND HOW FAR I DRIVE...WHICH IS NOT ONLY FRUSTRATING, IT'S SCARY! THE NEEDLE NOW FLOATS FROM FULL TO EMPTY AND EVERYWHERE IN BETWEEN, BUT FOR THE MOST PART, IT RESTS ON E. VEHICLE IN QUESTION IS 2005 CHEVROLET TRAILBLAZER...THIS MODEL IS NOT GIVEN AS AN OPTION IN LATER SCREEN WHERE I ENTERED "SUBURBAN". I OWN A CHEVY TRAILBLAZER. THANK YOU *TR

WHILE DRIVING ON INTERSTATE WHEN SPEEDOMETER STARTED READING 80 THEN 90 THEN 100, THEN EVENTUALLY 120 MPH. PULLED OVER, SPEEDOMETER ONLY RETURNED TO 45. HAD TO START AND STOP ENGINE 7 TIMES TO GET TO RESET. HAPPENS APPROXIMATELY EVERY 2 WEEKS. CAN'T COUNT ON ITS ACCURACY FOR MY SAFETY IN DRIVING.*AK

DT*: THE CONTACT STATED WHILE DRIVING 35 MPH, THE SEAT BELT ON THE PASSENGER AND CENTER SECOND ROW SEATS CAME UNLATCHED ON THREE OCCASIONS. THE VEHICLE WAS DRIVEN TO THE DEALER EACH TIME WHERE THE BUCKLE ASSEMBLY WAS REPLACED TWICE, HOWEVER THE PROBLEM RECURRED. UPDATED 12/1/2006 - *NM

I HAVE HAD NOTHING BUT ELECTRICAL PROBLEMS EVER SINCE I BOUGHT THIS CAR. I DIDN'T EVEN HAVE THE CAR FOR A MONTH AND THE DASH LIGHTS AND HEAD LIGHTS WOULD DIM ON AND OFF BROUGHT THE CAR IN TO WHERE IT WAS PURCHASED FROM AND HAD MY CAR FOR A WEEK AND REPLACED CONTROL MODULE CAR STILL PROCEED TO DO THE SAME THING BROUGHT IT IN TO ANOTHER DEALERSHIP TOLD ME THAT THIS WAS NORMAL BECAUSE CAR HAD PCM AFTER 4 MONTHS OF GOING BACK AND FORTH WITH THESE DEALERSHIPS CAR WAS FINALLY FIXED DUE TO A RECALL IN A SCREW AND WIRE NOT BEING GROUNDED CORRECTLY. NOW MY CAR IS IN THE DEALERSHIP WITH NUMEROUS ELECTRICAL PROBLEMS AND ARE TRYING TO SAY THAT CAR WAS HIT BY LIGHTING CAR WOULD NOT START BURNING SMELL CAME FROM UNDERNEATH HOOD OF CAR. NOW CAR DOES NOT RUN OVER 15 MPH WITH DYING OUT BATTERY ONLY HOLD CHARGE OF 10 VOLTS. *JB

VEHICLE WAS IN SHOP ONE TIME ALL READY BECAUSE AIR BAG LIGHT CAME ON. TOOK IN FOR SERVICE THEY SAID LOOSE GROUND ALL FIXED. THEN ON 9/11/2006 I WAS INVOLVED IN AN ACCIDENT. A DRIVER FAILED TO YIELD WHILE MAKING A LEFT TURN. I HIT HIM BROAD SIDE AT 45 MILES PER HOUR. SMASHED FRONT END OF MY VEHICLE, SMASHED THE SIDE OF HIS VEHICLE IN BUCKLING HIS DASH AND HIS VEHICLE FLIPPED ON ITS SIDE. MY AIR BAGS DID NOT DEPLOY ON THE VEHICLE. I CONTACTED GM AND THEY SAID EVERYTHING IS OK, THEY SENT OUT A PERSON TO INVESTIGATE AND HE STATES THAT EVERYTHING IS OK. BUT AT THE SCENE OF THE ACCIDENT EVERY POLICE OFFICER DID NOT BELIEVE ME WHEN I TOLD THEM THE AIR BAGS DID NOT DEPLOY, NOR DID THE PARAMEDIC, THEY HAD TO GO LOOK FOR THEMSELVES AND SEE BECAUSE THEY THOUGHT THAT THEY SHOULD HAVE GONE OFF. I HAVE PICTURES OF BOTH VEHICLES IF YOU SHOULD NEED THEM. I FEEL THERE IS A SAFETY DEFECT. *NM

DT*: THE CONTACT STATED THAT THE VEHICLE WAS BUILT WITH WATER INSIDE THE TRANSMISSION. THE SERVICE DEALER DETERMINED IT WAS RAIN WATER. THE TRANSMISSION WAS CLEANED AND COMPLETELY RESEALED. A COWL WATER DEFLECTOR WAS ADDED TO SOLVE THIS ISSUE IN THE FUTURE. UPDATED 9/18/2006 - *NM

DT*: THE CONTACT STATED WHILE DRIVING 50 MPH ON A DRY HIGHWAY IN A PASSING SITUATION, A LIGHT STATING "REDUCED ENGINE POWER" ILLUMINATED IN THE VEHICLE. THE VEHICLE LOST A MAJORITY OF THE ENGINE POWER, AND THE TACHOMETER WOULD NOT PASS 1200 RPMS. THE VEHICLE WAS NOT IMMEDIATELY TAKEN IN FOR SERVICE.

DT*: THE CONTACT STATED WHILE BEING ON AN INCLINE AND WITH THE GEAR SHIFTER IN DRIVE THE VEHICLE ROLLS BACK IF THE BRAKES ARE NOT APPLIED. UPON INSPECTION THE DEALERSHIP DETERMINED THIS IS THE WAY THE VEHICLE WAS DESIGNED. UPDATED 4/14/2006 - *NM

STEERING WHEEL. WHEN I START MY VAN IT WANTS TO KEEP TURNING OVER. AND WHEN IT FINALLY STARTS, THE STEERING WHEEL LOCKS UP. THE CAR LOT THAT I BOUGHT IT FROM SAYS THERE'S NOTHING THAT THEY CAN FIND THAT WOULD CAUSE THIS PROBLEM. BUT IT KEEPS ACCRUING. THIS HAS NOTHING TO DO WITH THE DEALER. THEY DIDN'T MAKE MY VAN, GM MOTORS DID. I WANT TO MAKE IT CLEAR THAT THE DEALERS SERVICE DEPARTMENT WAS GREAT.*JB

DT*: THE CONTACT STATED THAT THE 2005 CHEVROLET SUBURBAN HAS NO QUICK EXIT FROM THE THIRD SEAT AND THE TAILGATE. IT TAKES TOO MUCH FORCE TO OPEN FROM THE INSIDE. THE VEHICLE IS SO LONG THE SIDE VIEW MIRRORS DO NOT SHOW THE ROAD VERY WELL EVEN AFTER ADJUSTMENTS ARE MADE. THE BRAKES ON THE VEHICLE TAKE TOO MUCH FORCE TO STOP THE VEHICLE IN AN EMERGENCY. LASTLY, THE PICKUP ON THE TRANSMISSION IS SLUGGISH WHICH IS A CONCERN IN EMERGENCY CONDITIONS WHEN ACCELERATING FROM A STOPPED POSITION. THE CONTACT SPOKE WITH THE DEALER, AND WAS REFERRED TO THE MANUFACTURER BECAUSE ALL ISSUES ARE WITH THE DESIGN OF THE VEHICLE.*AK

THIS IS A PRE-CAUTIONARY COMPLAINT AS A RESULT OF MY SHOCK REGARDING GM'S 8.1L ENGINE IN THE SUBURBANS. ALSO WOULD APPLY TO SILVERADO HD AS WELL. THE VEHICLE IS USING EXCESSIVE OIL WHICH TO MY SURPRISE GM SAYS IS NORMAL. OIL USAGE IS 1.25 QTS PER 2000 MILES AND GM INDICATED THAT THE VEHICLE COULD USE AS MUCH AS 1QT PER 1000 MILES (ASSUMING 10 MILES TO THE GALLON). THE CONCERN IS REGARDING EMISSIONS DURABILITY AND INDIRECT FAILURES AS A RESULT OF THIS OIL LOADING INTO THE EXHAUST AND CATALYTIC CONVERTER. GM WOULD NOT PROVIDE DETAILS TO ME BUT, INDUSTRY NORMS ARE ASSUMING WORST CASE 1/2 OF THIS LEVEL OF EXPECTED OIL USAGE. GM WAS UNCONCERNED AND HAS A BULLETIN FOR THEIR DEALERS STATING THIS. I FEEL THIS SHOULD BE INVESTIGATED BOTH FROM A SAFETY STANDPOINT FOR POTENTIAL ENGINE FAILURE AND FOR EMISSIONS DURABILITY AND ENVIRONMENTAL COMPLIANCE. *JB

FAULTY TRANSMISSION AND PRESSURE PUMP. *NM

ON TWO OCCASIONS MY 2005 SUBURBAN HAS STAYED ON CRUISE CONTROL EVEN AFTER TURNING OFF CRUISE CONTROL. MY VEHICLE KEPT A CONSTANT SPEED AT WHICH IT WAS SET WHEN I HAD THE CRUISE CONTROL ON. THIS HAS OCCURRED ON FLAT HIGHWAYS. I WAS NOT DESCENDING. *JB

CONSUMER 2005 CHEVY SUBURBAN NAVIGATION GIVES INCOMPLETE DATA. *TS THE DEALER SUGGESTED TO THE CONSUMER THAT HE BORROW THE LATEST VERSION DVD VERSION 4.1 TO SEE IF THE SITUATION IMPROVES. *JB

WHILE DRIVING OUR 2005 SUBURBAN ON THE INTERSTATE, THE CHECK TIRE PRESSURE INDICATOR CAME ON AND IMMEDIATELY THE BACK END BECAME SQUIRRELLY. PULLING TO THE SIDE OF THE ROAD, THE PASSENGER SIDE REAR TIRE WAS COMPLETELY BLOWN AT THE SIDEWALL. THE TREAD CAUGHT ONTO THE WHEEL WELL FLARE, CAUSING ABOUT $500 IN DAMAGE TO THE VEHICLE. THE TIRE WAS ORIGINAL EQUIPMENT ON THE SUBURBAN, A P265/70R16 FIRESTONE WILDERNESS RADIAL. THE VIN NUMBER ON THE SUBURBAN IS [XXX]. THE TIRES HAD ABOUT 12,000 MILES OF USAGE WHEN THE BLOWOUT HAPPENED. I CONTACTED GM (SERVICE REQUEST CLAIM #[XXX]) AND HAD THE SERVICE MANAGER AT JOHN SERETTI CHEVROLET IN MOON, PA INSPECT THE TIRE. HE COULD FIND NO PUNCTURES, FOREIGN OBJECTS OR OTHER EVIDENCE OF EXTERNAL DAMAGE TO THE TIRE. GM REVIEWED THIS AND INFORMED ME THAT THEY DID NOT HAVE ENOUGH INFORMATION TO DECLARE A DEFECT, SO THEY REFERRED ME TO THE TIRES MANUFACTURER, FIRESTONE. THE FIRESTONE SHOP IN MOON, PA ALSO COULD NOT FIND ANY PUNCTURE OR EXTERNAL DAMAGE. THE MANAGER THERE SAID THE BLOWOUT COULD HAVE HAPPENED FOR ANY NUMBER OF REASONS OTHER THAN A DEFECT AND TRIED TO SUGGEST THAT IT HAD BEEN DRIVEN WITH TOO LITTLE TIRE PRESSURE. THAT CANNOT BE THE CASE. THE TIRES HAD BEEN ROTATED AND THE AIR PRESSURE CHECKED BY THE DEALERSHIP WITHIN THE PREVIOUS MONTH AND THE VEHICLE IS EQUIPPED WITH AN AIR PRESSURE SENSOR THAT WARNS OF DROPS. THAT SENSOR WENT OFF AT THE SAME TIME THE TIRE BLEW. FIRESTONE SOLD US A REPLACEMENT TIRE AT A PRORATED COST BASED ON THE USAGE FROM THE ORIGINAL. *JB UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

WHILE DRIVING INTO WORK THE REAR END HOUSING EXPLODED AND THE DRIVE SHAFT DROPPED TO PIECES BOTH FLEW ALL OVER THE HIGHWAY SOME COMING OUT RED HOT. *JB

GENERAL MOTORS RECENTLY ANNOUNCED AN SUV/TRUCK RECALL FOR DEFECTIVE AND UNSAFE ANTI-LOCK BRAKE SYSTEMS. THE RECALL WENT INTO EFFECT IN 14 COLD-WEATHER STATES AND CANADA...BUT IT EXCLUDED WISCONSIN!!!! IT DID SO BECAUSE GM SAID IT DIDN'T HAVE ENOUGH COMPLAINTS FROM WISCONSIN. THAT'S LUDICROUS! MANY HERE HAD THE SAME PROBLEMS AS IN IOWA, MICHIGAN, AND ALL THE REST. I EXPERIENCED THE PROBLEM, TOOK MY 2001 SUBURBAN TO MY GM DEALER FOR REPAIRS, AND WAS TOLD I'D BE REIMBURSED SUBJECT TO THE RECALL. THEN THE WISCONSIN EXCLUSION WAS ANNOUNCED. MANY PEOPLE HERE WILL BE OPERATING UNSAFE VEHICLES...AND THAT'S NOT RIGHT! PLEASE HELP. MARK & SHARON LEIDER. *NM

THE ANTILOCK BRAKES COME ON AT LOW SPEED, WHICH IS STARTLING AND INCREASES STOPPING DISTANCE. THIS DEFECT IS ACKNOWLEGED BY GENERAL MOTORS, THOUGH THEY REFUSE TO ISSUE A RECALL. THEY TELL ME TO PAY FOR IT MYSELF. I AM AFRAID THAT THIS DEFECT WILL CAUSE AN ACCIDENT.

DT: THE VEHICLE HAS BEEN IN THE SHOP 3 TIMES FOR TRANSMISSION PROBLEMS. THE DEALER HAS CHANGED DIFFERENT PARTS, HOWEVER THE PROBLEM CONTINUED. *JB

2001 CHEVROLET SUBURBAN K-1500 4WD; WAS DRIVING AT LOW SPEED ~10-15 MPH AND APPLIED BRAKES HARD WITH SUDDEN AND UNEXPECTE LOSS OF BRAKES RESULTING IN MVA AND DAMAGE TO THREE VEHICLES, INCLUDING MY OWN

MANUFACTURER PROMISED TO PURCHASE CONSUMER'S VEHICLE DUE TO THE HYDROBOOST BRAKE RECALL. THEY PROMISED TO MAKE THE FIRST PAYMENT UPON RECEIPT OF THE NEW VEHICLE. OWNER HAD IN HER POSSESSION AN ALERT BULLETIN ABOUT THE HYDROBOOST. NEITHER MANUFACTURER NOR DEALERSHIP CLAIMED RESPONSIBILITY. NOTICE STATED, EFFECTIVE IMMEDIATELY TO STOP DELIVERY AND ANY PURCHASES FOR THE SUBURBANS AND OTHER GM TRUCKS DATED FEBRUARY 4, 2005. HIGHLIGHTED SENTENCE STATED NOT TO ALLOW CONSUMERS TO PURCHASE. *AK

2005 CHEVROLET SUBURBAN (LESS THAN 1 WEEK OLD) -CAR WAS PLACED INTO PARK ON A DRIVEWAY WITH HILL -PARKING FOOT BRAKE WAS ENGAGED -I LEFT THE VEHICLE AND STARTED WALKING INTO THIS HOUSE -AT 30 YDS I HEARD SOMETHING BEHIND ME AND TURNED TO REALIZE THE CAR WAS ROLLING -I RAN BACK, JUMPED INTO THE CAR AND SLAMMED THE BRAKE ON -I TESTED THIS 3 MORE TIMES AND REPEATED THIS CONDITION. -THE DASHBOARD INDICATOR IS SAYING THE CAR IS IN PARK, BUT IT IS NOT LOCKING -AN ADDITIONAL CONCERN WAS THAT PARKING BRAKE DID NOT HOLD UP WITH 3 CHILDREN IN MY HOUSEHOLD THIS IS A MAJOR CONCERN. NOT TO MENTION IT NEARLY RAN ME OVER. THIS IS A BRAND NEW CAR!!! NOT MORE THAN 400 MILES ON IT. CAR IS CURRENTLY BEING LOOKED AT BY THE CHEVY DEALER. THIS IS SERIOUS AND THOUGHT IT WAS IMPORTANT TO INFORM THE AGENCY.I*=*AK -

THE DRIVER AND PASSENGER'S SIDE MIRRORS FAILED. THE OBJECTS APPEARED FAR AWAY THAN NORMAL. THIS CAUSED POOR VISIBILITY. THE VEHICLE HAD A TOW MIRROR PACKAGE. THE CONSUMER TOOK THE VEHICLE TO THE DEALER FOR INSPECTION, AND THE MECHANIC DETERMINED THAT THIS WAS A DESIGN FLAW FROM THE MANUFACTURER. THE MECHANIC INFORMED THE CONSUMER THAT THE MIRROR COULD BE REPLACED, BUT THE DRIVER HAD TO PAY FOR IT. *AK THE FOUR WHEEL DRIVE LIGHT HAD COME ON. *SC